IllustrationISSUE WHEN BRAKING. LOTS OF FORCE NEEDED AT TIMES TO STOP.SEEMS TO OCCUR MORE AT SLOWER SPEEDS.
2015 GMC Yukon Xl
Owner reports · Recalls · Investigations
More warning signs than most Yukon Xl years
Owner complaints for the 2015 GMC Yukon Xl are substantially higher than the model-year median of 68.
About this comparison →How this year compares
Owner complaints by model year
Compare all Yukon Xl years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
120–25K
3025–50K
7150–75K
4775–100K
33100–150K
7150K+
200 reports with mileage · 106 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 140 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports3 fire reports2 injury reports
Service Brakes complaints
62 reportsTHE BRAKES FAILED IN MY CAR CAUSING A REAR COLLISION WITH AN OBJECT IN MY DRIVEWAY. AFTER INSPECTION FROM A CERTIFIED GMC DEALERSHIP, THE BRAKE FAILURE WAS NOT CAUSED BY SERVICE NEGLECT OR AGE OF BRAKES, IT WAS DUE TO THE VACCUM PUMP FAILURE TO PROVIDE PRESSURE. THIS IS THE SECOND TIME IN TWO YEARS THIS PART HAS CAUSED MY BRAK…
Read full complaint
THE BRAKES FAILED IN MY CAR CAUSING A REAR COLLISION WITH AN OBJECT IN MY DRIVEWAY. AFTER INSPECTION FROM A CERTIFIED GMC DEALERSHIP, THE BRAKE FAILURE WAS NOT CAUSED BY SERVICE NEGLECT OR AGE OF BRAKES, IT WAS DUE TO THE VACCUM PUMP FAILURE TO PROVIDE PRESSURE. THIS IS THE SECOND TIME IN TWO YEARS THIS PART HAS CAUSED MY BRAKES TO FAIL. THE DEALERSHIP REPLACED THE PART AT NO COST THOUGH THERE IS NOT FORMAL RECALL ON THIS PART. BOTH TIMES THIS PART FAILED THE CAR WAS IN MOTION. THE FIRST TIME IT WAS TOWED OUT OF A CITY TO BE REPAIRED AS IT WAS DANGERSOUS TO DRIVE AND THE SECOND TIME THE FAILURE CAUSED THE VEHICLE TO COLLIDE WITH A LARGE DUMPSTER IN MY DRIVEWAY CAUSING EXTENSIVE DAMAGE TO THE REAR PASSENGER SIDE OF THE CAR. THANKFULLY THERE WAS NOT PHYSICAL DAMAGE TO ANY PERSONS IN EITHER OF THESE TWO INCIDENTS WHICH BOTH WERE NO FAULT OF THE DRIVER OR OWNER OF THE CAR.
THE BRAKES ON MY 2015 GMC YUKON SUDDENLY BECAME EXTREMELY DIFFICULT TO OPERATE WITH VERY HARD BRAKE PEDAL AND INCREASED STOPPING DISTANCE. I WAS ABLE TO BRING THE VEHICLE TO THE DEALER FOR SERVICE. THEY INFORMED ME THAT THERE WAS NO OUTPUT FROM THE ENGINE VACUUM PUMP TO THE BRAKE BOOSTER AND IT WOULD BE ADDRESSED UNDER A SPEC…
Read full complaint
THE BRAKES ON MY 2015 GMC YUKON SUDDENLY BECAME EXTREMELY DIFFICULT TO OPERATE WITH VERY HARD BRAKE PEDAL AND INCREASED STOPPING DISTANCE. I WAS ABLE TO BRING THE VEHICLE TO THE DEALER FOR SERVICE. THEY INFORMED ME THAT THERE WAS NO OUTPUT FROM THE ENGINE VACUUM PUMP TO THE BRAKE BOOSTER AND IT WOULD BE ADDRESSED UNDER A SPECIAL COVERAGE WARRANTY FROM GM REPAIRED. HOWEVER, AFTER FIXING THE COVERED PART OF THE VACUUM PUMP ASSEMBLY, THEY INDICATED THAT THE PROBLEM WAS STILL PREVALENT AND DETERMINED THEY ALSO NEEDED TO REPLACE THE BRAKE BOOSTER THAT WAS ALSO AT FAULT. THE BRAKE BOOSTER WAS NOT COVERED UNDER THE SPECIAL COVERAGE AND RESULTED IN A SIGNIFICANT CHARGE. IT SEEMS THAT THE BRAKING SYSTEM ISSUES ARE RELATED AND NEEDS TO BE LOOKED INTO FURTHER.
2015 REAR BRAKE LIGHTS WORK INTERMITTENTLY AND NEED TO BE REPLACED OR REPAIRED. GMC KNOW THERE ARE NUMEROUS COMPLAINTS ABOUT THIS PROBLEM AND HAVE DONE NOTHING. HUGE SAFETY ISSUE!!
MAJOR SAFETY ISSUES WITH THIS VEHICLE. ANOTHER 2015 YUKON WITH NO TAIL OR STOP LIGHTS. I'M OVER MILLAGE ON SPECIAL RECALL. THERE SHOULD BE NO TIME/MILLAGE ISSUE ON THIS. SEAT BELTS LOCK UP. BRAKES ARE EITHER GOOD OR MUSSY WHENEVER THEY WANT TO BE. HARD TO STOP THE VEHICLE. ALSO WHEN I FIRST PURCHASED THE VEHICLE IT WOULD COMPLET…
Read full complaint
MAJOR SAFETY ISSUES WITH THIS VEHICLE. ANOTHER 2015 YUKON WITH NO TAIL OR STOP LIGHTS. I'M OVER MILLAGE ON SPECIAL RECALL. THERE SHOULD BE NO TIME/MILLAGE ISSUE ON THIS. SEAT BELTS LOCK UP. BRAKES ARE EITHER GOOD OR MUSSY WHENEVER THEY WANT TO BE. HARD TO STOP THE VEHICLE. ALSO WHEN I FIRST PURCHASED THE VEHICLE IT WOULD COMPLETELY DIE (NO LIGHTS MOTOR DIED, NO POWER STEERING, NO AIR BAGS, NO RADIO NOTHING AT ALL ON THE X-WAY AT 70 MPH) AND THE DEALER COULD NOT REPAIR IT! RUST ON FRAME RAILS. (AND MORE).
MY PASSENGER SIDE TAIL LIGHT ASSEMBLY NEED TO BE REPLACED AS THE BRAKE LIGHTS ARE NOT WORKING. THIS HAS BECOME A COMMON PROBLEM AS EVIDENCED BY THE NUMBER OF COMPLAINTS FILED ON YOUR SITE FOR THE SAME ISSUE. LACK OF PROPERLY FUNCTIONING TAIL LIGHTS IS A MAJOR SAFETY CONCERN AND A RECALL SHOULD BE ISSUED. *TR
TL* THE CONTACT OWNS A 2015 GMC YUKON XL. THE CONTACT STATED THAT WHILE DEPRESSING THE BRAKE PEDAL THE REAR BRAKE TAILLIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO KEWEENAW BUICK GMC LOCATED AT 608 QUINCY ST, HANCOCK, MI 49930, TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE REAR BRAKE LIGHTS WERE DEFECTIVE AND NEEDED…
Read full complaint
TL* THE CONTACT OWNS A 2015 GMC YUKON XL. THE CONTACT STATED THAT WHILE DEPRESSING THE BRAKE PEDAL THE REAR BRAKE TAILLIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO KEWEENAW BUICK GMC LOCATED AT 608 QUINCY ST, HANCOCK, MI 49930, TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE REAR BRAKE LIGHTS WERE DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 102,000.
BOTH LED BRAKE LIGHTS STOPPED WORKING. THEY WERE BOTH REPLACED BY THE DEALERSHIP. NOW APPROXIMATELY 7 MONTHS LATER THE PASSENGER BRAKE LIGHT HAS STOPPED WORKING AGAIN. THIS IS A VERY EXPENSIVE PART, WHICH COST $700.00 EACH SIDE, AND HAS FAILED TWICE IN YEAR. FROM A SIMPLE SEARCH ON THE INTERNET THIS SEEMS TO BE A VERY COMMON PRO…
Read full complaint
BOTH LED BRAKE LIGHTS STOPPED WORKING. THEY WERE BOTH REPLACED BY THE DEALERSHIP. NOW APPROXIMATELY 7 MONTHS LATER THE PASSENGER BRAKE LIGHT HAS STOPPED WORKING AGAIN. THIS IS A VERY EXPENSIVE PART, WHICH COST $700.00 EACH SIDE, AND HAS FAILED TWICE IN YEAR. FROM A SIMPLE SEARCH ON THE INTERNET THIS SEEMS TO BE A VERY COMMON PROBLEM FOR GMC YUKON'S AND DENALI'S BUT THERE IS NOT A RECALL FOR THIS FAILURE. THE PROBLEM SEEMS TO BE A FAULTY DESIGN. THE SOLDER CONNECTION PREMATURELY BREAKS AND CAUSES THE LED BRAKE LIGHTS TO NOT WORK. *TR
THE BRAKE LIGHT IS NOT WORKING. ALL OTHER FUNCTIONS IN THE ASSEMBLY ARE FINE. REVERSE AND TURN SIGNAL, NO BRAKE INDICATION. IT DOES NOT ACTIVATE A WARNING ON THE DASH FOR THE BRAKE LIGHT FAILURE. THIS HAPPENS 24/7... THIS SHOULD NOT OCCUR WITH AN ITEM PRICED AT OVER $700.00 TO REPLACE. *TR
I PURCHASED BY VEHICLE IN THE SUMMER OF 2015. IT HAS BEEN IN THE SHOP NUMEROUS TIMES FOR VARIOUS ISSUES, MOSTLY ELECTRICAL INVOLVING THE COMPUTER AND SOFTWARE, OR ISSUES INVOLVING MY TIRES OR STEERING WHEN TURNING THE STEERING WHEEL.. MY "DRIVER ASSIST" HAS MALFUNCTIONED MANY TIMES AND I HAVE TAKEN IT TO THE SHOP TO HAVE IT RE…
Read full complaint
I PURCHASED BY VEHICLE IN THE SUMMER OF 2015. IT HAS BEEN IN THE SHOP NUMEROUS TIMES FOR VARIOUS ISSUES, MOSTLY ELECTRICAL INVOLVING THE COMPUTER AND SOFTWARE, OR ISSUES INVOLVING MY TIRES OR STEERING WHEN TURNING THE STEERING WHEEL.. MY "DRIVER ASSIST" HAS MALFUNCTIONED MANY TIMES AND I HAVE TAKEN IT TO THE SHOP TO HAVE IT REPAIRED ON 3 SEPARATE OCCASIONS. LAST SUMMER MY FRONT AND REAR LIGHTS STARTED FLICKERING AND STOPPED WORKING. I SPENT $800 FOR THE BACK PASSENGER BRAKE LIGHT AND ALMOST $1000 FOR THE FRONT DRIVER HEAD LIGHT ASSEMBLY. I ALSO HAD TO GET A NEW BATTERY FOR THIS VEHICLE. MY 2015 GMC YUKON XL IS NOW MALFUNCTIONING AGAIN AND THIS TIME, I AM TOLD THAT THE SEAT MOTOR (THAT ALERTS YOU WHEN YOU ARE NEAR AN OBSTACLE HAS BURNED OUT.) ABOUT 4 DAYS AGO, I BECAME AWARE OF TICKING NOISE WHILE MY CAR HAS BEEN IDLE. I IMMEDIATELY SCHEDULED A MAINTENANCE APPOINTMENT. TODAY, I AM ALSO INFORMED THAT MY "LIFTERS" ARE BAD ON THE VEHICLE AND MY ENGINE IS GOING BAD. I AM TOLD THE AIR CONDITIONING CONDENSER HAS BURNED OUT, I AM TOLD THE MOTOR UNDER MY SEAT IS BURNED OUT. I HAVE PERFORMED ROUTINE MAINTENANCE, I GET OIL CHANGES REGULARLY AND USE HIGH QUALITY SYNTHETIC OILS. I TAKE MY CAR TO THE SHOP AT LEAST 2X PER YEAR FOR PROBLEMS AND SOME MAJOR REPAIR IS ALWAYS REQUIRED. THIS IS A CAR THAT I AM GOING INTO THE 5TH YEAR OF OWNERSHIP THIS SUMMER. ORIGINALLY. I WAS TOLD THAT THERE WAS A RECALL FOR BRAKES, NOW I AM TOLD THERE IS NOT, BUT I HAVE TAKEN MY CAR IN FOR VARIOUS RECALLS AT LEAST 3X. THIS IS AN UNSAFE, DEFECTIVE VEHICLE. EVERY SYSTEM FAILS. I AM NOW IN SEARCH OF A NEW VEHICLE. I HAVE DRIVEN OTHER GM VEHICLES (GRAND AM, HUMMER) AND NONE HAVE REQUIRED SO MUCH REPAIR COSTS. TODAY I AM TOLD THAT IT WILL COST $6800 TO REPAIR MY VEHICLE TO MAKE IT SAFE. MY REPAIR RECORDS WILL SHOW THE REPAIRS AND SERVICE CHARGES I HAVE PAID SINCE PURCHASE. THIS IS A LEMON. *TR
Official recalls
217V437000 · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Jul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
16V651000 · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Sep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence & remedy
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Additional source detail variants (3)
Seat Belts:pretensioner
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal:sensor/control MODULE-INACTIVE
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Air Bags:frontal
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE18012 · Brake Vacuum Pump Failure
Opened Nov 20, 2018 · Closed Apr 10, 2022
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Additional source detail variants (3)
Service Brakes
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
Service Brakes, Hydraulic:power Assist:vacuum
On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.