NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
34 reportsClear category filterMileage unknown · Apr 17, 2023
Unknown Or OtherVisibility
With high outside temperatures A/C unit was on, but only the heating system was working. Air Conditioning system was not functuning and heating system would not go off. With windows down, inside tempearture was over 100 degrees and passing out due to heat was happening. Ford Dealer inspected the problem and said it was a manufac…
Read full complaint
With high outside temperatures A/C unit was on, but only the heating system was working. Air Conditioning system was not functuning and heating system would not go off. With windows down, inside tempearture was over 100 degrees and passing out due to heat was happening. Ford Dealer inspected the problem and said it was a manufacture malfunction. After repairing, the same issue developed again five days later. Ford dealer said it was another malfunctioning manufacture part.
NHTSA ODI #11517351
Mileage unknown · Apr 27, 2022
Unknown Or Other
The front passenger door mechanism failed. the actuator that grips onto the metal latch on the truck's frame is locked in the up position, preventing the door from closing. That creates a safety problem because the door will not close or latch.
NHTSA ODI #11462506
Mileage unknown · Mar 18, 2022
Fuel/propulsion SystemUnknown Or Other
Unknown, My vehicle seems to stall in low gear. I already informed the dealership several times, and they stated that everything was fine. The stalling appears to be getting more frequent as time goes on, and worried that this could cause further damage to the vehicle. This is a safety concern as well.
NHTSA ODI #11457217
Mileage unknown · Mar 12, 2022
EngineFuel/propulsion SystemUnknown Or Other
Drive truck and park in garage and garage smells like gas. Only happens when parking truck in garage right after driving it. This has happened about 3-4 times now. I don't drive it that often. Just had an oil change at Ford and drove home. Then the next day i took it out and parked it in garage and gas smell again. Smell wi…
Read full complaint
Drive truck and park in garage and garage smells like gas. Only happens when parking truck in garage right after driving it. This has happened about 3-4 times now. I don't drive it that often. Just had an oil change at Ford and drove home. Then the next day i took it out and parked it in garage and gas smell again. Smell will last 2-3 days if truck stays parked. Have an appt. this coming week at Ford.
NHTSA ODI #11456425
Mileage unknown · Feb 17, 2022
Unknown Or OtherCrash
I was slowly pulling forward, parking my vehicle. I pressed the brakes and they did not engage. I pumped my brakes and my foot was down to the floor with no brake activity and an involuntary acceleration occurred causing me to crash into a brick wall. Fortunately, I was the only person injured in the crash. The police were ca…
Read full complaint
I was slowly pulling forward, parking my vehicle. I pressed the brakes and they did not engage. I pumped my brakes and my foot was down to the floor with no brake activity and an involuntary acceleration occurred causing me to crash into a brick wall. Fortunately, I was the only person injured in the crash. The police were called and my vehicle was towed to be repaired. It was inspected by my insurance company. I called Ford several times to ask that the vehicle be inspected by a Ford investigator to determine why the brakes failed and the involuntary acceleration occurred. They misdirected me at least 10 times. I informed that there were 12 reports of the identical problem happening to other 2019 Ford Ranger owners. They ignored my requests. Upon recommendation by Ford Customer Service, my car was towed from a body shop to a Ford dealer where they informed by that there was at least one instance that the diagnostics showed a sensor failure. At no time did any warning light appear on my dash signaling me there was an issue of a sensor failure. In spite of this problem, Ford continues to ignore my request for an inspection of the vehicle. I went to a Doctor as I had a very bad headache and pain throughout my body. I had a concussion and soft tissue damage along my right side, both hands and elbows.
NHTSA ODI #11452558
Mileage unknown · Feb 7, 2022
Electrical SystemUnknown Or OtherFire
On Jan 04,2022 while flat towing my truck behind my motorhome it caught fire and burned to the ground. It was too badly burned for the insurance to make a determination of the cause. However, it started in the engine compartment. I know it was not a bad tire because all tires were inflated until the fire popped them. I was able…
Read full complaint
On Jan 04,2022 while flat towing my truck behind my motorhome it caught fire and burned to the ground. It was too badly burned for the insurance to make a determination of the cause. However, it started in the engine compartment. I know it was not a bad tire because all tires were inflated until the fire popped them. I was able to get the truck disconnected from the RV and know that it remain in Neutral with nothing seized up like the transmission or brakes because the truck rolled on its own once it was disconnected and had to be chocked. I had followed all the proper procedures and my key was in acc position. I had towed this truck many hundred miles prior. That day I had towed it 5-6 hours prior to the fire. This incident took place in Alachua County Florida. Alachua County Fire Rescur case # ACFR22-0000462 Alachua Police Department case #22APD00014 State Farm Insurance Claim #36-29co-58s
NHTSA ODI #11450843
Mileage unknown · Aug 17, 2021
Unknown Or Other
I am certain my vehicle does not shift correctly. It often seems to be in the wrong gear for the terrain and according to the dashboard seems to skip gears. Also it seems to not get the power to the road as if the transmission slips. It is intermittent. The start stop feature which I usually turn off, sometimes does not work cor…
Read full complaint
I am certain my vehicle does not shift correctly. It often seems to be in the wrong gear for the terrain and according to the dashboard seems to skip gears. Also it seems to not get the power to the road as if the transmission slips. It is intermittent. The start stop feature which I usually turn off, sometimes does not work correctly. I have only had this vehicle for about 5 months. When the start stop feature is off the vehicle still acts as if its on. I have read blogs of many people having similar transmission issues. A local Ford dealer told me it drove fine, nature of the beast and it shifts that way to save fuel. Also on off the gas there is a hard clunk which seem to harsh. I feel like at some point something is going to fail.
NHTSA ODI #11429397
125 miles · Nov 19, 2020
Unknown Or Other
PURCHASED A 2019 FORD RANGER IN JUNE 2020. IN JULY, I NOTICED THAT THE IGNITION TRIM RING BEZEL, A PART TO SECURE THE IGNITION CYLINDER TO THE STEERING COLUMN WAS MISSING AND THE CYLINDER COULD POSSIBLY DETACH. I CONTACTED THE DEALERSHIP TWICE AND HAVE NO RESPONSE.
NHTSA ODI #11375353
840 miles · Aug 12, 2020
Electrical SystemEngineUnknown Or Other
AFTER THE AUTO START STOP FEATURE ENGAGES AT A STOP, THE ENGINE BEGINS TO RE-START BUT THEN SHUTS DOWN COMPLETELY ALONG WITH ALL ELECTRIC FUNCTIONS IN THE VEHICLE. CANNOT ENGAGE HAZARD LIGHTS OR RE-START THE ENGINE UNTIL THE THE BATTERY IS JUMP-STARTED. ONCE THE VEHICLE IS JUMPED, IT FUNCTIONS NORMALLY AND DOES NOT DISPLAY ANY B…
Read full complaint
AFTER THE AUTO START STOP FEATURE ENGAGES AT A STOP, THE ENGINE BEGINS TO RE-START BUT THEN SHUTS DOWN COMPLETELY ALONG WITH ALL ELECTRIC FUNCTIONS IN THE VEHICLE. CANNOT ENGAGE HAZARD LIGHTS OR RE-START THE ENGINE UNTIL THE THE BATTERY IS JUMP-STARTED. ONCE THE VEHICLE IS JUMPED, IT FUNCTIONS NORMALLY AND DOES NOT DISPLAY ANY BATTERY OR CHECK ENGINE INDICATOR. THIS HAPPENED ONCE AT A STOP SIGN IN A RESIDENTIAL AREA, AND AGAIN AT A RED LIGHT ON A MULTI-LANE BOULEVARD WITH SPEED LIMIT 45 MPH.
NHTSA ODI #11348791
4,200 miles · Jun 9, 2020
Unknown Or OtherVisibility/wiper
THE PASSENGER SIDE FRONT WINDOW IS DEVELOPING SEVERAL SNOWFLAKE LIKE DEFECTS IN BETWEEN THE GLASS. THESE ARE THREE TO FOUR INCHES IN DIAMETER AND IMPEDE THE SIDE VISION OF THE VEHICLE. FORD IS REFUSING TO REPLACE THE GLASS. THIS IS A SAFETY HAZARD AND NEEDS TO BE INVESTIGATED. THE SIZE GROWS AN 1/8 INCH A DAY AND DOES NOT ST…
Read full complaint
THE PASSENGER SIDE FRONT WINDOW IS DEVELOPING SEVERAL SNOWFLAKE LIKE DEFECTS IN BETWEEN THE GLASS. THESE ARE THREE TO FOUR INCHES IN DIAMETER AND IMPEDE THE SIDE VISION OF THE VEHICLE. FORD IS REFUSING TO REPLACE THE GLASS. THIS IS A SAFETY HAZARD AND NEEDS TO BE INVESTIGATED. THE SIZE GROWS AN 1/8 INCH A DAY AND DOES NOT STOP. THE SPOT IN THE PICTURE IS NEARLY DOUBLE IN SIZE NOW. *TR
NHTSA ODI #11327953
Official recalls
11Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Sep 3, 2025
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence & remedy
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
May 26, 2023
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco, 2023 Super Duty F-250, and 2019-2023 Ranger vehicles. The Tire and Loading Information (TREAD) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An overloaded vehicle increases the risk of a crash.
Remedy: Ford will mail a new TREAD label to install over the existing label, free of charge. Owners will also have the option to take their vehicle to a Ford or Lincoln dealer to have the new label installed, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C18.
Oct 15, 2021
Ford Motor Company (Ford) is recalling certain 2019-2021 Ford Ranger Super Cab vehicles. The front passenger outboard seat belt may not have been assembled properly, allowing the seat belt to be misrouted. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occupant Crash Protection" and 209, "Seat Belt Assemblies."
Consequence & remedy
Consequence: A misrouted seat belt may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will provide owners with instructions to perform a preliminary inspection of their front seat belts. Owners that detect an issue with the driver's seat belt, are unsure of the results, or do not want to perform an inspection, should not drive their vehicles and contact a Ford dealership. Dealers will inspect the front row outboard seat belts and replace them, if necessary, free of charge. Interim owner notification letters were mailed on November 5, 2021. Owner notification letters were mailed December 22, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C25.
Mar 9, 2020
Ford Motor Company (Ford) is recalling certain 2019 Ranger vehicles previously repaired under recall 19V-726. The service replacement Heating, Ventilating and Air Conditioning (HVAC) blower motor that was installed may have an improper clearance between an electrical terminal and the conductive base plate that may result in an resistive electrical short.
Consequence & remedy
Consequence: A resistive electrical short increases the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect and replace the HVAC blower motor, as necessary, free of charge. The recall began April 6, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S12.
Nov 21, 2019
Ford Motor Company (Ford) is recalling certain 2019 Ranger trucks. The inline electrical connector terminals for the rear lights may be misaligned or not properly seated, potentially causing the rear lights to function intermittently or not at all.
Consequence & remedy
Consequence: Intermittent or inoperative tail lamps can result in loss of stop, turn, rear position, and reverse lamp functions, which reduces the vehicle's visibility and may not fully alert other drivers that the vehicle is braking, turning, or reversing, increasing the risk of crash.
Remedy: Ford will notify owners, and dealers will inspect the inline connector for loose terminals and replace the connectors, if necessary, free of charge. The recall began March 5, 2020. A renotification was sent on July 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S43.
Oct 10, 2019
Ford Motor Company (Ford) is recalling certain 2019 Ranger vehicles. The Heating, Ventilating and Air Conditioning (HVAC) blower motor may electrically short.
Consequence & remedy
Consequence: An electrical short can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the HVAC blower motor production date, replacing it as necessary, free of charge. The recall began December 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S34.
Jul 10, 2019
Ford Motor Company (Ford) is recalling certain 2019 Ford Ranger vehicles with a SuperCab body style. The front passenger seat belt may have been improperly assembled.
Consequence & remedy
Consequence: Improperly assembled seat belts may not adequately restrain occupants in a crash, increasing their risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the right front seat belt assembly, free of charge. The recall began July 29, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S23.
May 13, 2019
Ford Motor Company (Ford) is recalling certain 2019 Ranger vehicles. The fasteners that attach the transmission shifter cable bracket to the transmission may loosen allowing the transmission to be in a different gear than indicated by the gear shift lever position.
Consequence & remedy
Consequence: If the gear shift lever position does not match the actual transmission gear, the vehicle may move in an unexpected direction. Additionally, despite selecting 'Park', if the parking brake is not applied before the vehicle is exited, the vehicle may roll. Either scenario increases the risk of crash or injury.
Remedy: Ford will notify owners, and dealers will inspect and tighten the transmission shift cable bracket fasteners as necessary, and verify the proper transmission shift operation, free of charge. The recall began July 1, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S15.
Feb 1, 2019
Ford Motor Company (Ford) is recalling certain 2019 Ranger vehicles equipped with 10-speed automatic transmissions. In some of these vehicles, the transmission shift lever can be moved from the "Park" position without the key in the starting system and without depressing the brake pedal. As a result, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence & remedy
Consequence: If the vehicle can be shifted out of Park without the brake applied, the vehicle may unexpectedly move. Unintentional vehicle movement can increase the risk of injury or crash.
Remedy: Ford has notified owners, and dealers will inspect and repair the transmission floor shift selector interlock assembly, as necessary, free of charge. The recall began February 22, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C02.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration