IllustrationMOTOR MOUNTS: ALL THREE MOUNTS HAVE BEEN REPLACED. 6 TOTAL. ONE HAS BEEN REPLACED TWICE. ONE THREE TIMES. ELECTRIC DOOR LOCKS & WINDOW REGULATORS: FRONT DRIVER AND REAR RIGHT PASSENGER HAVE FAILED. DRIVER FLOOR MAT: SLIDES. *TR
2006 Ford Fusion
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2006 Ford Fusion do not stand out strongly from the model-year median of 1,109.
About this comparison →How this year compares
Owner complaints by model year
Compare all Fusion years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
340–25K
6825–50K
10650–75K
9275–100K
91100–150K
39150K+
430 reports with mileage · 300 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 319 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 150 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
38 crash reports4 fire reports23 injury reports
Visibility complaints
7 reportsWINDSHIELD CRACKED HORIZONTALLY ON A 20 F DAY (NO ICE OR WATER INVOLVED). CAR HAD WARMED UP FOR APPROX. 10 MINS. BEFORE DRIVING. DROVE HALF A SUBURBAN BLOCK, HEARD A POPPING SOUND AND NOTICED A CRACK THAT DEVELOPED ABOUT 4 INCHES ABOVE THE WINDSHIELD WIPERS AND IS ABOUT 24 INCHES LONG. *TR
I PURCHASED A 2006 FUSION ON 8-12-06 AFTER AN INITIAL TEST DRIVE. THE CAR APPEARED TO BE FREE FROM ANY COSMETIC DEFECTS. WHEN PICKING UP THE VEHICLE AFTER THE PAPERS WERE SIGNED. HOWEVER, THE MORE I DROVE THE CAR, THE MORE I NOTICED A DEFECT IN THE WINDSHIELD GLASS. I WAS NOT ABLE TO PUT MY FINGER ON THE PROBLEM UNTIL READING A …
Read full complaint
I PURCHASED A 2006 FUSION ON 8-12-06 AFTER AN INITIAL TEST DRIVE. THE CAR APPEARED TO BE FREE FROM ANY COSMETIC DEFECTS. WHEN PICKING UP THE VEHICLE AFTER THE PAPERS WERE SIGNED. HOWEVER, THE MORE I DROVE THE CAR, THE MORE I NOTICED A DEFECT IN THE WINDSHIELD GLASS. I WAS NOT ABLE TO PUT MY FINGER ON THE PROBLEM UNTIL READING A POST HERE FROM ANOTHER FUSION OWNER. IT IS MOST NOTICEABLE WHEN MAKING A TURN IN THE VEHICLE, AS THE DEFECT IS MOST PRONOUNCED WHEN LOOKING THROUGH THE GLASS AT AN ANGLE, SUCH AS LOOKING TO THE RIGHT THROUGH THE PASSENGER SIDE OF THE GLASS. I ALSO SAT IN THE PASSENGER SIDE OF THE VEHICLE AND LOOKED THROUGH THE GLASS AT AN ANGLE ON THE DRIVER'S SIDE AND CAN SEE THE DEFECT THERE AS WELL. IT DOES NOT SEEM TO BE A PROBLEM WHEN LOOKING STRAIGHT AHEAD THROUGH THE GLASS. THE DEFECT IS A SERIES OF 'LINES' VERTICALLY THROUGHOUT THE GLASS SO THAT THE GLASS LOOKS WARPED. I HAVE NOT CONTACTED THE DEALERSHIP ABOUT THIS YET BUT WILL BRING IT TO THEIR ATTENTION WHEN THE FIRST SERVICE IS DUE. *JB
LOW VISIBILITY OUT OF THE REAR WINDSHIELD CAN POSE A DANGER WHEN BACKING UP IN PARKING LOTS OR OUT OF DRIVEWAYS SINCE SOMETIMES THE ROAD CANNOT BE SEEN AND DISTANCE TO OTHER VEHICLES CANNOT BE ESTIMATED. NO BACKUP WARNING SYSTEM WAS AVAILABLE AS AN ADD-ON LIKE THE FORD EXPLORER AND OTHER FORD MODELS. THIS SHOULD BE A STANDARD …
Read full complaint
LOW VISIBILITY OUT OF THE REAR WINDSHIELD CAN POSE A DANGER WHEN BACKING UP IN PARKING LOTS OR OUT OF DRIVEWAYS SINCE SOMETIMES THE ROAD CANNOT BE SEEN AND DISTANCE TO OTHER VEHICLES CANNOT BE ESTIMATED. NO BACKUP WARNING SYSTEM WAS AVAILABLE AS AN ADD-ON LIKE THE FORD EXPLORER AND OTHER FORD MODELS. THIS SHOULD BE A STANDARD FEATURE IN ALL MODELS OF THE VEHICLE AS IT WOULD PROVIDE SAFETY IN BACKING OF THE VEHICLE IF NOT AT LEAST AN OPTION TO ADD TO THE PURCHASE. *JB
MY WINDSHIELD HAD SERIOUS DISTORTIONS THROUGHOUT THE ENTIRE GLASS. VARYING DEGRESS OF MAGNIFICATION CAUSED EYE STRAIN AND HEADACHES. IT WAS DANGEROUS DRIVING THE VEHICLE IN THIS CONDITION AND NOT A PLEASANT EXPERIENCE. MY DEALERSHIP REPLACED THE WINDSHIELD ONLY TO HAVE THE NEW ONE BE EVEN WORSE. THE NEW WINDSHIELD IS SO BAD …
Read full complaint
MY WINDSHIELD HAD SERIOUS DISTORTIONS THROUGHOUT THE ENTIRE GLASS. VARYING DEGRESS OF MAGNIFICATION CAUSED EYE STRAIN AND HEADACHES. IT WAS DANGEROUS DRIVING THE VEHICLE IN THIS CONDITION AND NOT A PLEASANT EXPERIENCE. MY DEALERSHIP REPLACED THE WINDSHIELD ONLY TO HAVE THE NEW ONE BE EVEN WORSE. THE NEW WINDSHIELD IS SO BAD IT'S AS THOUGH I'M LOOKING THROUGH A WET WINDSHIELD THAT HAS NOT BEEN WIPED. THE DEALERSHIP HAS ACKNOWLEDGED THE REPLACEMENT IS BAD AND THAT IT MIGHT BE INDICATIVE OF A LARGER PROBLEM. THEY PLAN ON CONTACTING FORD. I'VE HAD THE CAR FOR ONLY ONE WEEK AT THE TIME OF TYPING THIS. *NM
DT*: THE CONTACT STATED THE EXTERIOR MIRRORS ON THE VEHICLE DO NOT ALLOW VISION OF THE REAR END, NO MATTER HOW THE MIRRORS ARE POSITIONED. THE DEALERSHIP SUGGESTED MOTION SENSORS BE INSTALLED AND THE MANUFACTURER STATED THIS IS HOW THE VEHICLE WAS MANUFACTURED AND NO REPAIRS WERE AVAILABLE. UPDATED 03/09/06
DT*: THE CONTACT STATED THE EXTERIOR MIRROR ON THE VEHICLE DOES NOT ALLOW YOU TO SEE THE BACK OF THE VEHICLE. NO MATTER HOW THE MIRRORS ARE TURNED THE BACK OF THE VEHICLE CANNOT BE SEEN. THE DEALER AND THE MANUFACTURER HAVE BEEN ALERTED. UPDATED 3/9/2006 - *NM
Official recalls
421V158000 · Air Bags:frontal:driver Side:inflator Module
Mar 10, 2021
Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge. Owner notification letters were mailed on April 9, 2021 for the passenger side, and November 14, 2022 for the driver side. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S12.
19V904000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Dec 18, 2019
Ford Motor Company (Ford) is recalling certain 2006-2010 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ vehicles. The valves within the ABS Hydraulic Control Units (HCU) may react with brake fluids containing specific corrosion preventative additives. This reaction may cause the valves to not close properly.
Consequence & remedy
Consequence: If the valves do not properly close, additional brake pedal travel may be required to stop the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will flush the brake system with DOT 4 fluid and install a new brake fluid reservoir cap. In addition, the HCU will be tested to detect a possible stuck valve condition, replacing the HCU as necessary. All services will be performed free of charge. The recall began April 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S54.
17V024000 · Air Bags:frontal:passenger Side:inflator Module
Jan 10, 2017
Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain 2009 Ford Ranger, Edge, Fusion and Mustang, Lincoln MKX, MKZ and Zephyr and Mercury Milan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Ford is recalling certain 2007-2008 Ford Ranger, Edge and Lincoln MKX, 2006-2008 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ, 2005-2008 Ford Mustang and 2005-2006 Ford GT vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Interim letters informing owners of the recall and that parts are not yet available began mailing March 1, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
16V384000 · Air Bags:frontal:passenger Side:inflator Module
May 31, 2016
Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA12009 · Floor Mat Interference With Accelerator
Opened Dec 12, 2012 · Closed Jun 12, 2014
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal
On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated clockwise.Both the single- and double-clip (Figure 2) all-weather floor mats may interfere with the accelerator pedal return to idle when the mats are not secured by the retention clip(s).Testing showed that this can occur if the mats are moved forward from the clipped position approximately two inches into a position in which the rear edge of the mats will abut the retention clip(s) when installed singly and align with the clip(s) when stacked on another floor mat.The pedal interference incidents reviewed by the Office of Defects Investigation (ODI) include 1 crash and 9 incidents with allegations of brake friction materials smoking and/or requiring repair for heat related damage.The crash incident occurred after the parking brake was applied at speed, resulting in loss-of-control vehicle yaw event caused by lock-up of the rear tires.The spin-out resulted in a side impact collision with an oncoming vehicle in an opposing lane of traffic. For the 29 incidents with sufficient information available to make an assessment; 23 (79%) were controlled by the driver either shifting to neutral, turning the engine off, or both; 4 (14%) were ended by the driver either kicking the pedal free (2) or pulling the mat away from the pedal (2); and 2 (7%) were ended by the pedal freeing itself from the mat with no apparent driver action.None of the drivers who reacted to the incident by shifting to neutral or turning the engine off reported any difficulties with either action.The subject mats were sold by Ford and Lincoln dealers directly to customers as an optional accessory equipment item or, beginning in November 2007, the mats were also available as a factory installed accessory if ordered with a new vehicle.Ford estimates that approximately 82,579 affected driver's side all weather floor mats were sold worldwide; either over the counter through Ford dealerships or as original equipment.Owners that purchased the subject all-weather floor mats as a factory installed accessory with their new vehicle will be notified to return their all weather floor mats to their Ford or Lincoln Dealership in exchange for replacement mats.Owners of all other potentially affected vehicles will be notified that, if they have an affected Ford driver's side all weather floor mat, they should return their mats to the dealership in exchange for replacement mats.The VOQs associated with the closing of this investigation are: 10327597, 10332233, 10334211, 10335336, 10339330, 10348772 (and duplicate 10342572), 10372674, 10379562, 10415911, 10426255, 10434107, 10521053, 10554966.This investigation is hereby closed.
Additional source detail variants (2)
Vehicle Speed Control:accelerator Pedal
On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated clockwise.Both the single- and double-clip (Figure 2) all-weather floor mats may interfere with the accelerator pedal return to idle when the mats are not secured by the retention clip(s).Testing showed that this can occur if the mats are moved forward from the clipped position approximately two inches into a position in which the rear edge of the mats will abut the retention clip(s) when installed singly and align with the clip(s) when stacked on another floor mat.The pedal interference incidents reviewed by the Office of Defects Investigation (ODI) include 1 crash and 9 incidents with allegations of brake friction materials smoking and/or requiring repair for heat related damage.The crash incident occurred after the parking brake was applied at speed, resulting in loss-of-control vehicle yaw event caused by lock-up of the rear tires.The spin-out resulted in a side impact collision with an oncoming vehicle in an opposing lane of traffic. For the 29 incidents with sufficient information available to make an assessment; 23 (79%) were controlled by the driver either shifting to neutral, turning the engine off, or both; 4 (14%) were ended by the driver either kicking the pedal free (2) or pulling the mat away from the pedal (2); and 2 (7%) were ended by the pedal freeing itself from the mat with no apparent driver action.None of the drivers who reacted to the incident by shifting to neutral or turning the engine off reported any difficulties with either action.The subject mats were sold by Ford and Lincoln dealers directly to customers as an optional accessory equipment item or, beginning in November 2007, the mats were also available as a factory installed accessory if ordered with a new vehicle.Ford estimates that approximately 82,579 affected driver's side all weather floor mats were sold worldwide; either over the counter through Ford dealerships or as original equipment.Owners that purchased the subject all-weather floor mats as a factory installed accessory with their new vehicle will be notified to return their all weather floor mats to their Ford or Lincoln Dealership in exchange for replacement mats.Owners of all other potentially affected vehicles will be notified that, if they have an affected Ford driver's side all weather floor mat, they should return their mats to the dealership in exchange for replacement mats.The VOQs associated with the closing of this investigation are: 10327597, 10332233, 10334211, 10335336, 10339330, 10348772 (and duplicate 10342572), 10372674, 10379562, 10415911, 10426255, 10434107, 10521053, 10554966.This investigation is hereby closed.
Vehicle Speed Control
On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated clockwise.Both the single- and double-clip (Figure 2) all-weather floor mats may interfere with the accelerator pedal return to idle when the mats are not secured by the retention clip(s).Testing showed that this can occur if the mats are moved forward from the clipped position approximately two inches into a position in which the rear edge of the mats will abut the retention clip(s) when installed singly and align with the clip(s) when stacked on another floor mat.The pedal interference incidents reviewed by the Office of Defects Investigation (ODI) include 1 crash and 9 incidents with allegations of brake friction materials smoking and/or requiring repair for heat related damage.The crash incident occurred after the parking brake was applied at speed, resulting in loss-of-control vehicle yaw event caused by lock-up of the rear tires.The spin-out resulted in a side impact collision with an oncoming vehicle in an opposing lane of traffic. For the 29 incidents with sufficient information available to make an assessment; 23 (79%) were controlled by the driver either shifting to neutral, turning the engine off, or both; 4 (14%) were ended by the driver either kicking the pedal free (2) or pulling the mat away from the pedal (2); and 2 (7%) were ended by the pedal freeing itself from the mat with no apparent driver action.None of the drivers who reacted to the incident by shifting to neutral or turning the engine off reported any difficulties with either action.The subject mats were sold by Ford and Lincoln dealers directly to customers as an optional accessory equipment item or, beginning in November 2007, the mats were also available as a factory installed accessory if ordered with a new vehicle.Ford estimates that approximately 82,579 affected driver's side all weather floor mats were sold worldwide; either over the counter through Ford dealerships or as original equipment.Owners that purchased the subject all-weather floor mats as a factory installed accessory with their new vehicle will be notified to return their all weather floor mats to their Ford or Lincoln Dealership in exchange for replacement mats.Owners of all other potentially affected vehicles will be notified that, if they have an affected Ford driver's side all weather floor mat, they should return their mats to the dealership in exchange for replacement mats.The VOQs associated with the closing of this investigation are: 10327597, 10332233, 10334211, 10335336, 10339330, 10348772 (and duplicate 10342572), 10372674, 10379562, 10415911, 10426255, 10434107, 10521053, 10554966.This investigation is hereby closed.