2018 Ford Transit

Odometer Fraud. The contact purchased a 2018 Ford Transit. The contact stated that upon taking the vehicle to the Ford dealer for service, the contact was informed that the vehicle was a Lemon vehicle, and that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 33,135; however, upon retrieving the Carfax history report of the vehicle, the Ford dealer informed the contact that the vehicle mileage was 240,000.

My 2018 Ford Transit 250 experienced a failure of the Input/Turbine Speed Sensor in the 6R80 transmission’s mechatronic lead frame at approximately 60,000 miles. The failure was confirmed by an authorized Ford service department, which retrieved DTC codes P0715-00 and P0717-00. These codes indicate that the turbine speed sensor signal is lost, forcing the transmission into limp mode, causing loss of power and erratic shifting. This is a serious safety concern, it can occur suddenly while driving and results in loss of proper gear control. Relation to Recall 19S07 Ford has already acknowledged this same defect in other vehicles using the 6R80 transmission. In Safety Recall 19S07, Ford recalled certain 2011–2013 F-150, Expedition, and Navigator models due to failure of the Output Shaft Speed (OSS) sensor in the 6R80 lead frame. The failure mode, symptoms, and remedy (lead frame replacement and PCM update) are identical. In my case, the failure is of the Input/Turbine Speed Sensor rather than the OSS sensor, but both are housed in the same lead frame assembly and both result in sudden sensor failure, limp mode, and unsafe driving conditions. Why Action Is Needed Despite the identical defect, Ford has refused coverage because my VIN is not included in Recall 19S07 and my vehicle is just outside the 5 year / 60,000 mile powertrain warranty. This exclusion leaves Transit owners unprotected even though we are experiencing the same premature failure Ford already acknowledged. Given the safety implications, I am requesting NHTSA to investigate whether Recall 19S07 should be expanded to include Ford Transit vehicles equipped with the 6R80 transmission. Summary Vehicle: 2018 Ford Transit 250, 60,000 miles DTCs: P0715-00, P0717-00 (Input/Turbine Speed Sensor failure) Component: 6R80 mechatronic lead frame (same part as in Recall 19S07) Symptoms: Limp mode, loss of shifting, unsafe drivability Ford refuses coverage despite identical failure acknowledged in other model

The contact owns a 2018 Ford Transit. The contact stated that while slowly driving into a parking space, the vehicle suddenly experienced unintended acceleration and crashed into another parked vehicle. During the incident, the brake pedal was pressed, but the vehicle did not stop. The vehicle was towed to the local dealer, who was unable to determine the cause of the failure. No injuries were reported and a police report was taken at the scene. Also, the vehicle later experienced the same failure. While attempting to park the vehicle again experienced unintended acceleration and drove forward, crashing into a second vehicle. During the crash, the two front occupants of the second vehicle had sustained undisclosed injuries that later required medical treatment. No further information was available. A police report was taken at the scene. The vehicle was towed to the local dealer, who was unable to determine the cause of the second failure. The contact indicated that the failure had recently reoccurred for the third time. The cause of the failures was not determined. The manufacturer was not contacted regarding the failures. The failure mileage was unknown.

The contact owns a 2018 Ford Transit. The contact stated while driving at 55 MPH, the vehicle suddenly started losing power, after driving over 200 yards, the vehicle became inoperable. The check engine and service engine warning lights were illuminated. The contact merged to the side of the road as a ramp was coming up and called AAA. The vehicle was towed to the dealer and was diagnosed with a timing chain and engine failure. The contact was informed by the dealer of an extended warranty; however, the warranty had expired two days prior to the failure. The vehicle was taken to an independent mechanic. The engine was replaced with a used engine, new timing chain, new gaskets, engine oil, water pump, rear sealant, coolant, and spark plugs. The vehicle was replaced. The manufacturer was made aware of the failure. The failure mileage was approximately 156,206.

I was driving on a rural highway 55 mph when I heard a pop! I lost control and veered into oncoming traffic! I slowed down by tapping brakes and ended up back on the right side in the shoulder/ditch. The shoulder had new gravel so it slowed me down and grabbed a hold of what was left. Found the wheel out in the ditch a good ways from the car and also three lug nuts with bolts still attached and broken at the base in the stretch from the turn off to where the car stopped. Also found my brake pad near a lug nut in the median! Bolts completely broken at the base with lug nuts still attached. Wheel completely fine just not on car. Inside rim gouged out from riding on it after the bolts broke. Found a recall on Ford Transit for the 2019 version of this vehicle for the exact same problem. But since this is a 2018 Ford will not honor it. Cause appears to be a weakness in the alloy used which warps over time and then without warning causing the bolts to brake at the base and separate wheel from vehicle.

The contact owns a 2018 Ford Transit. The contact stated that while driving at various speeds, an abnormal squeaking sound would be emitted from the vehicle without warning. The contact stated that the sound went away upon the depression of the brake pedal. Since owning the vehicle, the contact had taken the vehicle to the dealer for an oil change, each time, the contact was informed that both the brake pads and rotors needed to be replaced. The contact stated that the clips needed to keep the brake pads in place fractured approximately 20-50 miles after being replaced. The contact stated that the brake pads and rotors had been replaced several times due to the failure. The manufacturer was notified of the failure and acknowledged the failure; however, no assistance was provided. The vehicle was not repaired. The failure mileage was approximately 160,000.

With this vehicle when driving on highway or interstate once you go past about 40 miles the transmission begins to overheat and when it reaches a temperature of approximately 245° it will kick down into limp mode causing the vehicle to suddenly slow down in front of other traffic. You have to get over to the side of the road and let the transmission cool down before you can continue at a safe pace. This vehicle has been taken multiple times the transmission has been replaced twice. They have replaced the transmission cooler, they have an auxiliary cooler, and the problems still persist. This is very dangerous to be operating when it kicks down tent mode and gears down suddenly. It has been in Fords service shop for over seven months now and we just got it back with the new auxiliary cooler on it and it is still having the same problem.