NO INJURIES, OR CRASHES. DOOR HANDLE ON VAN PULLING AWAY FROM VEHICLE. POOR QUALITY FOR HANDLES. MADE OF ALL PLASTIC. COULDN'T OPEN PASSENGER DOOR BECAUSE PLASTIC PARTS HAD BROKEN INSIDE THE DOOR. THIS VAN IS NOT ABUSED IN ANY WAY,AS MY 98 LB. WIFE IS THE ONE USING THAT DOOR EVERYDAY AND DOESN'T SLAM THE DOOR, OR TUG ON HANDLES.…
Read full complaint
NO INJURIES, OR CRASHES. DOOR HANDLE ON VAN PULLING AWAY FROM VEHICLE. POOR QUALITY FOR HANDLES. MADE OF ALL PLASTIC. COULDN'T OPEN PASSENGER DOOR BECAUSE PLASTIC PARTS HAD BROKEN INSIDE THE DOOR. THIS VAN IS NOT ABUSED IN ANY WAY,AS MY 98 LB. WIFE IS THE ONE USING THAT DOOR EVERYDAY AND DOESN'T SLAM THE DOOR, OR TUG ON HANDLES. PART WAS REPLACED BY DEALER. MY CONCERN IS WHEN WILL THE REST OF THE HANDLES BREAK, OR FALL OFF?*JB
NHTSA ODI #10138469
Mileage unknown · Aug 13, 2000
Latches/locks/linkagesFire
OUR VEHICLE CAUGHT ON FIRE WITH MY WIFE AND THREE SMALL CHILDREN INSIDE. WE HAD THE CHILD SEFETY LOCKS ENGAGED AND QUICKLY REALIZED THAT IF MY WIFE HAD GONE TO THE REAR OF THE VAN FROM THE INSIDE (VIA BETWEEN THE SEATS) TO RETRIEVE THE CHILDREN THE RESULTS WOULD HAVE BEEN DEADLY SINCE SHE WOULD NOT HAVE BEEN ABLE TO OPEN THE DOO…
Read full complaint
OUR VEHICLE CAUGHT ON FIRE WITH MY WIFE AND THREE SMALL CHILDREN INSIDE. WE HAD THE CHILD SEFETY LOCKS ENGAGED AND QUICKLY REALIZED THAT IF MY WIFE HAD GONE TO THE REAR OF THE VAN FROM THE INSIDE (VIA BETWEEN THE SEATS) TO RETRIEVE THE CHILDREN THE RESULTS WOULD HAVE BEEN DEADLY SINCE SHE WOULD NOT HAVE BEEN ABLE TO OPEN THE DOOR FROM THE INSIDE WHILE THE CHILD SAFETY LOCK WAS ENGAGED. ALTHOUGH THEY WERE INSTALLED WITH GOOD INTENTIONS WE HAVE LEARNED THEY ARE UNSAFE DURING A FIRE AND WILL NEVER ENGAGE THEM AGAIN. *AK
SOME PICKUP TRUCKS, VANS, AND SPORT UTILITY VEHICLES EQUIPPED WITH A HYDRAULIC PUMP DRIVESHAFT THAT CAN FRACTURE, RESULTING IN IMMEDIATE LOSS OF HYDRAULIC POWER STEERING ASSIST. ON CERTAIN VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, THE SAME CONDITION CAN RESULT IN LOSS OF POWER ASSIST FOR BRAKING AFTER THE RESERVE PRESSURE IS DEPLETED.
Consequence & remedy
Consequence: AN INOPERATIVE PUMP CAN CAUSE INCREASED STEERING EFFORT, AND IN HYDRO-BOOST EQUIPPED VEHICLES ALSO INCREASED BRAKING EFFORT, BUT DOES NOT COMPLETELY ELIMINATE THE ABILITY TO STEER OR SLOW THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE HYDRAULIC PUMP. THE CAMPAIGN BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
VEHICLE DESCRIPTION: PASSENGER VANS EQUIPPED WITH A BRAKE WARNING INDICATOR. SOME OF THESE VEHICLES HAVE A POWER STEERING COOLER HOSE THAT CAN SEPARATE FROM THE POWER BRAKE BOOSTER FLUID FLOW SWITCH ASSEMBLY.
Consequence & remedy
Consequence: IF THIS OCCURS, POWER STEERING FLUID COULD FLOW ONTO HOT ENGINE PARTS AND AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT FOR THREE SCREW CLAMPS TO THE POWER STEERING HOSE JOINTS. IF THE CLAMPS ARE NOT THE SCREW TYPE, DEALERS WILL REPLACE THE CLAMPS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA04012 · Hydraulic Pump Failres
Opened Apr 30, 2004 · Closed Feb 28, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist; Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
2000 GMC Savana Problems, Complaints & Recalls | Skip That Year
Illustration