IllustrationSteel rim came apart while adding air to tire causing severe injuries to hands leg and foot only 20 psi in tire pressure when rim blew apart !
2002 Ford Ranger
Owner reports · Recalls · Investigations
More warning signs than most Ranger years
Owner complaints for the 2002 Ford Ranger are substantially higher than the model-year median of 144.
About this comparison →How this year compares
Owner complaints by model year
Compare all Ranger years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
510–25K
4925–50K
3750–75K
2875–100K
36100–150K
19150K+
220 reports with mileage · 126 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
43 crash reports12 fire reports25 injury reports
What owners actually said
346 reportsThe contact owns a 2002 Ford Ranger. The contact stated while driving approximately 40 MPH and attempting to switch lanes, the accelerator pedal was depressed but the vehicle failed to accelerate as needed. The contact received notification of NHTSA Campaign Number: 09V399000 (Vehicle Speed Control). The local dealer was not con…
Read full complaint
The contact owns a 2002 Ford Ranger. The contact stated while driving approximately 40 MPH and attempting to switch lanes, the accelerator pedal was depressed but the vehicle failed to accelerate as needed. The contact received notification of NHTSA Campaign Number: 09V399000 (Vehicle Speed Control). The local dealer was not contacted. The vehicle was taken to three separate independent mechanics to be diagnosed. After each diagnostic test, the contact was informed that the rear differential needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 180,000.
Extreme rusting of the entire frame and underside steel components. Attachments are rusting to the point of failure and falling off the vehicle.
The contact owns a 2002 Ford Ranger. The contact stated while driving 30 MPH, the air bag warning light was illuminated. Neither the dealer nor the independent mechanic was not made aware of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure and referred the contact to file a …
Read full complaint
The contact owns a 2002 Ford Ranger. The contact stated while driving 30 MPH, the air bag warning light was illuminated. Neither the dealer nor the independent mechanic was not made aware of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA. The failure mileage was approximately 50,000.
Rear shake bracket rusted off
TRUCK FAILED NH SAFETY INSPECTION 4/10/2021 DUE TO BADLY RUSTED FRAME.
2002 FORD RANGER. CONSUMER WRITES IN REGARDS TO FRAME ON RANGER VEHICLE. *LD *JS
WHILE PULLING UP TO A SECURITY GATE WHEN I APPLIED THE BRAKES THE VEHICLE ACCELERATED. AND I RAN INTO THE GATE. I COULD NOT STOP. DON'T KNOW WHY THIS HAPPENED
RECENTLY MY TRUCK UNINTENTIONALLY ACCELERATED AS I WAS BACKING UP IN DRIVEWAY CAUSING AN ACCIDENT. WHEN I PICKED UP TRUCK AFTER COLLISION REPAIR, IT SUDDENLY ACCELERATED ON HIGHWAY CAUSING IT TO FISH-TAIL OUR OF CONTROL AND NEARLY CAUSING ANOTHER ACCIDENT.
THE REAR STRAP THAT HOLDS THE FUEL TANK IS HANGING DOWN. ON CLOSER INSPECTION, THE MOUNT THAT IS CONNECTED/PART OF THE FRAME HAS COMPLETELY CORRODED AND IS NOW MISSING. I ONLY NOTICED THE PROBLEM WHEN THE "CHECK FUEL CAP" AND I STARTED TO TRY AND LOCATE THE PROBLEM.
Official recalls
309V399000 · Vehicle Speed Control
Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
07V336000 · Vehicle Speed Control
Aug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
02V035000 · Power Train:driveline:differential Unit
Feb 4, 2002
ON SOME MANUAL TRANSMISSION TRUCKS EQUIPPED WITH THE FX4 PACKAGE, THE REAR AXLE DIFFERENTIAL CASE COULD FRACTURE UNDER A HIGH TORQUE EVENT SUCH AS WHEN CUSTOMERS ACCELERATE RAPIDLY FROM A STOP OR WHEN A SPINNING TIRE SUDDENLY GAINS TRACTION.
Consequence & remedy
Consequence: DIFFERENTIAL FRACTURES COULD POTENTIALLY RESULT IN WHEEL LOCK-UP.
Remedy: DEALERS WILL REPLACE THE REAR AXLE ASSEMBLY. OWNER NOTIFICATION BEGAN MARCH 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.