NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
11 reportsClear category filterMileage unknown · Nov 13, 2023
EngineSteering
My engine went out, and I had to have it rebuilt. There was a check engine light on. My steering goes out and in without warning while driving. I have talked to the dealership, and they stated that all safety recalls were done on my vehicle. My safety and those of others were put at risk when the steering failed. I almost crashe…
Read full complaint
My engine went out, and I had to have it rebuilt. There was a check engine light on. My steering goes out and in without warning while driving. I have talked to the dealership, and they stated that all safety recalls were done on my vehicle. My safety and those of others were put at risk when the steering failed. I almost crashed my vehicle in traffic. There were no warning messages prior to the failure. I did see that there was a recall in 2019 and the dealership will not inspect the vehicle without payment.
NHTSA ODI #11554898
Mileage unknown · Sep 4, 2023
Electrical SystemSteeringUnknown Or Other
My car is giving me all kinds of warnings, parking assist off, rear back up, trailer brake, the radio sounds go off, blinker sounds go off, while trying to park power steering locks up, it will die in the middle of a turn. It’s doing everything The 2015 recall was created for. I do not think my car was fixed during the recall pe…
Read full complaint
My car is giving me all kinds of warnings, parking assist off, rear back up, trailer brake, the radio sounds go off, blinker sounds go off, while trying to park power steering locks up, it will die in the middle of a turn. It’s doing everything The 2015 recall was created for. I do not think my car was fixed during the recall period. It is very hazardous.
NHTSA ODI #11542538
Mileage unknown · Sep 13, 2022
Steering
My Wife was driving at a low speed completing a right hand turn through an intersection and as she completed the turn the vehicle completely lost all steering. The vehicle ran up onto a curb but she was able to stop before she hit a poll. The vehicle was towed home and I found that there was no power to the steering wheel contro…
Read full complaint
My Wife was driving at a low speed completing a right hand turn through an intersection and as she completed the turn the vehicle completely lost all steering. The vehicle ran up onto a curb but she was able to stop before she hit a poll. The vehicle was towed home and I found that there was no power to the steering wheel controls, the horn didn't work and there were Electronic Steering warnings. I also found that the steering wheel could spin freely like a top without any movement of the wheels. Upon examination in the engine compartment I found that the bottom of the steering shaft was completely disconnected and the single bolt that holds the 2 pieces together was missing. I took the vehicle to the local GMC dealership and they conformed that the bolt was missing and the shafts came apart which lead to the steering failure. The free movement of the steering wheel caused the internal malfunction of the steering wheel electronics. Prior to the steering failure there was no indications of any steering issues. The steering warning lights didn't come on until the steering failure. My Wife and children were about to get on the freeway when the failure occurred and could have led to a fatal accident if this failure occurred while she was driving on the freeway. I contacted GM and opened a case but was informed that they would not provide any assistance with the repair which is about $2900. I don't understand how GM would design a steering shaft that has a single point failure that could lead to a catastrophic failure. The vehicle has 120K miles and has never been in any accidents. I expect a basic safety feature such as the steering to never fail during operation. I will never purchase another GM vehicle and will tell as many people as I can about the potential failure. GM case# [XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA ODI #11484325
125,000 miles · Aug 10, 2022
Steering
The contact owns a 2015 GMC Yukon Denali XL. The contact stated that while driving at 75 MPH, the steering wheel hardened as both a warning chime and a service power steering warning message appeared on the instrument panel. The contact stated that he crossed two lanes of traffic before gaining control of the vehicle's power ste…
Read full complaint
The contact owns a 2015 GMC Yukon Denali XL. The contact stated that while driving at 75 MPH, the steering wheel hardened as both a warning chime and a service power steering warning message appeared on the instrument panel. The contact stated that he crossed two lanes of traffic before gaining control of the vehicle's power steering. Excessive force was used to steer the vehicle to his place of work. The contact called several dealers as well as the manufacturer who all informed him that his vehicle was not included in NHTSA Campaign Number: 14V719000 (Steering). The vehicle had yet to be repaired. The failure mileage was approximately 125,000.
NHTSA ODI #11478575
75,000 miles · Oct 20, 2021
Electrical SystemSteering
The contact owns a 2015 GMC Yukon. The contact stated that while operating the vehicle, the power steering malfunctioned causing the steering wheel to become very difficult to turn in either direction. The contact indicated that recently when the failure occurred the vehicle also shut off nearly causing a crash. The vehicle was …
Read full complaint
The contact owns a 2015 GMC Yukon. The contact stated that while operating the vehicle, the power steering malfunctioned causing the steering wheel to become very difficult to turn in either direction. The contact indicated that recently when the failure occurred the vehicle also shut off nearly causing a crash. The vehicle was taken to the local dealer who diagnosed that the battery cables needed to be replaced. The vehicle was not yet repaired. The contact indicated that the vehicle was previously serviced under the NHTSA Campaign Number: 18V586000 (Steering) however, the failure recurred intermittently. The manufacturer was notified of the failure. The failure mileage was 75,000.
NHTSA ODI #11437454
Mileage unknown · Dec 4, 2020
Forward Collision AvoidanceLane DepartureSteering
WHILE DRIVING ON HIGHWAY INSTITUTE STEERING POWER AND COULD BARELY CONTROL THE STEERING WHEEL WHILE POWER ASSIST WARNING, STABILIZE,AIRBAG LIGHT AND PASSENGER WINDOWS WOULDN'T GO UP.
NHTSA ODI #11377975
70,000 miles · Jan 9, 2020
Electrical SystemSteering
TL* THE CONTACT OWNS A 2015 GMC YUKON XL. THE CONTACT STATED THAT WHILE DRIVING AT LOW SPEEDS WITHOUT WARNING, THE STEERING WHEEL BECAME DIFFICULT TO OPERATE IN EITHER DIRECTION. ON SEVERAL OCCASIONS, THE VEHICLE ALSO STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THOMPSON BUICK GMC LOCATED AT 2600 WAKE FOREST RD. RALEIGH NC,…
Read full complaint
TL* THE CONTACT OWNS A 2015 GMC YUKON XL. THE CONTACT STATED THAT WHILE DRIVING AT LOW SPEEDS WITHOUT WARNING, THE STEERING WHEEL BECAME DIFFICULT TO OPERATE IN EITHER DIRECTION. ON SEVERAL OCCASIONS, THE VEHICLE ALSO STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THOMPSON BUICK GMC LOCATED AT 2600 WAKE FOREST RD. RALEIGH NC, 27609, (919)809-6217, TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE STEERING GEAR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT YET REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000.
NHTSA ODI #11298106
64,000 miles · Apr 30, 2019
Steering
WHEN PARKING THE STEERING WHEEL LOCKS UP, THE MONITOR THAT PLAYS THE RADIO SHUTS OF AND MY SPEEDOMETER MONITOR SHOWS 3 TO 4 DIFFERENT WARNINGS SUCH AS BRAKE ASSIST OFF, PARK ASSIST OFF, STABILITRAK AND POWER STEERING. THIS IS WHILE THE CAR IS IN MOTION AS WELL AS WHEN I PUT IT IN PARK.
NHTSA ODI #11204771
Mileage unknown · Mar 19, 2019
Power TrainSteering
I WAS DRIVING UP NORTH IN 4WHEEL DRIVE AND TRANSMISSION CAM OUT OF GEAR I STOPPED THE VECHILE AND RESTARTED NOW THE TRANSMISSION DOES NOT SHIFT PROPERLY AND STEERING IS HARD TO STEER AND IT GOES IN AND OUT
NHTSA ODI #11190131
78,000 miles · Feb 5, 2019
Electronic Stability Control (esc)Exterior LightingSteering
THIS IS THE SECOND COMPLAINT THAT I HAVE MADE TO NHTSA. THE FIRST TIME, THE VEHICLE WAS SPONTANEOUSLY TURNING OFF AND SHUTTING DOWN DURING BACKING IN AND TURNS CAUSING A SAFETY ISSUE. THIS RESULTED IN A RECALL, AND A "SOFTWARE UPDATE" THAT WAS DONE TWICE TO CORRECT THE ISSUE. RIGHT AND BACK PASSENGER LIGHTS BEGAN TO BLINK ON …
Read full complaint
THIS IS THE SECOND COMPLAINT THAT I HAVE MADE TO NHTSA. THE FIRST TIME, THE VEHICLE WAS SPONTANEOUSLY TURNING OFF AND SHUTTING DOWN DURING BACKING IN AND TURNS CAUSING A SAFETY ISSUE. THIS RESULTED IN A RECALL, AND A "SOFTWARE UPDATE" THAT WAS DONE TWICE TO CORRECT THE ISSUE. RIGHT AND BACK PASSENGER LIGHTS BEGAN TO BLINK ON AND OFF AND WATER GETS INTO THE BRAKE LIGHT. THE DEALER TOLD ME THIS WAS M ISSUE. THIS TIME THE 4WD SERVICE LIGHT CAME AND THE CAR APPEARED TO BE STUCK IN "4WD LOW" MAKING IT "DRAG" AT A REDUCED SPEED WHEN DRIVING. ALSO, THE "SERVICE TRAILER BRAKE" LIGHT CAME ON REPEATEDLY. I HAVE NEVER USED THE TRAILER BRAKE. I TOOK IT INTO AN AUTHORIZED DEALER, SELLERS GMC IN FARMINGTON HILLS, MI. THEY TOLD ME I NEEDED A NEW "MODULE", SO I PAID TO HAVE THAT DONE. WITHIN ONE DAY THE SAME SERVICE LIGHTS CAME ON AGAIN. "SERVICE 4 WD" AND "SERVICE TRAILER BRAKE." I IMMEDIATELY TOOK THE VEHICLE BACK AND AM NOW BEING TOLD IT NEEDS ANOTHER SOFTWARE UPDATE AND A NEW TRAILER BRAKE TRANSFER SWITCH. QUITE FRANKLY, I BELIEVE THAT THIS MODEL HAS SIGNIFICANT, UNADDRESSED COMPUTER SOFTWARE ISSUES AND THE DEALER DOES NOT KNOW WHO TO FIX IT. THE CAR IS UNSAFE BECAUSE IT SPONTANEOUSLY STOPS WORKING APPROPRIATELY DURING DRIVING. THE CONCERNS HAVE BEEN VARIOUS AND ALWAYS SEEM TO AFFECT STEERING, WHEN TURNING OR BACKING IN. I AM BEING CHARGED FOR VARIOUS CONTROL PANELS AND MODULES. I AM REQUESTING THAT THIS CONCERN GETS ADDRESSED BEFORE THERE IS A SERIOUS INJURY. I WOULD LIKE MY VEHICLE FIXED AND RETURNED TO A SAFE CONDITION. I WAS NEVER TOLD UPON PURCHASE, THAT THIS MODEL WOULD REQUIRE SO MANY "SOFTWARE" UPDATES TO REMAIN SAFE. THIS SHOULD NOT BE A BURDEN PLACED ON A CONSUMER FOR A VEHICLE TO OPERATE SAFELY. THIS IS DANGEROUS.
NHTSA ODI #11174459
Official recalls
2Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE18012 · Brake Vacuum Pump Failure
Opened Nov 20, 2018 · Closed Apr 10, 2022
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Additional source detail variants (3)
Service Brakes
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Illustration