SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2005 Ford Taurus

Owner reports · Recalls · Investigations

More warning signs than most Taurus years

Owner complaints for the 2005 Ford Taurus are substantially higher than the model-year median of 318.

About this comparison →
774Owner complaints

Model-year median: 318

0Recall campaigns

View recall details →

2Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
1,426
20021,223
2003375
2004774
2005318
2006149
2007175
2008
Compare all Taurus years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Vehicle Speed Control
529Power Train
123Engine
68Engine And Engine Cooling
40Fuel/propulsion System
29
All reported categories
Electrical System
28Air Bags
27Service Brakes
26Unknown Or Other
25Structure
22Visibility
11Fuel System, Gasoline
10Service Brakes, Hydraulic
10Steering
7Suspension
7Equipment
4Exterior Lighting
4Latches/locks/linkages
4Seat Belts
4Tires
3Fuel System, Other
2Child Seat
1Electronic Stability Control (esc)
1Forward Collision Avoidance
1Visibility/wiper
1Wheels
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

703 reports with mileage · 71 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Vehicle Speed Control. Review the 529 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Power Train. Review the 123 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

40 crash reports10 fire reports19 injury reports

Structure complaints

22 reports
Clear category filter
112,600 miles · Jan 4, 2013
Structure

ON 01/03/13 TEMPERATURE OUTSIDE WAS IN THE SINGLE & LOWER TEENS. I ENTERED MY 2005 FORD TAURUS CLOSED THE DRIVER SIDE DOOR IT WAS FROZEN. I THEN LET CAR RUN FOR 40 MINUTES BLOWING HEAT DIRECTLY ON INTERIOR DRIVER DOOR, I THEN TRIED PASSENGER DOOR SEEM TO BE OK. WHEN DRIVER SIDE DOOR BECAME UNFROZEN I DROVE OFF, THE PASSENG…

Read full complaint

ON 01/03/13 TEMPERATURE OUTSIDE WAS IN THE SINGLE & LOWER TEENS. I ENTERED MY 2005 FORD TAURUS CLOSED THE DRIVER SIDE DOOR IT WAS FROZEN. I THEN LET CAR RUN FOR 40 MINUTES BLOWING HEAT DIRECTLY ON INTERIOR DRIVER DOOR, I THEN TRIED PASSENGER DOOR SEEM TO BE OK. WHEN DRIVER SIDE DOOR BECAME UNFROZEN I DROVE OFF, THE PASSENGER FRONT DOOR FLEW OPEN, I PULLED THE CAR OFF THE ROAD, I TRIED TO CLOSE DOOR, STILL FROZEN. AFTER 1 HOUR OF WARM UP BOTH DOORS FINALLY CLOSED. IF I HAD A PASSENGER ON THIS OCCURRING DATE THEY COULD HAVE BEEN EJECTED FROM FRONT PASSENGER SIDE, DUE TO FROZEN DOOR LATCHES. THIS PROBLEM OCCURS EVERY TIME DURING COLD WEATHER. ON 01/04/12 LET CAR RUN TO WARM FRONT INTERIOR DOORS TO THAW OUT LATCHES, EXIT CAR THE DOOR LATCHES LOCKED, CAR WAS RUNNING, KEYS INSIDE, COULD NOT ENTER CAR, GOT EXTRA CAR KEY TO ENTER CAR TO SHUT ENGINE OFF, THIS SHOULD NOT HAVE OCCURRED. THIS IS A MAJOR SAFETY PROBLEM DUE TO DOOR LATCHES FREEZING AND NOT CLOSING AND FLYING OPEN AND DOORS LOCKING WHILE RUNNING ENGINE TO THAW OUT DOOR LATCHES. *TR

NHTSA ODI #10490982

160,000 miles · Oct 27, 2012
Service BrakesStructureVehicle Speed ControlCrash

I WAS TRYING TO PARK THE VEHICLE BUT WHEN I HIT THE BRAKES, IT ACCELLORATED, THEN I PUT IT IN REVERSE AND IT WENT ABOUT 50MPH BACKWARDS CAUSING ME TO CRASH INTO 2 PARKED VEHICLES. IT STOPPED WHEN I PUT ON THE EMERGENCY BRAKE. *TR

NHTSA ODI #10482448

150,000 miles · Jul 27, 2012
EngineStructureFire

MY HUSBAND WAS DRIVING OUR 2005 FORD TAURUS WITH THE AIR CONDITIONER ON HIGH, HE HEARD A POP AND THEN SAW FLAMES COMING OUT OF THE ENGINE. HE WAS ABLE TO GET OUT OF THE VEHICLE AND CALL THE FIRE DEPT. THE CAR WENT UP IN FLAMES. THE MECHANIC SAID THE FIRE STARTED IN THE AIR CONDITIONER. THE CAR IS A TOTAL LOSS. *TR

NHTSA ODI #10467896

75,000 miles · Nov 27, 2011
Electrical SystemStructureVisibility

I HAVE A 2005 FORD TAURUS. WHENEVER THERE IS MODERATE TO HEAVY RAINFALL, WATER LEAKS INTO THE PASSENGER SIDE UNDER THE DASH, SOAKING THE FLOOR AND THE BLOWER MOTOR WILL NOT WORK. WHILE DRIVING THE WINDSHIELD FOGS OVER AND I CANNOT GET THE BLOWER TO TURN ON, CAUSING VISIBILITY ISSUES WHILE DRIVING ON THE ROAD. THIS IS HAPPENIN…

Read full complaint

I HAVE A 2005 FORD TAURUS. WHENEVER THERE IS MODERATE TO HEAVY RAINFALL, WATER LEAKS INTO THE PASSENGER SIDE UNDER THE DASH, SOAKING THE FLOOR AND THE BLOWER MOTOR WILL NOT WORK. WHILE DRIVING THE WINDSHIELD FOGS OVER AND I CANNOT GET THE BLOWER TO TURN ON, CAUSING VISIBILITY ISSUES WHILE DRIVING ON THE ROAD. THIS IS HAPPENING TO A LOT OF PEOPLE, THIS SHOULD BE INVESTIGATED AND A RECALL ISSUED. *TR

NHTSA ODI #10437390

54,831 miles · Feb 8, 2011
Exterior LightingPower TrainSteering

MY 2005 FORD TAURUS HAS BEEN A HEADACHE SINCE DAY ONE. TODAY ON MY WAY TO WORK THE CAR SUDDENLY ACCELERATED AND APPLYING THE BRAKES WAS A CHALLENGE AS I ALMOST COULDN'T STOP WHEN PULLING OVER FOR SAFETY. PRIOR TO THIS, OVER $2000 FOR A NEW ENGINE, ANOTHER $900 FOR A NEW TRANSMISSION, ANOTHER $250 FOR A POWER STEERING PUMP, AND D…

Read full complaint

MY 2005 FORD TAURUS HAS BEEN A HEADACHE SINCE DAY ONE. TODAY ON MY WAY TO WORK THE CAR SUDDENLY ACCELERATED AND APPLYING THE BRAKES WAS A CHALLENGE AS I ALMOST COULDN'T STOP WHEN PULLING OVER FOR SAFETY. PRIOR TO THIS, OVER $2000 FOR A NEW ENGINE, ANOTHER $900 FOR A NEW TRANSMISSION, ANOTHER $250 FOR A POWER STEERING PUMP, AND DAILY ISSUES LIKE THE DOOR NOT LATCHING AND ME TRYING TO HOLD DRIVER'S DOOR SHUT WHILE DRIVING AT THE SAME TIME, AND THEN HAVING TO TIE A ROPE ACROSS THE FRONT SEAT TO THE PASSENGER DOOR. ALSO, THE DAYTIME RUNNING LIGHTS TURN ON ON THEIR OWN AT ANY GIVEN TIME AND DRAIN THE BATTERY. THIS CAR IS A PIECE OF CRAP. IF YOU BUY THIS KIND OR CAR, MAKE SURE YOU HAVE AAA TOO. *TR

NHTSA ODI #10381099

80,100 miles · Mar 4, 2010
Structure

I WAS DRIVING MY VEHICLE AND HEARD A CLICK. I HADN'T PUSHED ANY BUTTONS AND DIDN'T THINK MUCH OF IT. A MINUTE LATER I LOOKED IN THE REARVIEW MIRROR AND SAW THE TRUNK HAD OPENED ON ITS OWN. *TR

NHTSA ODI #10316863

89,542 miles · Feb 5, 2010
StructureVisibility

TL*THE CONTACT OWNS A 2005 FORD TAURUS. SHE STATED THAT WATER WAS LEAKING INTO THE VEHICLE ON THE PASSENGER SIDE OF THE FRONT WINDSHIELD. THE DEALER STATED THAT SHE WOULD NEED A RAIN CAP EXTENSION INSTALLED ON THE VEHICLE TO CORRECT THE FAILURE. THERE WERE NO RECALLS RELATED TO THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE …

Read full complaint

TL*THE CONTACT OWNS A 2005 FORD TAURUS. SHE STATED THAT WATER WAS LEAKING INTO THE VEHICLE ON THE PASSENGER SIDE OF THE FRONT WINDSHIELD. THE DEALER STATED THAT SHE WOULD NEED A RAIN CAP EXTENSION INSTALLED ON THE VEHICLE TO CORRECT THE FAILURE. THERE WERE NO RECALLS RELATED TO THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE UNDER 89,542. UPDATED 3/17/10 *CN UPDATED 06/17/10*JB

NHTSA ODI #10306564

53,450 miles · Sep 15, 2009
Structure

THE PAINT IS BUBBLING AND PEELING ON THE ROOF, FRONT BUMPER AND THE REAR BUMPER. *TR

NHTSA ODI #10283966

Mileage unknown · Dec 31, 2007
Structure

AFTER IT RAINS, THE PASSENGER SIDE FLOORBOARD IS SOAKED. THERE IS ALSO RUST ON THE METAL PARTS IN THE GLOVE BOX AS WELL AS DRIP STAINS. I HAVE REPORTED THIS SEVERAL TIMES TO THE DEALER SINCE I PURCHASED THE CAR AND WAS TOLD IT IS JUST MOISTURE CAUSING THE RUST (SUCH A LIE). THEY SAID THE SMELL IN THE VENTS WAS CAUSED BY A SMA…

Read full complaint

AFTER IT RAINS, THE PASSENGER SIDE FLOORBOARD IS SOAKED. THERE IS ALSO RUST ON THE METAL PARTS IN THE GLOVE BOX AS WELL AS DRIP STAINS. I HAVE REPORTED THIS SEVERAL TIMES TO THE DEALER SINCE I PURCHASED THE CAR AND WAS TOLD IT IS JUST MOISTURE CAUSING THE RUST (SUCH A LIE). THEY SAID THE SMELL IN THE VENTS WAS CAUSED BY A SMALL BUILD UP OF WATER IN THE AIR VENT RESERVOIR. I HAVE ONLY 17,000 MILES ON MY 2005 TAURUS (WHICH I PURCHASED IN SEPTEMBER, 2006 WITH ONLY 247 MILES ON IT) BUT THE MANUFACTURERS WARRANTY JUST EXPIRED THIS MONTH. I DO HAVE A 6 YEAR EXTENDED WARRANTY. I CALLED THE DEALERSHIP WHERE I PURCHASED THE CAR AND WAS TREATED VERY RUDELY BY THE SERVICE MANAGER. HE SAID I WOULD HAVE TO PAY $100.00 TO "INVESTIGATE" THE PROBLEM AND THAT IT IS MOST LIKELY NOT UNDER WARRANTY. THIS PROBLEM SEEMS TO BE OCCURRING IN MANY SABLE AND TAURUS CARS YET FORD HAS NOT RECALLED THIS PROBLEM. IT SEEMS TO BE A MAJOR PROBLEM IN THESE FORD VEHICLES AND FORD SHOULD TAKE RESPONSIBILITY FOR THIS AND FIX IT AT THEIR COST. HOW QUICK THEY ARE TO TAKE MY MONEY TO BUY THE CAR AND THE EXTENDED WARRANTY YET THEY WILL NOT FIX NOR ACKNOWLEDGE PUBLICLY THIS PROBLEM (WHICH THEY CREATED). PLEASE INVESTIGATE AND TELL FORD TO DO A RECALL. *TR

NHTSA ODI #10213325

43,917 miles · Oct 12, 2007
Structure

TL*THE CONTACT OWNS A 2005 FORD TAURUS. THE CONTACT NOTICED WATER ON THE PASSENGER SIDE FLOORBOARD. THE DEALER STATED THAT WATER WAS LEAKING FROM THE AIR INTAKE HEATER BOX AND THE WEATHER STRIPPING COWL PANEL FAILED. THE COWL PANEL WAS REPLACED. THE FAILURE MILEAGE WAS 43,917 AND CURRENT MILEAGE WAS 44,017.

NHTSA ODI #10205480

Official recalls

0

No recalls in this snapshot.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

PE12005 · Stuck Throttle

Opened Mar 7, 2012 · Closed Oct 22, 2012

Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables

Preliminary Evaluation (PE)12-005 was opened to investigate allegations of speed control cables detaching from the throttle body and subsequently interfering with the throttle closing fully to the idle position in model year (MY) 2005 and 2006 Ford Taurus vehicles.The speed control cable, throttle body attachment arm (?nail head?) for the speed control cable, cable mounting bracket and cable routing for the MY 2005 and 2006 Ford Taurus are common to all MY 2004 through 2006 Ford Taurus and Mercury Sable vehicles equipped with either the 155 HP 3.0L 2-valve Vulcan engine or the 200 HP 3.0L 4-valve Duratec engine (the ?subject vehicles?). Figures 1 and 2 show the throttle body cam and speed control cable installed and a cable interference condition caused by contact between a detached cable and the ?nail head.?Ford?s assessment of the condition in incident vehicles noted that the interference conditions produced tended to be short in duration as the cable end tended to dislodge itself from the throttle body due to vibration, road loads or engine roll in addition to tapping the acceleration pedal.Ford inspected three incident vehicles and measured maximum throttle openings of 5.8% to 14.9%, resulting in engine speeds ranging from 1600 to 2200 rpm with the transmission selector in Drive.A Ford stack-up analysis of the speed control cable length from the attachment bracket to the throttle body indicated a maximum theoretical throttle opening of 16.4% that could result from the alleged defect. Engineers at the NHTSA Vehicle Research and Test Center (VRTC) inspected an incident vehicle to evaluate throttle positions and engine speeds that could result from the alleged defect and performed brake testing of a vehicle with the throttle stuck at the worst case throttle opening that could result from the condition.The VRTC vehicle inspection noted that, depending on the orientation of the detached cable end, the amount of throttle opening that could result from interference by a detached speed control cable end varied from 4.8% to 11.3%.VRTC brake testing of a MY 2006 Taurus with a Vulcan engine and the throttle held open at 16% found that, even with multiple brake applications, sufficient vacuum was available for the brake booster assist and the brake pedal efforts required to stop the vehicle did not increase significantly from normal operating conditions. ODI?s analysis of 100 complaints related to the alleged defect found that drivers were generally able to free the interference condition or safely brake to a stop without incident.Approximately one-third (32) reported that the stuck throttle condition was corrected with no action or by tapping the accelerator pedal while the vehicle was still moving, another third (34) reported braking to a stop with the vehicle in Drive prior to correcting the condition, and the remaining third (34) reported that the driver responded to the incident by shifting to Neutral before stopping the vehicle.One complaint alleged that stuck-throttle type symptoms caused the vehicle to pass partially through a traffic light and into an intersection before stopping, however,ODI was unable to contact the owner to verify the cause or relationship to the alleged defect condition.ODI has not identified any crashes related to the alleged defect. Tables 1 and 2 provide a breakdown of complaints and warranty claims related to the alleged defect by engine and model year.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation do

Additional source detail variants (2)

Vehicle Speed Control:cables

Preliminary Evaluation (PE)12-005 was opened to investigate allegations of speed control cables detaching from the throttle body and subsequently interfering with the throttle closing fully to the idle position in model year (MY) 2005 and 2006 Ford Taurus vehicles.The speed control cable, throttle body attachment arm (?nail head?) for the speed control cable, cable mounting bracket and cable routing for the MY 2005 and 2006 Ford Taurus are common to all MY 2004 through 2006 Ford Taurus and Mercury Sable vehicles equipped with either the 155 HP 3.0L 2-valve Vulcan engine or the 200 HP 3.0L 4-valve Duratec engine (the ?subject vehicles?). Figures 1 and 2 show the throttle body cam and speed control cable installed and a cable interference condition caused by contact between a detached cable and the ?nail head.?Ford?s assessment of the condition in incident vehicles noted that the interference conditions produced tended to be short in duration as the cable end tended to dislodge itself from the throttle body due to vibration, road loads or engine roll in addition to tapping the acceleration pedal.Ford inspected three incident vehicles and measured maximum throttle openings of 5.8% to 14.9%, resulting in engine speeds ranging from 1600 to 2200 rpm with the transmission selector in Drive.A Ford stack-up analysis of the speed control cable length from the attachment bracket to the throttle body indicated a maximum theoretical throttle opening of 16.4% that could result from the alleged defect. Engineers at the NHTSA Vehicle Research and Test Center (VRTC) inspected an incident vehicle to evaluate throttle positions and engine speeds that could result from the alleged defect and performed brake testing of a vehicle with the throttle stuck at the worst case throttle opening that could result from the condition.The VRTC vehicle inspection noted that, depending on the orientation of the detached cable end, the amount of throttle opening that could result from interference by a detached speed control cable end varied from 4.8% to 11.3%.VRTC brake testing of a MY 2006 Taurus with a Vulcan engine and the throttle held open at 16% found that, even with multiple brake applications, sufficient vacuum was available for the brake booster assist and the brake pedal efforts required to stop the vehicle did not increase significantly from normal operating conditions. ODI?s analysis of 100 complaints related to the alleged defect found that drivers were generally able to free the interference condition or safely brake to a stop without incident.Approximately one-third (32) reported that the stuck throttle condition was corrected with no action or by tapping the accelerator pedal while the vehicle was still moving, another third (34) reported braking to a stop with the vehicle in Drive prior to correcting the condition, and the remaining third (34) reported that the driver responded to the incident by shifting to Neutral before stopping the vehicle.One complaint alleged that stuck-throttle type symptoms caused the vehicle to pass partially through a traffic light and into an intersection before stopping, however,ODI was unable to contact the owner to verify the cause or relationship to the alleged defect condition.ODI has not identified any crashes related to the alleged defect. Tables 1 and 2 provide a breakdown of complaints and warranty claims related to the alleged defect by engine and model year.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation do

Vehicle Speed Control

Preliminary Evaluation (PE)12-005 was opened to investigate allegations of speed control cables detaching from the throttle body and subsequently interfering with the throttle closing fully to the idle position in model year (MY) 2005 and 2006 Ford Taurus vehicles.The speed control cable, throttle body attachment arm (?nail head?) for the speed control cable, cable mounting bracket and cable routing for the MY 2005 and 2006 Ford Taurus are common to all MY 2004 through 2006 Ford Taurus and Mercury Sable vehicles equipped with either the 155 HP 3.0L 2-valve Vulcan engine or the 200 HP 3.0L 4-valve Duratec engine (the ?subject vehicles?). Figures 1 and 2 show the throttle body cam and speed control cable installed and a cable interference condition caused by contact between a detached cable and the ?nail head.?Ford?s assessment of the condition in incident vehicles noted that the interference conditions produced tended to be short in duration as the cable end tended to dislodge itself from the throttle body due to vibration, road loads or engine roll in addition to tapping the acceleration pedal.Ford inspected three incident vehicles and measured maximum throttle openings of 5.8% to 14.9%, resulting in engine speeds ranging from 1600 to 2200 rpm with the transmission selector in Drive.A Ford stack-up analysis of the speed control cable length from the attachment bracket to the throttle body indicated a maximum theoretical throttle opening of 16.4% that could result from the alleged defect. Engineers at the NHTSA Vehicle Research and Test Center (VRTC) inspected an incident vehicle to evaluate throttle positions and engine speeds that could result from the alleged defect and performed brake testing of a vehicle with the throttle stuck at the worst case throttle opening that could result from the condition.The VRTC vehicle inspection noted that, depending on the orientation of the detached cable end, the amount of throttle opening that could result from interference by a detached speed control cable end varied from 4.8% to 11.3%.VRTC brake testing of a MY 2006 Taurus with a Vulcan engine and the throttle held open at 16% found that, even with multiple brake applications, sufficient vacuum was available for the brake booster assist and the brake pedal efforts required to stop the vehicle did not increase significantly from normal operating conditions. ODI?s analysis of 100 complaints related to the alleged defect found that drivers were generally able to free the interference condition or safely brake to a stop without incident.Approximately one-third (32) reported that the stuck throttle condition was corrected with no action or by tapping the accelerator pedal while the vehicle was still moving, another third (34) reported braking to a stop with the vehicle in Drive prior to correcting the condition, and the remaining third (34) reported that the driver responded to the incident by shifting to Neutral before stopping the vehicle.One complaint alleged that stuck-throttle type symptoms caused the vehicle to pass partially through a traffic light and into an intersection before stopping, however,ODI was unable to contact the owner to verify the cause or relationship to the alleged defect condition.ODI has not identified any crashes related to the alleged defect. Tables 1 and 2 provide a breakdown of complaints and warranty claims related to the alleged defect by engine and model year.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation do

DP06005 · Engine Stalling Ffv

Opened Dec 4, 2006 · Closed Dec 28, 2007

Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:fuel Injection System; Fuel System, Gasoline:fuel Injection System:fuel Rail; Fuel System, Gasoline:fuel Injection System:injectors; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:auxillary Tank; Fuel System, Gasoline:storage:auxillary Tank:selector Devices; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap; Fuel System, Gasoline:storage:tank Assembly:mounting; Fuel System, Other; Fuel System, Other:delivery; Fuel System, Other:delivery:fuel Pump; Fuel System, Other:delivery:hoses, Lines/piping, And Fittings; Fuel System, Other:fuel Injection System; Fuel System, Other:storage; Fuel System, Other:storage:fuel Gauge System; Fuel System, Other:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:filling/charging; Fuel System, Other:storage:tank Assembly:mounting; Fuel System, Other:storage:tank Assembly:pressure Relief Devices

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

Additional source detail variants (23)

Fuel System, Gasoline:delivery

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

Fuel System, Gasoline:delivery:fuel Pump

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

Fuel System, Gasoline:fuel Injection System

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

Fuel System, Gasoline:fuel Injection System:fuel Rail

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

Fuel System, Gasoline:fuel Injection System:injectors

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

Fuel System, Gasoline:storage:auxillary Tank

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

Fuel System, Gasoline:storage:auxillary Tank:selector Devices

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

Fuel System, Gasoline:storage

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

Fuel System, Gasoline:storage:tank Assembly

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

Fuel System, Gasoline:storage:tank Assembly:mounting

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

Fuel System, Other:delivery

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

Fuel System, Other:delivery:fuel Pump

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

Fuel System, Other:delivery:hoses, Lines/piping, And Fittings

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

Fuel System, Other

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

Fuel System, Other:fuel Injection System

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

Fuel System, Other:storage

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

Fuel System, Other:storage:fuel Gauge System

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

Fuel System, Other:storage:tank Assembly:filling/charging

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

Fuel System, Other:storage:tank Assembly

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

Fuel System, Other:storage:tank Assembly:mounting

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.

Fuel System, Other:storage:tank Assembly:pressure Relief Devices

ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.