2019 Ford Ranger

The cooling fan clutch control wire is supported by a "wire support hose" between the engine block and the fan clutch. the cooling fan clutch control freely rotates on a raceway on the drive shaft. The purpose of the support hose is to prevent the fan clutch control from freely rotating, but allows the control a limited range of movement as the drive shaft changes speed with engine RPM. The idea is that this hose prevents undue stress on the control wire. Hose is normally a consumable part that may need replaced with age, heat, etc. The hose is not sold as a replacement part and can only be obtained by purchasing a new fan clutch. When the hose fails, the control wraps around the drive shaft causing damage to the fan clutch control and wiring requiring replacement. The circuit on which the fan clutch control sits is integrated with no less than 6 other critical vehicle systems including oil pressure. When the incident occurs, all these systems generate errors that put the vehicle into limp mode until repair can be made. The fan clutch control wiring support hose should be a bracket with a different mechanical linkage solution to support wire while allowing the necessary limited movement. This low-tech hose solution causes outsized damage when it fails, effectively disabling the vehicle which creates a safety concern and undue hardship from an unnecessarily cascading damage effect. Ford acknowledges this defect by redesigning this feature for 6G Rangers but will not proactively correct through manufacturer recall 5G Rangers. If Ford will not correct, I believe the NHTSA should get involved and force Ford's hand at addressing this repair.

he 2019 Ford Ranger the VIN [XXX] , the driver’s side AC only blows hot due to the climate control issue addressed in Fords service bulletin SSM 51313. This is a known issue with the early production model of the Ranger, hence the service bulletin SSM 51313. It is my belief that faulty parts were used on the early model Rangers and instead of a recall or extending the warranty on this issue only issued a service bulletin was put out. I am writing to have the Ford MOCO issue the proper recall or cover repairs under and extended warranty. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2019 ford ranger, 74,000 miles On way to pick up girlfriends engagement ring…. The truck started jerking, loosing power, no engine light came on. Turned around to go home and drive about 8 miles under 45 mph.Then truck started jerking again , like transmission issue. Engine light and tool wrench came on. As I was pulling in driveway, truck went into “limp” mode. Had it towed to Gullo Ford Conroe. Now they are saying need new transmission due to Internal transmission failure! Shouldn’t Ford. Over this! Only 60,000 mile warranty.

The climate control system on my 2019 Ford Ranger has a recurring failure that prevents the vehicle from properly adjusting temperature or directing air through the vents. The failure causes a constant clicking/snapping noise behind the dashboard, and the blend door does not move when the temperature is changed. This malfunction matches Ford’s published SSM 49264, which identifies a known defect in 2019–2020 Rangers built on or before 7/30/2020 and states that the entire HVAC housing assembly must be replaced. This issue creates a safety hazard because the truck cannot reliably defrost the windshield in cold or wet weather. Loss of defrosting capability severely limits visibility and makes safe operation of the vehicle difficult. The issue is reproducible every time the temperature is adjusted. The problem began when the vehicle was still within the original mileage window of the factory warranty, but the dealership did not repair it. Ford has confirmed the malfunction is caused by the blend door system, yet they have refused goodwill coverage for a repair that requires full dash removal and replacement of a known defective part. There were no warning lights, but the clicking noise and loss of temperature control began well before the warranty expired. The vehicle continues to experience the defect, and it poses an ongoing visibility and safety risk. Ford has acknowledged this exact failure mode in writing (SSM 49264), but has not issued a recall or safety campaign.

Repeated failure of HVAC system, even after repairs, leads to not only a very cold truck in January in Maine, but inability to defrost the windshield and keep it defrosted. Repairs have been made in January 2025, April 2025, and now has to be repaired again in December 2025. My independent service provider who subscribes to OEM Ford subscriptions, was not made aware of an "internal" service memo until now. Neither from the subscription services or from contacts at a Ford dealer where he resourced parts and repair info. SSM 51313 indicates a different repair than was made on the previous two attempts. These repairs require the disassembly and reassembly of the instrument panel and are very expensive - especially when not apprised of correct. Now the SSM indicates a complete housing replacement to correct the defective part. See attached forms.

The transmission in my truck has worked excellently with no sign of wear or degredation in performance, that was until the transmission suddenly began hesitating and slamming into gear. This is a common problem with this vehicle and is reported online incredibly frequently, while this may seem like a simple mechanical issue it did cause a completely lost of power when making a left hand turn which nearly caused me to be T-bone'd by oncoming traffic, and the hard shifting makes throttle response incredibly unpredictable. Please help us with this, there are recalls on the transmission in these trucks in multiple other countries with the chance of death as a consequence being openly stated. Me and my loved ones were almost killed because of this transmission which has widespread problems and NEEDS to be recalled before someone does lose their life. Ford has claimed this to be due to the adaptive learning software in the truck, but coincidentally has also redesigned a critical component in the transmission that causes these types issues three times now, but with zero effort to notify the customer of the risk or to openly address the problem.

I started hearing a ticking sound under the dash on the driver's side. Then it would blow hot air on drivers side and cold air on passenger side whether it was on heat or air conditioning. We also smelt plastic once in awhile. I took it in and was told it was it was the actuator. They replaced that and that took care of the noise but not the 2 different air Temps. Took it back and now was told the distribution housing needs to be replaced. I have read on a recall for the HVAC system it could catch on fire so the melting plastic smell concerns me.

Apparently the heater box in the 2019 Ranger is prone to warping. This leads to malfunctions in the heat/ac in the cabin. They tell me if I don’t get it replaced I could wind up getting ac instead of heat. This would be a real problem in winter weather, as I may not be able to keep the windshield clear without heat. I saw many complaints about this happening to owners of the 2019 Ford Ranger. The fix is to remove the dashboard to install a new box at a cost of 2200.00, according to the Ford dealership I bought the truck from.

HVAC BLOWER MOTOR NEEDS REPLACED AND EVAP BOX PER FORD DEALERSHIP TODD JUDY FORD. THERE HAS BEEN A PREVIOUS RECALL ON THE SAME MODEL FORD RANGER YEAR 2019. AIR CONDITIONING WORK FINE ON THE PASSENGER VENTS BUT BLOWS OUT HOT AIR ON DRIVERS SIDE. 2 SEPARATE MECHANICS AT INDEPENDENT MECHANIC AND TODD JUDY FORD DEALERSHIP REPORT THERE HAVE BEEN PROBLEMS WITH THE FORD RANGER AIR CONDITIONING AND HEATING SYSTEM REGARDING DUAL TEMPERATURE UNITS. DEALERSHIP REPORTS THAT THIS IS NOT COVERED UNDER WARRANTY AND IS ESTIMATED $3200 IN REPAIR. THE INDEPENDENT MECHANIC IS NOT ABLE TO OBTAIN THE PART AND DISCOVERED THERE WAS A PREVIOUS RECALL ON THIS PART ON THE 2019 FORD RANGER. I HAVE CONTACTED FORD CUSTOMER SERVICE DEPARTMENT AND THEY SPECIFY THAT THIS PART AND FAILURE OF MY 2019 FORD RANGER DOES NOT HAVE MY VEHICLE LISTED UNDER THE RECALL ALTHOUGH IT IS THE SAME MODEL. THE PROBLEM WAS DISCOVERED ON [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)