TL*THE CONTACT OWNS A 2003 FORD RANGER. THE CONTACT STATED THAT WHILE TRAVELING 60 MPH THE HOOD ON HIS VEHICLE CAME OPEN AND OBSCURED HIS VISION. THE LATCH ON THE HOOD AND THE HOOD CABLE ALSO FAILED. THE DEALER STATED THAT THE REPAIRS WOULD BE APPROXIMATELY $260.00 AT THE OWNERS EXPENSE. THE VEHICLE WAS NOT REPAIRED. THE CURRE…
Read full complaint
TL*THE CONTACT OWNS A 2003 FORD RANGER. THE CONTACT STATED THAT WHILE TRAVELING 60 MPH THE HOOD ON HIS VEHICLE CAME OPEN AND OBSCURED HIS VISION. THE LATCH ON THE HOOD AND THE HOOD CABLE ALSO FAILED. THE DEALER STATED THAT THE REPAIRS WOULD BE APPROXIMATELY $260.00 AT THE OWNERS EXPENSE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 86,000. UPDATED 12/22/10 *BF THE CONSUMER STATED HE FIXED THE PROBLEM HIMSELF. UPDATED 12/23/10
NHTSA ODI #10353256
43,220 miles · Nov 26, 2008
Latches/locks/linkagesStructure
WHILE USING RAMPS TO LOAD LAWN EQUIPMENT INTO THE BED OF MY 2003 FORD RANGER PICKUP, BOTH OF THE TAILGATE LIMIT CABLES BROKE SIMULTANEOUSLY. EXAMINATION OF THE FAILED CABLED INDICATED THEY BOTH BROKE AT THE SAME LOCATION, ROUGHLY THE MIDPOINT OF THE CABLE WHERE IT IS FOLDED WHEN THE TAILGATE IS IN THE UP POSITION. IT WOULD APP…
Read full complaint
WHILE USING RAMPS TO LOAD LAWN EQUIPMENT INTO THE BED OF MY 2003 FORD RANGER PICKUP, BOTH OF THE TAILGATE LIMIT CABLES BROKE SIMULTANEOUSLY. EXAMINATION OF THE FAILED CABLED INDICATED THEY BOTH BROKE AT THE SAME LOCATION, ROUGHLY THE MIDPOINT OF THE CABLE WHERE IT IS FOLDED WHEN THE TAILGATE IS IN THE UP POSITION. IT WOULD APPEAR THAT WATER MIGHT HAVE ENTERED THE CABLE SHEATH AND RUSTED THE CABLE. THIS FAILURE RESULTED IN THE TAILGATE DROPPING APPROXIMATELY SIX INCHED AND NEARLY CAUSING TWO PERSONS PLUS HEAVY EQUIPMENT TO FALL TO THE GROUND. THIS COULD HAVE RESULTED IN SERIOUS INJURY. THIS APPEARS TO BE A CLASSIC DESIGN FLAW. I TRIED TO GET NEW CABLES FROM FORD, BUT THEY ARE ON BACKORDER PENDING RE-DESIGN (ACCORDING TO THE PARTS DEPARTMENT AT THE FORD DEALER I WENT TO). THIS SEEMS TO INDICATE THAT FORD IS AWARE OF THE PROBLEM BUT HAS NOT NOTIFIED ITS CUSTOMERS. *TR
NHTSA ODI #10249944
98,592 miles · Jun 25, 2008
Latches/locks/linkages
THE STEEL CABLES THAT SUPPORT THE TAIL GATE OF MY 2003 FORD RANGER FAILED WITHOUT WARNING. THE TAILGATE DROPPED AND IT THE BUMPER. HAD I BEEN STANDING ON THE TAIL GATE OR HAD A LOAD PLACED ON IT I WOULD HAVE FALLEN TO THE GROUND OR THE LOAD WOULD HAVE DROPPED WHICH EITHER WOULD HAVE CAUSED INJURY. THE CABLES FAILED DUE TO CORRO…
Read full complaint
THE STEEL CABLES THAT SUPPORT THE TAIL GATE OF MY 2003 FORD RANGER FAILED WITHOUT WARNING. THE TAILGATE DROPPED AND IT THE BUMPER. HAD I BEEN STANDING ON THE TAIL GATE OR HAD A LOAD PLACED ON IT I WOULD HAVE FALLEN TO THE GROUND OR THE LOAD WOULD HAVE DROPPED WHICH EITHER WOULD HAVE CAUSED INJURY. THE CABLES FAILED DUE TO CORROSION. THEY ARE COVERED BY A PLASTIC SLEEVE WITH OPEN ENDS WHICH ALLOWS WATER TO ENTER THE CABLE ASSEMBLY AND BECOME TRAPPED CAUSING THE CABLE TO CORRODED PREMATURELY. *TR
NHTSA ODI #10232272
Mileage unknown · May 6, 2005
Electrical SystemLatches/locks/linkages
2003 FORD RANGER EXPERIENCING PROBLEMS WITH THE DOOR LOCKS.*MR DOOR LOCKED SPONTANEOUSLY, WAS INFORMED THAT FORD COULD NOT FIX THE PROBLEM. THE CONSUMER HAD TO PURCHASE A SPARE KEY TO KEEP OUTSIDE THE TRUCK. *BF *NM
NHTSA ODI #10120427
13,600 miles · Jul 26, 2004
Latches/locks/linkages
WHILE DRIVING 60 MPH, THE CONSUMER'S VEHICLE WAS BEING BY PASSED BY AN 18 WHEELER. THE AIR BLAST POPPED THE HOOD OPEN AND THE SAFETY CATCH KEPT THE HOOD FROM OPENING COMPLETELY. *AK *SC *JB
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting:brake Lights
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:tail Lights
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2003 Ford Ranger Problems, Complaints & Recalls | Skip That Year
Illustration