NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
34 reportsClear category filterMileage unknown · Mar 2, 2024
EngineUnknown Or Other
2019 Ford Rangers were shipped without an engine cover to protect the engine from water intrusion. This, along with the design of the plastic cowl at the base of the windshield being a 2 piece design with a seam directly over the engine bay, allows water to drain into the engine bay during periods of heavy rain. Water will drai…
Read full complaint
2019 Ford Rangers were shipped without an engine cover to protect the engine from water intrusion. This, along with the design of the plastic cowl at the base of the windshield being a 2 piece design with a seam directly over the engine bay, allows water to drain into the engine bay during periods of heavy rain. Water will drain from the windshield into the top of the engine, and begin filling the spark plug wells under the ignition coil boots and into the engine head. This water intrusion can cause engine misfire codes as well as a loss of power while driving, and on multiple instances while merging into traffic, the engine would bog down. It wasn't until the most recent occurrence that a check engine light came on. I immediately pulled into a shop and they found the plug wells were rusted, corroded and full of water from this happening since the day it rolled off the lot in 2019. I have had an independent mechanic assess the damage as well as had the vehicle towed to a local Ford dealer and they found the same condition- with the only solution to replace the engine head as they are unable to remove the plugs due to the damage caused by the water intrusion. An owner should not have to be concerned with parking or driving a vehicle in the rain and whether it will suddenly lose power while driving at highway speeds. This is a safety issue that Ford should be forced to take care of. They are aware of the issue and have been as they have issued multiple service bulletins with a solution for misfires to change plugs and install an engine cover. An engine cover has no bearing on an engine misfire but it shows Ford knows water is getting into engines and causing these problems. Engine/plugs/coils failed, it is available for inspection. Mine and public safety was at risk when driving as it lost power merging into traffic. Problem has been confirmed by dealer and independent mechanic. Last instance (2/9/24) was first time a CEL came on while driving
NHTSA ODI #11575053
Mileage unknown · Feb 26, 2024
Unknown Or OtherVisibility
Heater box went out due to a defective heater door. This caused the front windshield to ice over and not being able to see other traffic. No warm air would come out of the vents .Heater box was replaced by the Dealer at the cost to owner.
NHTSA ODI #11574078
Mileage unknown · Dec 22, 2023
Fuel/propulsion SystemService BrakesUnknown Or OtherCrash
Unintended Aceleration Veheicle experienced normal stop with no anomaly. Upon release of brakes, experienced reported Wide Open Throttle" Brakes were ineffective. Vehicle accelerate thru intersection striking guardrail with significant damage. WOT stopped by shutting of engine. Vehicle currently in repair. Reported event to loca…
Read full complaint
Unintended Aceleration Veheicle experienced normal stop with no anomaly. Upon release of brakes, experienced reported Wide Open Throttle" Brakes were ineffective. Vehicle accelerate thru intersection striking guardrail with significant damage. WOT stopped by shutting of engine. Vehicle currently in repair. Reported event to local dealer service dept, Insurance Rep and Ford referencing 2010 Class Action Lawsuit for similar events, All claim no knowledge of such an event. Vehicle had no previous reports of similar events
NHTSA ODI #11561429
Mileage unknown · Oct 31, 2023
Unknown Or OtherVisibility
I was driving over a bridge at 65 mph on a foggy morning a couple weeks ago and my windshield fogged over. I turned on the defroster and it only blew cold air. I could not see and I couldn't clear it. I had to slow down and find a safe spot to pull over. I had to try to wipe down the windshield and then start driving. It did it…
Read full complaint
I was driving over a bridge at 65 mph on a foggy morning a couple weeks ago and my windshield fogged over. I turned on the defroster and it only blew cold air. I could not see and I couldn't clear it. I had to slow down and find a safe spot to pull over. I had to try to wipe down the windshield and then start driving. It did it again and i had to pull over again and wipe and wait for it to clear to be able to drive. It was foggy the next morning and I had to do the same thing all over again. I stopped by a ford dealer and spoke to someone. He told me, oh yeah we know all about it and so does ford. The ac heater chamber in the dash breaks. Costs about 2 grand to fix. All the new rangers do it. This is a safety defect and needs to be recalled by ford. Thank you.
NHTSA ODI #11552889
Mileage unknown · Oct 13, 2023
Unknown Or Other
Ticking sound when i turn off vehicle. Usually did it for about 5 seconds, Now it just keeps on ticking and sounds like it is coming from behind glove box area passenger side. Found a lot of same complaints for this year Ranger and they mention the "Blend Door". If so many complaints shouldn't it be a recall?
NHTSA ODI #11549861
Mileage unknown · Oct 11, 2023
Electrical SystemLane DepartureUnknown Or Other
Vehicle presented a blind spot system fault warning and a cross traffic system fault. Immediately after this warning appears the vehicle ac/ heater shutdown, passengers seat belts light came up and radio got frozen. None of the ac/ heater controls worked. Blinkers appears to be advising that the were not working properly. Vehic…
Read full complaint
Vehicle presented a blind spot system fault warning and a cross traffic system fault. Immediately after this warning appears the vehicle ac/ heater shutdown, passengers seat belts light came up and radio got frozen. None of the ac/ heater controls worked. Blinkers appears to be advising that the were not working properly. Vehicle rums but everything else regarding de console stopped working.
NHTSA ODI #11549414
Mileage unknown · Aug 23, 2023
EnginePower TrainUnknown Or Other
The vehicle is shifting rough between 2nd and 3rd gear. It has trouble getting up to speed through intersections.
NHTSA ODI #11540407
Mileage unknown · Jul 18, 2023
Electrical SystemUnknown Or Other
See related steering problem report. After Electronic Power Steering Assist went out on vehicle without warning of any kind to owner, dealer's service department diagnostics as best as I can determine did NOT indicate a problem with the parts that were replaced. The parts replaced were: 1. steering gear/rack and pinion/EPAS (whi…
Read full complaint
See related steering problem report. After Electronic Power Steering Assist went out on vehicle without warning of any kind to owner, dealer's service department diagnostics as best as I can determine did NOT indicate a problem with the parts that were replaced. The parts replaced were: 1. steering gear/rack and pinion/EPAS (which seems to go by various names), and, when installing this new, expensive, and long-in-coming part didn't get the power steering to work, 2. the battery. The scenario suggests that the root problem was the battery, not the steering gear. A representative of another dealer has advised that the first thing they check in cases involving electronic components is the battery. He also advised that Ford does not have a standard operating procedure or service bulletin that says this is something that is to be done. Can this be? Apparently, at least for this vehicle, there was/is no system to check for adequate battery voltage or to warn that electronic components like the power steering may fail if the battery is not replaced. If my research results are correct, the Diagnostic Trouble Codes the Ford dealer repair tech found went to a steering angle sensor in the steering column, and things having to do with the anti-lock brake system. They weren't fixed, but the codes disappeared after the new battery was installed. The diagnostic tools seem to give more misdirection than direction. With so many critical electrical components in today's vehicles, the warning and diagnostic systems seem woefully inadequate. I have read about Fords limiting battery recharging to about 75% and have noted that one of the DTCs involved here, U3003, sets on-demand if the voltage supplies to the ABS module falls below 10 volts. I'm a layman, but these things suggest to me that some of the electronic components require substantial minimum operating voltage which an older battery would not supply, and the recharging cap could exacerbate the problem.
NHTSA ODI #11533105
Mileage unknown · Jun 8, 2023
Unknown Or Other
2019 Ford Ranger air conditioning compressor failed. When compressor seized, the component smelt of burning. The compressor failure has been confirmed by the Ford dealership. There was no warnings prior to the problem occurring. Similar recalls have been made on other 2019 Ford Rangers.
NHTSA ODI #11526107
Mileage unknown · May 4, 2023
Unknown Or Other
The air conditioner blows hot air on the driver's side and cold air on the passenger side. No safety issues. It has not been verified by a dealer. We notified them a year ago. No warning lights.
NHTSA ODI #11520524
Official recalls
11Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Sep 3, 2025
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence & remedy
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
May 26, 2023
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco, 2023 Super Duty F-250, and 2019-2023 Ranger vehicles. The Tire and Loading Information (TREAD) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An overloaded vehicle increases the risk of a crash.
Remedy: Ford will mail a new TREAD label to install over the existing label, free of charge. Owners will also have the option to take their vehicle to a Ford or Lincoln dealer to have the new label installed, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C18.
Oct 15, 2021
Ford Motor Company (Ford) is recalling certain 2019-2021 Ford Ranger Super Cab vehicles. The front passenger outboard seat belt may not have been assembled properly, allowing the seat belt to be misrouted. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occupant Crash Protection" and 209, "Seat Belt Assemblies."
Consequence & remedy
Consequence: A misrouted seat belt may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will provide owners with instructions to perform a preliminary inspection of their front seat belts. Owners that detect an issue with the driver's seat belt, are unsure of the results, or do not want to perform an inspection, should not drive their vehicles and contact a Ford dealership. Dealers will inspect the front row outboard seat belts and replace them, if necessary, free of charge. Interim owner notification letters were mailed on November 5, 2021. Owner notification letters were mailed December 22, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C25.
Mar 9, 2020
Ford Motor Company (Ford) is recalling certain 2019 Ranger vehicles previously repaired under recall 19V-726. The service replacement Heating, Ventilating and Air Conditioning (HVAC) blower motor that was installed may have an improper clearance between an electrical terminal and the conductive base plate that may result in an resistive electrical short.
Consequence & remedy
Consequence: A resistive electrical short increases the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect and replace the HVAC blower motor, as necessary, free of charge. The recall began April 6, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S12.
Nov 21, 2019
Ford Motor Company (Ford) is recalling certain 2019 Ranger trucks. The inline electrical connector terminals for the rear lights may be misaligned or not properly seated, potentially causing the rear lights to function intermittently or not at all.
Consequence & remedy
Consequence: Intermittent or inoperative tail lamps can result in loss of stop, turn, rear position, and reverse lamp functions, which reduces the vehicle's visibility and may not fully alert other drivers that the vehicle is braking, turning, or reversing, increasing the risk of crash.
Remedy: Ford will notify owners, and dealers will inspect the inline connector for loose terminals and replace the connectors, if necessary, free of charge. The recall began March 5, 2020. A renotification was sent on July 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S43.
Oct 10, 2019
Ford Motor Company (Ford) is recalling certain 2019 Ranger vehicles. The Heating, Ventilating and Air Conditioning (HVAC) blower motor may electrically short.
Consequence & remedy
Consequence: An electrical short can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the HVAC blower motor production date, replacing it as necessary, free of charge. The recall began December 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S34.
Jul 10, 2019
Ford Motor Company (Ford) is recalling certain 2019 Ford Ranger vehicles with a SuperCab body style. The front passenger seat belt may have been improperly assembled.
Consequence & remedy
Consequence: Improperly assembled seat belts may not adequately restrain occupants in a crash, increasing their risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the right front seat belt assembly, free of charge. The recall began July 29, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S23.
May 13, 2019
Ford Motor Company (Ford) is recalling certain 2019 Ranger vehicles. The fasteners that attach the transmission shifter cable bracket to the transmission may loosen allowing the transmission to be in a different gear than indicated by the gear shift lever position.
Consequence & remedy
Consequence: If the gear shift lever position does not match the actual transmission gear, the vehicle may move in an unexpected direction. Additionally, despite selecting 'Park', if the parking brake is not applied before the vehicle is exited, the vehicle may roll. Either scenario increases the risk of crash or injury.
Remedy: Ford will notify owners, and dealers will inspect and tighten the transmission shift cable bracket fasteners as necessary, and verify the proper transmission shift operation, free of charge. The recall began July 1, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S15.
Feb 1, 2019
Ford Motor Company (Ford) is recalling certain 2019 Ranger vehicles equipped with 10-speed automatic transmissions. In some of these vehicles, the transmission shift lever can be moved from the "Park" position without the key in the starting system and without depressing the brake pedal. As a result, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence & remedy
Consequence: If the vehicle can be shifted out of Park without the brake applied, the vehicle may unexpectedly move. Unintentional vehicle movement can increase the risk of injury or crash.
Remedy: Ford has notified owners, and dealers will inspect and repair the transmission floor shift selector interlock assembly, as necessary, free of charge. The recall began February 22, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C02.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration