IllustrationWHILE DRIVING THE ENGINE FAILED. *NM THE DEALER INFORMED THE CONSUMER THAT NOTHING COULD BE DONE. FORD HAD ISSUED A RECALL ON THE 3.0 ENGINE, BUT THE CONSUMER SUGGESTED THAT MAYBE THIS PROBLEM PERTAINED TO THE 4.0 ENGINE AS WELL. *SC *JB
2003 Ford Ranger
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2003 Ford Ranger do not stand out strongly from the model-year median of 144.
About this comparison →How this year compares
Owner complaints by model year
Compare all Ranger years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
630–25K
2225–50K
3050–75K
2075–100K
35100–150K
15150K+
185 reports with mileage · 58 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
37 crash reports11 fire reports20 injury reports
Engine And Engine Cooling complaints
18 reportsWHEN VEHICLE IDLED, ENGINE SLOWED DOWN TO BELOW 500 RPM, AND THEN CHARGED BACK UP TO 3000 RPM. DEALER SAID THIS WAS A CHARACTERISTIC OF THIS VEHICLE. *AK FORD ISSUED TECHNICAL SERVICE BULLETIN REGARDING ENGINE IDLING. *LA
WHEN PLACING VEHICLE IN REVERSE, MOTOR RACED WITH FOOT ON THE BRAKES. IT WAS LATER DETERMINED BY DEALERSHIP THAT IT WAS A COMPUTER PROBLEM AND WAS REPROGRAMMED. *LA THIS REMEDIED THE PROBLEM TEMPORALLY. FAILURE HAS OCCURRED NUMEROUS TIMES SINCE THE PART REPLACEMENT. CONSUMER FELT IF FORD COULDN'T REPAIR THE VEHICLE WITHOUT…
Read full complaint
WHEN PLACING VEHICLE IN REVERSE, MOTOR RACED WITH FOOT ON THE BRAKES. IT WAS LATER DETERMINED BY DEALERSHIP THAT IT WAS A COMPUTER PROBLEM AND WAS REPROGRAMMED. *LA THIS REMEDIED THE PROBLEM TEMPORALLY. FAILURE HAS OCCURRED NUMEROUS TIMES SINCE THE PART REPLACEMENT. CONSUMER FELT IF FORD COULDN'T REPAIR THE VEHICLE WITHOUT IT FAILING AGAIN, THEN HIS MONEY SHOULD BE RETURNED. *PH
VEHICLE IDLES BELOW 500 RPMS. THE ENGINE SOUNDS ROUGH, AND ACTS LIKE IT IS GOING TO STALL. THEN, IT RETURNS TO NORMAL. *AK
VEHICLE HAS DIED ON INTERSTATE FOUR TIMES AND HAD TO BE TOWED IN. FORD CUSTOMER SERVICE AT 1-800-392-FORD STATES THAT THEY DON'T WANT TO REPLACE THE VEHICLE. I AM TOLD I SHOULD CONTINUE TO GET IT REPAIRED UNDER WARRANTY. MY CONCERN IS FOR THE SAFETY OF MY FAMILY WHEN WE ARE WAITING HOURS IN A SNOWSTORM FOR THE TOW TRUCK TO ARRIV…
Read full complaint
VEHICLE HAS DIED ON INTERSTATE FOUR TIMES AND HAD TO BE TOWED IN. FORD CUSTOMER SERVICE AT 1-800-392-FORD STATES THAT THEY DON'T WANT TO REPLACE THE VEHICLE. I AM TOLD I SHOULD CONTINUE TO GET IT REPAIRED UNDER WARRANTY. MY CONCERN IS FOR THE SAFETY OF MY FAMILY WHEN WE ARE WAITING HOURS IN A SNOWSTORM FOR THE TOW TRUCK TO ARRIVE. I HAVE OWNED 8 FORDS IN THE LAST FIVE YEARS. THAT IS ABOUT TO CHANGE BECAUSE FORD MOTOR STATES THAT THEY HAVE FOLLOWED THE LETTER OF THE LAW CONCERNING REPAIRS UNDER THE WARRANTY. WE HAVE NOW REPLACED ONE FORD WITH A LEXUS AND ARE TOTALLY AMAZED AT THE DIFFERENCE OF ATTITUDE TOWARDS THE CUSTOMER. AT OUR FIRST FREE LEXUS OIL CHANGE MY WIFE WAS GIVEN A DOZEN LONG STEM ROSES. WHAT DO YOU THINK SHE IS SAYING ABOUT FORD THESE DAYS? NOW I UNDERSTAND WHY PEOPLE ARE BUYING MORE FOREIGN CARS AND TRUCKS.
A BURNING ODOR SMELL WAS COMING IN THROUGH THE VENTS. THE DRIVER TOOK THE VEHICLE TO THE DEALER FOR ANALYSIS. THE MECHANIC COULD NOT DUPLICATE THE PROBLEM. *NLM
WHILE DRIVING VEHICLE INTERMITTENTLY STALLED. THE CAUSE OF THE PROBLEM HAD NOT BEEN DETERMINED. *AK
BRAKE AND ENGINE PROBLEMS. *MR THE ROTORS WERE TURNED ON THE FRONT BRAKES AND A IDLER WAS INSTALLED BECAUSE THE ENGINE STALLED OUT. (TWICE AFTER THAT THE VEHICLE WAS RETURNED THE VEHICLE FOR THE SAME PROBLEM) *SCC *JB
Official recalls
109V399000 · Vehicle Speed Control
Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE05066 · Brake Lights Inoperative
Opened Dec 5, 2005 · Closed Mar 24, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting:brake Lights
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:tail Lights
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.