Air Bags. Review the 319 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 150 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

38 crash reports4 fire reports23 injury reports

Electrical System complaints

71 reports

Clear category filter

114,000 miles · Mar 31, 2017

Electrical System

TL* THE CONTACT OWNS A 2006 FORD FUSION. WHILE DRIVING 15 MPH, THE TURN SIGNALS BECAME INOPERABLE AND THE ENGINE STALLED. THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SMART JUNCTION BOX FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFAC…

Read full complaint

NHTSA ODI #10969765

100,000 miles · Nov 22, 2016

Electrical System

THE REAR TAIL LIGHT SOCKET AND BULB ARE CHARRED BLACK AS IF THEY CAUGHT FIRE. I FOUND THE ISSUE BECAUSE THE SIGNAL LIGHT FAILED. IT SMELLED BURNT. UNSURE IF THERE WAS ACTUAL FLAME OR NOT.

NHTSA ODI #10927571

98,000 miles · Oct 18, 2016

Electrical SystemExterior Lighting

Read full complaint

I WAS DRIVING HOME FROM WORK, WHEN BOTH OF MY FRONT TURN SIGNALS WENT OUT. MY DASH INDICATED TO CHECK LF TURN LAMP AND CHECK RF TURN LAMP. I STOPPED AT THE STORE TO PURCHASE NEW BULBS, THINKING THE BULBS WERE BAD. I GOT HOME, AND NOTICED THAT THE LEFT FRONT PARKING LAMP WAS ON. I SHUT THE CAR OFF, AND THE LIGHT REMAINED ON. I HAD TO DISCONNECT THE LIGHT, OTHERWISE IT WOULD HAVE DRAINED MY BATTERY. I HAD NO FRONT WORKING TURN SIGNALS AND NO WORKING HAZARDS IN THE FRONT. THE BACK SIGNALS AND HAZARDS WORK FINE, BUT BLINK FAST. *TR

NHTSA ODI #10917205

122,500 miles · Sep 28, 2016

Electrical SystemEngine

Read full complaint

DRIVING ON THE HIGHWAY AT 80 MPH THE CAR LOOSES ACCELERATION POWER AND AN ORANGE WRENCH SYMBOL SHOWS UP ON THE DASHBOARD. I HAVE TO SAFELY COAST MY VEHICLE TO A SAFE SPOT OFF THE ROAD. WHEN CAR COMES TO COMPLETE STOP IT IDLES REALLY ROUGH AND LOUD AND MAKES A LOUD NOISE WHEN PLACED INTO PARK. I HAVE TO SHUT CAR OFF THEN RESTART AND I'M ABLE TO CONTINUE DRIVING AS IF NOTHING EVER HAPPENED. THE PROBLEM KEEPS HAPPENING AND IS STARTING TO OCCUR MORE OFTEN BUT ALWAYS WHILE DRIVING ON THE HIGHWAY...PRAY TO GOD NOTHING SERIOUS EVER HAPPENS.

NHTSA ODI #10910410

159,639 miles · Aug 11, 2016

Electrical System

Read full complaint

DRIVING BOTH HIGHWAY AND CITY STREETS. WHILE DRIVING TO WORK MY TURN LEFT SIGNAL BEGAN TO FLASH FASTER INDICATING A BURNED OUT BULB WHEN THE RIGHT TURN SIGNAL STARTED FLASHING FASTER. AFTER WORK I COULD NOT UNLOCK MY CAR AND HAD TO HAVE SECURITY UNLOCK MY CAR ONLY TO FIND MY BATTERY WAS DEAD. SECURITY THEN JUMPED STARTED THE CAR, I DROVE OFF TO BATTLE MY THRU RUSH HOUR WITH OUT TURN SIGNALS. THE NEXT MORNING THE CAR BATTERY WAS DEAD AGAIN, AFTER GETTING IT STARTED I NOTICED THE RIGHT FRONT TURN SIGNAL BULB STAYED ON EVEN WHEN THE CAR WAS TURNED OFF,UNTIL BATTERY WAS DRAINED. I TOOK IT TO MY MECHANIC HE SAID THE SMART BOX WOULD NEED TO BE REPLACED AND PROGRAMED, AND COST ABOUT $850! I WENT TO PICKUP THE VEHICLE HAD TROUBLE UNLOCKING THE DOOR AGAIN THIS TIME THE BATTERY WAS DEAD AGAIN AND NEEDED TO BE REPLACED.

NHTSA ODI #10894998

121,759 miles · Feb 8, 2016

Electrical SystemEngine

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH, THE VEHICLE ACCELERATED AND DECELERATED INDEPENDENTLY AS THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ECM FAILED. THE VEHICLE WAS NOT REPAIRED…

Read full complaint

NHTSA ODI #10824786

88,000 miles · Nov 6, 2015

Electrical System

Read full complaint

WHILE DRIVING MY FUSION ON 11/1/15, BOTH FRONT TURN SIGNALS STOPPED WORKING WHEN ATTEMPTING TO MAKE A TURN ONTO AN INTERSTATE. THE DASH INDICATED A WARNING THAT THE LEFT AND RIGHT FRONT TURN SIGNAL LAMP WAS NOT WORKING WHEN THE SIGNAL WAS ACTIVATED BY THE SWITCH. I ASSUMED A BULB HAD BURNT OUT. HOWEVER, ONCE MY CAR WAS TURNED COMPLETELY OFF, THE LEFT FRONT BULB REMAINED ON, DESPITE NO ONE BEING IN THE CAR. THE LIGHT REMAINED ON FOR MULTIPLE HOURS BEFORE I BECAME AWARE OF IT ONCE I RETURNED TO MY VEHICLE. DURING THIS TIME, IT WAS DRAINING THE BATTERY. I THE. HAD TO DRIVE MY CAR ON CITY STREETS AND THE INTERSTATE TO GET HOME. I TRIED PURCHASING NEW BULBS, BUT FOUND THAT BOTH BULBS CURRENTLY IN THE CAR WORKED FINE. NO WIRING WAS LOOSE OR FRAYED. LATER THAT WEEK, I BROUGHT IT TO A MECHANIC WHO DIAGNOSED IT AS A FAILED SMART JUNCTION BOX THAT HAS LED TO THE TURN SIGNAL NOT WORKING. I CONTACTED MY LOCAL DEALERSHIP IN ACCORDANCE WITH MY MECHANIC'S SUGGESTION. I WAS INFORMED THERE IS NO RECALL ON THIS PART. HOW IS THERE NO RECALL WHEN THIS IS CLEARLY A SAFETY ISSUE? MALFUNCTIONING TURN SIGNALS WHILE DRIVING WITH NO DIRECT CAUSE IS A PROBLEM. ESPECIALLY WHEN IT LEADS TO A LIGHT REMAINING ON LEADING TO KILLING THE CAR BATTERY. ACCORDING TO THE DEALERSHIP, THE ONLY SOLUTION IS PURCHASING A NEW JUNCTION BOX FROM THEM (NO LOCAL PARTS STORES CAN EVEN FIND ONE IN THEIR INVENTORY) AND HAVE IT INSTALLED AND PROGRAMMED BY THEM.

NHTSA ODI #10788959

101,000 miles · Oct 27, 2015

Electrical SystemFire

Read full complaint

TL* THE CONTACT OWNS A 2006 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING AT 5 MPH, THE VEHICLE SUDDENLY STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER. THE DEALER STATED A REMOTE STARTER THAT WAS PREVIOUSLY INSTALLED BURNED A FUSE. THE FUSE WAS REPLACED, BUT THE TURN SIGNALS FAILED. THE DEALER STATED THAT THE SMART BOX NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 101,000. THE VIN WAS NOT AVAILABLE.

NHTSA ODI #10786432

108,718 miles · Oct 8, 2015

Electrical System

CAR WOULD CUT OFF AT ANY TIME, AND CUT OFF SEVERAL TIMES WHILE IN MOTION.. HAD TO BE TOWED TWICE AND FINALLY ON 10/1/14 TOOK IT TO A FORD DEALERSHIP AND THEY REPAIRED IT AT A COST TO ME OF $1,462.98. SINCE THE FOCUS HAS A RECALL I WONDER IF THIS SHOULD ALSO HAVE A RECALL.

NHTSA ODI #10780883

47,000 miles · May 2, 2015

Electrical System

AFTER PARKING MY CAR OUTSIDE MY HOUSE, I OPENED MY DOOR AND THE HANDLE SHORT CIRCUITED AND EXPLODED BLOWING OUT A PIECE OF THE DOOR HANDLE OFF EXPOSING THE THE HANDLES SPRINGS AND WIRING. *TR

NHTSA ODI #10714191

Official recalls

21V158000 · Air Bags:frontal:driver Side:inflator Module

Mar 10, 2021

Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge. Owner notification letters were mailed on April 9, 2021 for the passenger side, and November 14, 2022 for the driver side. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S12.

19V904000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Dec 18, 2019

Ford Motor Company (Ford) is recalling certain 2006-2010 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ vehicles. The valves within the ABS Hydraulic Control Units (HCU) may react with brake fluids containing specific corrosion preventative additives. This reaction may cause the valves to not close properly.

Consequence & remedy

Consequence: If the valves do not properly close, additional brake pedal travel may be required to stop the vehicle, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will flush the brake system with DOT 4 fluid and install a new brake fluid reservoir cap. In addition, the HCU will be tested to detect a possible stuck valve condition, replacing the HCU as necessary. All services will be performed free of charge. The recall began April 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S54.

17V024000 · Air Bags:frontal:passenger Side:inflator Module

Jan 10, 2017

Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain 2009 Ford Ranger, Edge, Fusion and Mustang, Lincoln MKX, MKZ and Zephyr and Mercury Milan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Ford is recalling certain 2007-2008 Ford Ranger, Edge and Lincoln MKX, 2006-2008 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ, 2005-2008 Ford Mustang and 2005-2006 Ford GT vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Interim letters informing owners of the recall and that parts are not yet available began mailing March 1, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.

16V384000 · Air Bags:frontal:passenger Side:inflator Module

May 31, 2016

Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA12009 · Floor Mat Interference With Accelerator

Opened Dec 12, 2012 · Closed Jun 12, 2014

Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal

On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated clockwise.Both the single- and double-clip (Figure 2) all-weather floor mats may interfere with the accelerator pedal return to idle when the mats are not secured by the retention clip(s).Testing showed that this can occur if the mats are moved forward from the clipped position approximately two inches into a position in which the rear edge of the mats will abut the retention clip(s) when installed singly and align with the clip(s) when stacked on another floor mat.The pedal interference incidents reviewed by the Office of Defects Investigation (ODI) include 1 crash and 9 incidents with allegations of brake friction materials smoking and/or requiring repair for heat related damage.The crash incident occurred after the parking brake was applied at speed, resulting in loss-of-control vehicle yaw event caused by lock-up of the rear tires.The spin-out resulted in a side impact collision with an oncoming vehicle in an opposing lane of traffic. For the 29 incidents with sufficient information available to make an assessment; 23 (79%) were controlled by the driver either shifting to neutral, turning the engine off, or both; 4 (14%) were ended by the driver either kicking the pedal free (2) or pulling the mat away from the pedal (2); and 2 (7%) were ended by the pedal freeing itself from the mat with no apparent driver action.None of the drivers who reacted to the incident by shifting to neutral or turning the engine off reported any difficulties with either action.The subject mats were sold by Ford and Lincoln dealers directly to customers as an optional accessory equipment item or, beginning in November 2007, the mats were also available as a factory installed accessory if ordered with a new vehicle.Ford estimates that approximately 82,579 affected driver's side all weather floor mats were sold worldwide; either over the counter through Ford dealerships or as original equipment.Owners that purchased the subject all-weather floor mats as a factory installed accessory with their new vehicle will be notified to return their all weather floor mats to their Ford or Lincoln Dealership in exchange for replacement mats.Owners of all other potentially affected vehicles will be notified that, if they have an affected Ford driver's side all weather floor mat, they should return their mats to the dealership in exchange for replacement mats.The VOQs associated with the closing of this investigation are: 10327597, 10332233, 10334211, 10335336, 10339330, 10348772 (and duplicate 10342572), 10372674, 10379562, 10415911, 10426255, 10434107, 10521053, 10554966.This investigation is hereby closed.

Additional source detail variants (2)

Vehicle Speed Control:accelerator Pedal

Vehicle Speed Control