IllustrationVehicle was involved in a collision with major front end damage and no airbags deployed. The brakes have been soft or spongy. I have not seen any leaks for the brake issue. I have bled the brakes several times the master was replaced by the original owner.
2003 Ford Taurus
Owner reports · Recalls · Investigations
More warning signs than most Taurus years
Owner complaints for the 2003 Ford Taurus are substantially higher than the model-year median of 318.
About this comparison →How this year compares
Owner complaints by model year
Compare all Taurus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
740–25K
14925–50K
25250–75K
25375–100K
261100–150K
70150K+
1,059 reports with mileage · 164 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 316 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 313 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 191 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
56 crash reports12 fire reports45 injury reports
What owners actually said
1,223 reportsAt times the vehicle accelerates by itself albeit I am not touching the gas pedal. While driving the vehicle at 45 mph, I take my foot off of the accelerator and the vehicle maintains the 45 mph speed or increases speed if I am driving down a hill or any downward gradient regardless of the angle of decent. When I try to stop th…
Read full complaint
At times the vehicle accelerates by itself albeit I am not touching the gas pedal. While driving the vehicle at 45 mph, I take my foot off of the accelerator and the vehicle maintains the 45 mph speed or increases speed if I am driving down a hill or any downward gradient regardless of the angle of decent. When I try to stop the vehicle using the foot brake it continues to maintain speed and if I put the shift lever in neutral, while trying to stop, the RPM's increase from approximately 1500 rpm's to 3200 rpm's until the vehicle comes to a complete stop, and then, only after approximately five seconds do the RPM's begin to drop to 1000 rpm's. If I am driving the vehicle with cruise control and cancel the cruise control, the vehicle maintains the cruise control speed indefinitely, literally for miles thereafter. I wanted to give this vehicle to my daughter who has multiple sclerosis but it's too dangerous for her to drive with this acceleration problem. Do you have any recommendations for me???
The contact owns a 2003 Ford Taurus. The contact stated that when taking the vehicle out of the park(P) after starting the vehicle, which required the brake pedal to be depressed, the contact could not depress the shifter button out of the park. The contact stated that the shift button would not depress. The contact stated no wa…
Read full complaint
The contact owns a 2003 Ford Taurus. The contact stated that when taking the vehicle out of the park(P) after starting the vehicle, which required the brake pedal to be depressed, the contact could not depress the shifter button out of the park. The contact stated that the shift button would not depress. The contact stated no warning light was illuminated. The contact turned the vehicle off and turned the vehicle back on but had to pump the brake pedal to shift the vehicle out of the park. The contact had not taken the vehicle to a local dealer. The vehicle had not been diagnosed or repaired. The contact researched online and determined that the failure was related to NHTSA Campaign Number: 04V106000 (Exterior Lighting). The manufacturer had been informed of the failure. The failure mileage was approximately 151,000.
The contact owns a 2003 Ford Taurus. The contact stated that the brake lights failed to actuate as needed. The contact stated that while driving at an undisclosed speed, the vehicle failed to shift out of park(P) into gear. There were no warning lights illuminated. The vehicle was taken to the local dealer where it was diagnosed…
Read full complaint
The contact owns a 2003 Ford Taurus. The contact stated that the brake lights failed to actuate as needed. The contact stated that while driving at an undisclosed speed, the vehicle failed to shift out of park(P) into gear. There were no warning lights illuminated. The vehicle was taken to the local dealer where it was diagnosed that the brake light switch or wiring needed to be replaced. The vehicle was not repaired. The contact stated that the failure was related to NHTSA Campaign Number: 04V106000 (Exterior Lighting). The manufacturer was notified of the failure but no additional assistance was provided. The approximate failure mileage was 74,000.
Windshield
The contact owns a 2003 Ford Taurus. The contact stated the vehicle failed to release from the park position. The brake warning light was illuminated. The vehicle was taken to the local dealer where it was diagnosed the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the fai…
Read full complaint
The contact owns a 2003 Ford Taurus. The contact stated the vehicle failed to release from the park position. The brake warning light was illuminated. The vehicle was taken to the local dealer where it was diagnosed the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown. The contact stated the failure was similar to NHTSA Campaign number 04V106000 (Exterior Lighting).
TL* THE CONTACT OWNS A 2003 FORD TAURUS. THE CONTACT STATED THAT WHILE SLOWING DOWN WOULD NOT ACCELERATE WHEN PRESSING THE ACCELERATOR PEDAL AND WHILE SWITCHING GEARS THE VEHICLE WOULD LUNGE FORWARD. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER AND THE LOCAL DEALER FORSOM LAKE FORD(12755 FOLSOM BLVD, FORSOM LA…
Read full complaint
TL* THE CONTACT OWNS A 2003 FORD TAURUS. THE CONTACT STATED THAT WHILE SLOWING DOWN WOULD NOT ACCELERATE WHEN PRESSING THE ACCELERATOR PEDAL AND WHILE SWITCHING GEARS THE VEHICLE WOULD LUNGE FORWARD. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER AND THE LOCAL DEALER FORSOM LAKE FORD(12755 FOLSOM BLVD, FORSOM LAKE CA.) WAS NOTIFIED OF THE FAILURE BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 175,000.
MY INTERIOR LIGHT STAYS ON WHILE I'M DRIVING, AND WILL STAY ON 2-3 HOURS AFTER THE ENGINE HAS STOPPED.
WHILE DRIVING DOWN THE ROAD, IF I RELEASE THE GAS PEDAL, THE VEHICLE WILL CONTINUE TO INCREASE IN SPEED. WHEN I AM COMPLETELY STOPPED AT STOP SIGN OR STOP LIGHT, I HAVE TO PRESSED ON THE BRAKES REALLY HARD TO KEEP THE VEHICLE FROM SURGING FORWARD
ON OCTOBER 23 2019, I RETAINED MAVIS DISCOUNT TIRE TO INSPECT MY NEW YORK STATE REGISTERED 2003 FORD TAURUS. MAVIS DISCOUNT TIRE PASSED THE VEHICLE, DETERMINING THE VEHICLES CONDITION COMPLIED WITH NY STATE SAFETY STANDARD OF ROADWORTHINESS. 12/12/2019, AFTER REPAIRING THE TRANSMISSION AT GORILLA AUTO WORKS, I WAS INFORMED OF A …
Read full complaint
ON OCTOBER 23 2019, I RETAINED MAVIS DISCOUNT TIRE TO INSPECT MY NEW YORK STATE REGISTERED 2003 FORD TAURUS. MAVIS DISCOUNT TIRE PASSED THE VEHICLE, DETERMINING THE VEHICLES CONDITION COMPLIED WITH NY STATE SAFETY STANDARD OF ROADWORTHINESS. 12/12/2019, AFTER REPAIRING THE TRANSMISSION AT GORILLA AUTO WORKS, I WAS INFORMED OF A SERIOUS STRUCTURAL SITUATION, CONTROL ARM ASSEMBLY "SEVERELY DETERIORATED". ON JANUARY 20TH 2020, I AGAIN REFERRED THE VEHICLE TO CASKINETE FORD CARTHAGE NEW YORK FOR FURTHER EVALUATION, AT FORD MOTOR COMPANY STANDARDS, AS WAS INFORMED, THAT THE CONTROL ARM ASSEMBLY WAS NOT REPAIRABLE, AT THE PRESENT CONDITION, DID NOT MEET NEW YORK STATE OR FEDERAL SAFETY STANDARDS, CONTRARY TO THE ORIGINAL STATUS, AND INSPECTION , ISSUED 10/23/2019 MAVIS DISCOUNT TIRE ARSENAL ST. WATERTOWN NEW YORK. FURTHER EVALUATIONS, STUDY REVEALED, THAT FAILURE OF THIS CONDITION, UNDERWAY, AT US INTERSTATE AVERAGE SPEED OF TRAFFIC, POTENTIALLY CATASTROPHIC INCIDENT WOULD RESULT, EMINENT RISK OF LOSS OF LIFE. PER US AGENCY STANDARDS, I HAVE MADE ALL REASONABLE EFFORTS TO RESOLVE THIS COMPLAINT WITH RELEVANT STATE AGENCIES, DMV. ETC. ADDITIONAL EFFORTS INCLUDED RELEVANT NEW YORK STATE POLITICAL REPRESENTATIVES, TO INCLUDE NEW YORK STATE SENATE. *PLEASE NOTE THE, POSSIBLY INTENTIONAL OMISSION BY MAVIS STAFF, OF THE VEHICLES MILEAGE. OBTAINED BY OTHER RECORDS.
Official recalls
304V105000 · Engine And Engine Cooling
Mar 2, 2004
ON CERTAIN VEHICLES, THE AIR FILTER PAPER IN THESE VEHICLES CAN SMOLDER OR BURN.
Consequence & remedy
Consequence: THIS CAN LEAD TO DAMAGE TO THE AIR INDUCTION SYSTEM ON THESE VEHICLES AND/OR AN UNDERHOOD FIRE.
Remedy: DEALERS WILL REPLACE THE AIR FILTER ELEMENT. OWNER NOTIFICATION BEGAN ON MARCH 10, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
04V106000 · Exterior Lighting:brake Lights:switch
Mar 2, 2004
CERTAIN PASSENGER VEHICLES ARE BEING RECALLED TO CORRECT A PROBLEM WITH A MALFUNCTIONING STOP LAMP SWITCH AND/OR ASSOCIATED WIRING. THIS MALFUNCTIONING COULD RENDER THE STOP LAMPS INOPERABLE OR CAUSE THEM TO STAY ON ALL THE TIME. THIS COULD CAUSE CONFUSION TO A FOLLOWING DRIVER, WHICH COULD LEAD TO A CRASH.
Consequence & remedy
Consequence: IN ADDITION, IF THE SWITCH AND/OR ASSOCIATED WIRING FAIL IN THE OPEN POSITION, THE BRAKE LIGHTS WILL NOT ACTUATE AND THE DRIVER WILL NOT BE ABLE TO SHIFT THE VEHICLE OUT OF "PARK" IF THEY FAIL IN THE CLOSED POSITION, THE BRAKE LIGHTS WILL REMAIN ON, WHICH WILL NOT ALLOW THE SPEED CONTROL TO BE ACTIVATED. THIS COULD ALSO CAUSE THE BATTERY TO DISCHARGE.
Remedy: DEALERS WILL REMOVE THE STOP LAMP SWITCH AND ASSOCIATED WIRING ASSEMBLY AND INSTALL A NEWLY DESIGNED STOP LAMP SWITCH AND WIRE ASSEMBLY. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON APRIL 5, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
03V087000 · Visibility:windshield
Mar 10, 2003
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING." THE WINDSHIELDS MAY POTENTIALLY EXHIBIT INCREASED WIND NOISE, WATER LEAKAGE, AND SQUEAKS AND RATTLES.
Consequence & remedy
Consequence: POTENTIAL LOSS OF WINDSHIELD RETENTION MAY ALSO REDUCE OCCUPANT PROTECTION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THESE WINDSHIELDS. OWNER NOTIFICATION BEGAN ON MARCH 31, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD/MERCURY AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE12033 · Speed Control Cable Damage
Opened Oct 24, 2012 · Closed Jun 26, 2013
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:cruise Control
On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.
Additional source detail variants (3)
Vehicle Speed Control:cables
On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.
Vehicle Speed Control:cruise Control
On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.
Vehicle Speed Control
On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.
EA08018 · Front Suspension Coil Spring Fracture
Opened Aug 28, 2008 · Closed Jun 30, 2011
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
To date, ODI is aware of 2,401 non-duplicative complaints related to the alleged defect. In addition, ODI is aware of 1,411 subject vehicles with one or more warranty claims related to the alleged defect. In total, ODI is aware of 3,645 unique subject vehicles that have experienced one or more front suspension coil spring fractures. ODI is also aware of four minor crashes related to the alleged defect resulting in one minor injury.With greater than eight years of exposure, a large subject vehicle population and approximately 2,052 reported front tire punctures caused by fractured coil springs (at all speeds), there have been no reported severe crashes, deaths or injuries related to the alleged defect. The real world consequences of these defective coil springs have been a small number of minor control problems that resulted in minor damage; suggesting that the effect of the defect on vehicle control is minor.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted. Accordingly, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency will continue to monitor this issue and will take further action if warranted by the circumstances. See the EA08-018 Engineering Analysis Closing Report for more details.
DP06005 · Engine Stalling Ffv
Opened Dec 4, 2006 · Closed Dec 28, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:fuel Injection System; Fuel System, Gasoline:fuel Injection System:fuel Rail; Fuel System, Gasoline:fuel Injection System:injectors; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:auxillary Tank; Fuel System, Gasoline:storage:auxillary Tank:selector Devices; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap; Fuel System, Gasoline:storage:tank Assembly:mounting; Fuel System, Other; Fuel System, Other:delivery; Fuel System, Other:delivery:fuel Pump; Fuel System, Other:delivery:hoses, Lines/piping, And Fittings; Fuel System, Other:fuel Injection System; Fuel System, Other:storage; Fuel System, Other:storage:fuel Gauge System; Fuel System, Other:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:filling/charging; Fuel System, Other:storage:tank Assembly:mounting; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Additional source detail variants (23)
Fuel System, Gasoline:delivery
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:delivery:fuel Pump
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:fuel Injection System
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:fuel Injection System:injectors
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage:auxillary Tank
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage:auxillary Tank:selector Devices
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage:tank Assembly
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage:tank Assembly:mounting
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:delivery
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:delivery:fuel Pump
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:fuel Injection System
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage:fuel Gauge System
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage:tank Assembly:filling/charging
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage:tank Assembly
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage:tank Assembly:mounting
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
RQ03008 · Brake Light Switch Failure
Opened Oct 23, 2003 · Closed Mar 5, 2004
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Exterior Lighting:tail Lights; Exterior Lighting:tail Lights:switch
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Additional source detail variants (5)
Exterior Lighting:brake Lights
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Exterior Lighting:brake Lights:switch
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Exterior Lighting
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Exterior Lighting:tail Lights
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Exterior Lighting:tail Lights:switch
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.