I PURCHASE THIS TRUCK BRAND NEW FROM GENE EVANS FORD IN AUGUST 2003. I STARTED COMPLAINING TO THEM A WEEK LATER THAT THE TRUCK RIDES AS THOUGH MY BUTT IS HITTING THE PAVEMENT ON A TRIP I TOOK. EVERYONE IGNORED MY CONCERN IN THE SERVICE AND SALES DEPARTMENT. WHEN THE PROBLEM WAS FINALLY NOTICE. I WAS SOLD A BRAND NEW TRUCK WITH A…
Read full complaint
I PURCHASE THIS TRUCK BRAND NEW FROM GENE EVANS FORD IN AUGUST 2003. I STARTED COMPLAINING TO THEM A WEEK LATER THAT THE TRUCK RIDES AS THOUGH MY BUTT IS HITTING THE PAVEMENT ON A TRIP I TOOK. EVERYONE IGNORED MY CONCERN IN THE SERVICE AND SALES DEPARTMENT. WHEN THE PROBLEM WAS FINALLY NOTICE. I WAS SOLD A BRAND NEW TRUCK WITH A SEVERE BENT AXLE AND THEY WOULD NOT DO ANYTHING TO REPAIR THE TRUCK NOR GIVE ME ANOTHER ONE. THEY ALL PLAYED DUMB AND STUPID AS TO NEVER SEEING THE PROBLEM IN THE BEGINNING. FORD STILL OWES ME RESTITUTION. DEALERSHIP SHOULD NOT BE ABLE TO DEFRAUD THE PUBLIC ON DAMAGE VEHICLES PAYING A FORTUNE FOR JUST TO KILL YOU OR SOMEONE ELSE. GENE EVANS KNEW THERE WAS A PROBLEM FROM THE ONSET. THERE HAS BEEN A LOT OF PROBLEMS WITH THIS TRUCK IN THE PAST, PRESENT AND MOST LIKELY IN THE FUTURE CONSIDERING THE REPAIRS THAT HAS ALREADY BEEN PUT INTO THE TRUCK OUT OF MY POCKET. MY VEHICLE DOES EVERTHING IN ALL MOTION AND NO MOTION AT ALL. DANGEROUS THINGS HAPPENS INCLUDING, CUTTING OFF CONSTANTLY, LIGHTS ARE DIM ON THE OUTSIDE SO IT IS VERY HARD TO SEE AT NIGHT,RAIN COMING IN THE REAR WINDOW, TRUCK STARTED SMOKING, FILLED THE RESERVOIR AND OVER FLOWED SPEWING THE ANTIFREEZE ALL OVER THE ENGINE. IT SOUNDED LIKE FOOD WAS FRYING IN VERY HOT GREASE. THERE IS A STINKING ODOR, SMELLS LIKE VERY STRONG URINE . SICKENING FEELING COMES OVER ME AND ANYONE IN THE TRUCK.ABS AND CHECK ENGINE LIGHTS WILL NOT GO OFF. THE PASSENGER WINDOW IS MOVING SLOW AS THOUGH IT IS GOING TO STOP. TRUCKS JUMPS WHICH CAUSING ME TO BOUNCE UP AND DOWN WHILE IDLING OR AT A STOP.
NHTSA ODI #10954120
85,000 miles · Jun 19, 2014
Exterior Lighting
THE FRONT TURN SIGNAL DO NOT WORK ALL THE TIME. *TR
NHTSA ODI #10604555
185,000 miles · Feb 14, 2014
Electrical SystemExterior LightingFire
TL* THE CONTACT OWNS A 2003 FORD RANGER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THE HEADLIGHTS AND THE INSTRUMENT PANEL LIGHTS SUDDENLY BEGAN TO FLICKER FOLLOWED BY THE VEHICLE STALLING. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. THE CONTACT EXITED THE VEHICLE AND RETURNED THE NEXT DAY TO DISCOVER THE VE…
Read full complaint
TL* THE CONTACT OWNS A 2003 FORD RANGER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THE HEADLIGHTS AND THE INSTRUMENT PANEL LIGHTS SUDDENLY BEGAN TO FLICKER FOLLOWED BY THE VEHICLE STALLING. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. THE CONTACT EXITED THE VEHICLE AND RETURNED THE NEXT DAY TO DISCOVER THE VEHICLE HAD CAUGHT ON FIRE AND WAS COMPLETELY DESTROYED. THE VEHICLE WAS TOWED TO A WRECKING YARD AND WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FIRE. THE FAILURE MILEAGE WAS 185,000. *TR
NHTSA ODI #10564349
Mileage unknown · Feb 3, 2006
Exterior Lighting
FOG LAMP LENSES ON 2003 FORD RANGER PICK-UP TRUCK KEEP CRACKING. DEALER CLAIMS ROADSIDE DEBRIS IS THE CAUSE. HOWEVER, BOTH LENSES HAVE CRACKED TWICE AT THE SAME TIME. COMPLAINTS HAVE BEEN MADE TWICE TO FORD MOTOR CO. WHICH HAS NO RECALL RECORD FOR THIS TYPE OF INCIDENT. *NM
NHTSA ODI #10149370
Mileage unknown · Oct 30, 2003
Exterior Lighting
I WAS BLINDED BY ONCOMING HEAD LIGHTS NOT SET TO HIGH BEAM AND DISTRACTION FROM VERY BRIGHT HEAD LIGHTS IN REAR VIEW MIRROR (ALSO NOT ON HIGH BEAM). THE SOURCE IS FORD RANGER PICKUPS BUILT IN THE LAST 5 YEARS. OTHER MAKES OF TRUCKS AND SUV'S CAN BE BAD, BUT THE RANGER IS THE WORST OF THE BUNCH. *LA
NHTSA ODI #10045116
Mileage unknown · Jul 30, 2003
Exterior Lighting
VEHICLE'S BRAKE LIGHTS ALSO FUNCTION AS THE TURN SIGNALS INDICATORS. CONSUMER FEELS THIS DESIGN IS VERY UNSAFE BECAUSE IF YOUR ARE BRAKING AND SIGNALING FOR A TURN, YOU LOSE 1/2 OF BRAKING "VISIBILITY" TO ALERT OTHER TRAVELING VEHICLES. THIS DESIGN DEFECT INCREASED THE RISK OF REAR-END COLLISIONS.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting:brake Lights
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:tail Lights
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2003 Ford Ranger Problems, Complaints & Recalls | Skip That Year
Illustration