IllustrationWHEN COMING TO A STOP, THE BRAKE PEDAL BECAME STIFF AND DID NOT ENGAGE. THIS HAS HAPPENED ON MULTIPLE OCCASIONS IN THE PAST, AND HAPPENS WHEN THE VEHICLE IS TRAVELING AT SLOW SPEEDS (LESS THAN 5MPH). THE ISSUE IS A FAULTY POWER BREAK PUMP.
2015 GMC Yukon Xl
Owner reports · Recalls · Investigations
More warning signs than most Yukon Xl years
Owner complaints for the 2015 GMC Yukon Xl are substantially higher than the model-year median of 68.
About this comparison →How this year compares
Owner complaints by model year
Compare all Yukon Xl years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
120–25K
3025–50K
7150–75K
4775–100K
33100–150K
7150K+
200 reports with mileage · 106 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 140 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports3 fire reports2 injury reports
Service Brakes complaints
62 reportsTODAY, WHILE COMING TO A STOP, THE BRAKE PEDAL BECAME STIFF AND DID NOT ENGAGE. THIS HAS HAPPENED ON MULTIPLE OCCASIONS IN THE PAST, AND HAPPENS WHEN THE VEHICLE IS TRAVELING AT SLOW SPEEDS (LESS THAN 5MPH).
WE PURCHASED THIS VEHICLE ON 11.21.18 AND THE BRAKE LIGHTS INTERMITTENTLY DON'T WORK. THEY WERE WORKING AT THE TIME WE DROVE IT OFF THE LOT. THE BULBS WERE TESTED BY OUR MECHANIC AND HE STATED THAT THE GMC YUKON OF THIS YEAR ARE KNOWN TO HAVE MAJOR PROBLEMS WITH THE BRAKE LIGHT HOUSING UNITS ON THE REAR OF THE VEHICLE. THE EL…
Read full complaint
WE PURCHASED THIS VEHICLE ON 11.21.18 AND THE BRAKE LIGHTS INTERMITTENTLY DON'T WORK. THEY WERE WORKING AT THE TIME WE DROVE IT OFF THE LOT. THE BULBS WERE TESTED BY OUR MECHANIC AND HE STATED THAT THE GMC YUKON OF THIS YEAR ARE KNOWN TO HAVE MAJOR PROBLEMS WITH THE BRAKE LIGHT HOUSING UNITS ON THE REAR OF THE VEHICLE. THE ELECTRICAL BOARD ASSOCIATED WITH IT HAS ISSUES THE MECHANIC STATED. I REVIEWED MANY POST ONLINE AND WONDER WHY THIS ISN'T A REQUIRED RECALL. TO ME THIS IS A MAJOR SAFETY CONCERN AND WE BOUGHT THIS VEHICLE TO TRANSPORT MY KIDS AND WIFE. I'D LIKE THIS TO BE CONSIDERED A RECALL IMMEDIATELY.
TL* THE CONTACT OWNS A 2015 GMC YUKON XL. WHILE DRIVING 5 MPH AND LOW SPEEDS, THE BRAKES SEIZED. WHEN DRIVING AT HIGHER SPEEDS, THE BRAKES PERFORMED PROPERLY. THE CONTACT WOULD HAVE TO PLACE THE VEHICLE IN NEUTRAL AND REV THE ENGINE FOR THE BRAKES TO WORK. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO SE…
Read full complaint
TL* THE CONTACT OWNS A 2015 GMC YUKON XL. WHILE DRIVING 5 MPH AND LOW SPEEDS, THE BRAKES SEIZED. WHEN DRIVING AT HIGHER SPEEDS, THE BRAKES PERFORMED PROPERLY. THE CONTACT WOULD HAVE TO PLACE THE VEHICLE IN NEUTRAL AND REV THE ENGINE FOR THE BRAKES TO WORK. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO SEILVEIRA BUICK GMC (985 HEALDSBURG AVE, HEALDSBURG, CA 95448, (866) 572-7256) WHERE IT WAS DIAGNOSED THAT A NEW VACUUM PUMP NEEDED TO BE INSTALLED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 105,000.
WHILE IN MOTION THE BRAKES WENT OUT COMPLETELY IN JULY 2015. THEN WHILE DRIVING DOWN THE INTERSTATE AT 75 MPH THE BRAKES WENT OUT COMPLETELY IN 2018. BOTH TIMES I WAS CHARGED A DEDUCTIBLE. BOTH TIMES THE COMPLETE BRAKE SYSTEM WAS COMPLETELY REPLACED BY A DEALERSHIP. AFTER THE SECOND INCIDENT I CONTACTED GMC. AFTER NUMEROUS PHO…
Read full complaint
WHILE IN MOTION THE BRAKES WENT OUT COMPLETELY IN JULY 2015. THEN WHILE DRIVING DOWN THE INTERSTATE AT 75 MPH THE BRAKES WENT OUT COMPLETELY IN 2018. BOTH TIMES I WAS CHARGED A DEDUCTIBLE. BOTH TIMES THE COMPLETE BRAKE SYSTEM WAS COMPLETELY REPLACED BY A DEALERSHIP. AFTER THE SECOND INCIDENT I CONTACTED GMC. AFTER NUMEROUS PHONE CALLS THE OFFERED ME $2000 TOWARDS A NEW VEHICLE. I WAS VERY UPSET WITH THEM AND THREATENED TO GET A LAWYER IF I WAS HURT IN THIS VEHICLE OR HURT OTHERS IN THE FUTURE. IT WAS A TERRIFYING EXPERIENCE AND I FELT LIKE I DESERVED MORE. THEY WOULDN'T EVEN PAY FOR THE RENT A CAR I HAD TO USE ON MY VACATION WHILE THE BRAKE SYSTEM WAS REPLACED. I PAID $70,0000 FOR THIS CAR, BUT DON'T WANT TO FEAR LOOSING BRAKES EVER AGAIN!
WHILE OPERATING THE VEHICLE AND ATTEMPTING A STOP THE BRAKING BECAME POOR AND I HAD TO DEPRESS THE BRAKE PEDAL AS HARD AS I COULD. HOWEVER, EVEN AFTER THAT THE VEHICLE DID NOT STOP RIGHT AWAY AND TOOK MORE DISTANCE TO COME TO A FULL STOP. THE BRAKE FELT "SOFT" AND NOT LIKE IT USUALLY DOES. INTERESTINGLY...THE BRAKE WOULD SEEM…
Read full complaint
WHILE OPERATING THE VEHICLE AND ATTEMPTING A STOP THE BRAKING BECAME POOR AND I HAD TO DEPRESS THE BRAKE PEDAL AS HARD AS I COULD. HOWEVER, EVEN AFTER THAT THE VEHICLE DID NOT STOP RIGHT AWAY AND TOOK MORE DISTANCE TO COME TO A FULL STOP. THE BRAKE FELT "SOFT" AND NOT LIKE IT USUALLY DOES. INTERESTINGLY...THE BRAKE WOULD SEEM TO WORK AGAIN IMMEDIATELY AFTER THE INCIDENT. I'VE HAD PROBABLY 3 OR 4 INCIDENTS, OVER THE PAST YEAR, WHERE THIS HAS HAPPENED. NONE OF THE INCIDENTS HAVE RESULTED IN ANY TRAFFIC INCIDENTS, BUT ALL HAVE REQUIRED MORE STOPPING DISTANCE THAN NORMAL. ALL OF THE INCIDENTS HAVE TYPICALLY OCCURRED AT LOWER SPEEDS (LESS THAN 40 MPH).
WHEN MOVING IN A PARKING SPOT THE BRAKE PEDAL BECAME HARD AS IF IT LOST POWER BRAKES, BUT THEN RETURNED. A FEW DAYS LATER ON THE FREEWAY TRAFFIC STOPPED IN FRONT OF US AND IT HAPPENED AGAIN. THIS CAUSED US TO NEED TO SWERVE TO AVOID CAUSING AN ACCIDENT UNTIL WE WERE ABLE TO COME TO A STOP. AFTER SEVERAL MILES THE POWER BRAKES HA…
Read full complaint
WHEN MOVING IN A PARKING SPOT THE BRAKE PEDAL BECAME HARD AS IF IT LOST POWER BRAKES, BUT THEN RETURNED. A FEW DAYS LATER ON THE FREEWAY TRAFFIC STOPPED IN FRONT OF US AND IT HAPPENED AGAIN. THIS CAUSED US TO NEED TO SWERVE TO AVOID CAUSING AN ACCIDENT UNTIL WE WERE ABLE TO COME TO A STOP. AFTER SEVERAL MILES THE POWER BRAKES HAVE NOT RETURNED. THERE IS OIL IN THE VACUUM LINE AT THE BOOSTER AND GAS MILEAGE YA BEEN POOR THE PAST FEW WEEKS PRIOR TO THIS. IT ALL POINTS TO A FAULTY VACUUM PUMP. 121,000 MILES ON THE TRUCK.
BRAKE VACUUM PUMP FAILED. WHILE TOWING A BOAT AND BACKING UP MY BRAKE PEDAL WENT HARD WHEN I PUSHED DOWN AND MY VEHICLE WOULD NOT STOP. I WAS ABLE TO STEER OUT OF DANGER AND EVENTUALLY COME TO A STOP.
MY PASSENGER FRONT LIGHT COVER IS ACQUIRING CONDENSATION WHICH MAKES THE LIGHTS GO OFF AND ON, AND MY DRIVER SIDE BRAKE LIGHT WORKS ONLY INTERMITTENTLY. MY INSURANCE OR WARRANTY WON'T COVER ANYTHING TO FIX THESE LIGHT ISSUES. THESE ISSUES STARTED ABOUT MAY 2018. WE WEREN'T IN A WRECK OR SUSTAINED ANY DAMAGES THAT WOULD HAVE L…
Read full complaint
MY PASSENGER FRONT LIGHT COVER IS ACQUIRING CONDENSATION WHICH MAKES THE LIGHTS GO OFF AND ON, AND MY DRIVER SIDE BRAKE LIGHT WORKS ONLY INTERMITTENTLY. MY INSURANCE OR WARRANTY WON'T COVER ANYTHING TO FIX THESE LIGHT ISSUES. THESE ISSUES STARTED ABOUT MAY 2018. WE WEREN'T IN A WRECK OR SUSTAINED ANY DAMAGES THAT WOULD HAVE LED TO THESE ISSUES. I HAVE TALKED TO TWO OTHER OWNERS OF THE SAME MAKE/MODEL/YEAR VEHICLE AND WE ALL HAVE SAFETY ISSUES THAT ARE NOT BEING RESOLVED BY GM VWARRANTIES. I WANT TO SEE GM ISSUE RECALLS AND ACCEPT COMPLETE FINANCIAL RESPONSIBILITY FOR REPAIRS. I WOULD ALSO LIKE TO SEE THE REAR LIGHTING SYSTEM REDESIGNED SO THE COMPONENTS ARE NOT DEPENDENT ON EACH OTHER. MY BRAKE LIGHT WENT OUT AND INSTEAD OF BEING ABLE TO REPLACE A BULB THE ENTIRE UNIT HAS TO BE REPLACED AT $1700.00 THAT WE JUST SIMPLY DO NOT HAVE.
MY RIGHT SIDE BRAKE ASSEMBLY SEEMS TO ONLY WORK WHEN IT WANTS TOO. WORKS ON COLD MORNINGS, BUT AS THE DAY GETS WARMER THE LIGHT ASSEMBLY DOESN'T WORK ANYMORE. NO LIGHTS, OR BRAKE LIGHTS.
Official recalls
217V437000 · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
16V651000 · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE18012 · Brake Vacuum Pump Failure
Opened Nov 20, 2018 · Closed Apr 10, 2022
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Additional source detail variants (3)
Service Brakes
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.