VAN HAS LESS THAN 60,000 M. LAST 2-3 YEARS RUST CORROSION ON FRAME HAS NOW BECOME SO BAD ITS NO LONGER ABLE TO PASS NH STATE SAFETY INSPECTION. BRAKE LINES RUSTED AND REPLACED IN 2010 .GAS TANK RUSTED AND LEAKS.LEAF SPRING BRACKETS RUSTED AND BROKEN ,ONE REPLACED IN 2011,OTHER JUST BROKE CAN NOT FIND MECH. TO FIX,BECAUSE RUST HA…
Read full complaint
VAN HAS LESS THAN 60,000 M. LAST 2-3 YEARS RUST CORROSION ON FRAME HAS NOW BECOME SO BAD ITS NO LONGER ABLE TO PASS NH STATE SAFETY INSPECTION. BRAKE LINES RUSTED AND REPLACED IN 2010 .GAS TANK RUSTED AND LEAKS.LEAF SPRING BRACKETS RUSTED AND BROKEN ,ONE REPLACED IN 2011,OTHER JUST BROKE CAN NOT FIND MECH. TO FIX,BECAUSE RUST HAS EATEN AWAY SO MUCH METAL,( IT GETS THINNER AND WEAKER). I BOUGHT THIS VAN BRAND NEW AM THE ONLY DRIVER AND HAVE TAKEN VERY GOOD CARE OF IT.I CAN NOT AFFORD TO JUST DUMP IT AND BUY ANOTHER. I KNOW OF MANY OTHER GMC VANS ALL DOING THE SAME THING.THE BUMPERS ALSO ARE PAPER THIN WHERE THERE'S SOME CHEAP METAL LEFT. *TR
NHTSA ODI #10470059
55,000 miles · Jun 7, 2011
Structure
TL* THE CONTACT OWNS A 2000 GMC SAVANNA. THE VEHICLE WAS BEING SERVICE FOR ROUTINE MAINTENANCE WHEN THE CONTACT WAS INFORMED BY THE TECHNICIAN THAT THE FRAME WAS SEVERELY RUSTED TO THE POINT WHERE THE TECHNICIAN WS ABLE TO PUT HIS FINGER THROUGH THE RUST AND THE FRAME. THE CONTACT BELIEVED THAT THE FAILURE INDICATED THAT THE VEH…
Read full complaint
TL* THE CONTACT OWNS A 2000 GMC SAVANNA. THE VEHICLE WAS BEING SERVICE FOR ROUTINE MAINTENANCE WHEN THE CONTACT WAS INFORMED BY THE TECHNICIAN THAT THE FRAME WAS SEVERELY RUSTED TO THE POINT WHERE THE TECHNICIAN WS ABLE TO PUT HIS FINGER THROUGH THE RUST AND THE FRAME. THE CONTACT BELIEVED THAT THE FAILURE INDICATED THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE MANUFACTURER WAS NOT CONTACTED OR MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 55,000.
NHTSA ODI #10405456
Mileage unknown · Aug 1, 2002
Structure
REAR DOOR WILL OPEN TOO WIDE, HITTING FRONT DOOR, AND CAUSING DAMAGE. DEALER NOTIFIED. *AK
NHTSA ODI #8015342
Mileage unknown · Oct 12, 2000
Structure
WHEN DRIVER'S SIDE SUNVISOR IS PUSHED AGAINST WINDSHIELD ,IT WILL DROP BACK DOWN INTO A NOTCH, D-DENT, CAUSING POOR VISIBILITY.*AK THE DRIVER'S SEAT (ELECTRIC) IS IN THE LOWEST POSITION. *YH
SOME PICKUP TRUCKS, VANS, AND SPORT UTILITY VEHICLES EQUIPPED WITH A HYDRAULIC PUMP DRIVESHAFT THAT CAN FRACTURE, RESULTING IN IMMEDIATE LOSS OF HYDRAULIC POWER STEERING ASSIST. ON CERTAIN VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, THE SAME CONDITION CAN RESULT IN LOSS OF POWER ASSIST FOR BRAKING AFTER THE RESERVE PRESSURE IS DEPLETED.
Consequence & remedy
Consequence: AN INOPERATIVE PUMP CAN CAUSE INCREASED STEERING EFFORT, AND IN HYDRO-BOOST EQUIPPED VEHICLES ALSO INCREASED BRAKING EFFORT, BUT DOES NOT COMPLETELY ELIMINATE THE ABILITY TO STEER OR SLOW THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE HYDRAULIC PUMP. THE CAMPAIGN BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
VEHICLE DESCRIPTION: PASSENGER VANS EQUIPPED WITH A BRAKE WARNING INDICATOR. SOME OF THESE VEHICLES HAVE A POWER STEERING COOLER HOSE THAT CAN SEPARATE FROM THE POWER BRAKE BOOSTER FLUID FLOW SWITCH ASSEMBLY.
Consequence & remedy
Consequence: IF THIS OCCURS, POWER STEERING FLUID COULD FLOW ONTO HOT ENGINE PARTS AND AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT FOR THREE SCREW CLAMPS TO THE POWER STEERING HOSE JOINTS. IF THE CLAMPS ARE NOT THE SCREW TYPE, DEALERS WILL REPLACE THE CLAMPS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA04012 · Hydraulic Pump Failres
Opened Apr 30, 2004 · Closed Feb 28, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist; Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
2000 GMC Savana Problems, Complaints & Recalls | Skip That Year
Illustration