NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
43 reports10,800 miles · Sep 2, 2016
SteeringSuspension
TRUCK GOES INTO A DEATH WOBBLE WHEN DRIVING 60MPH OR FASTER. USUALLY HAPPENS WHEN YOU GO OVER A BRIDGE, CATTLE GUARD OR BUMP IN THE ROAD. CAUSE THE CEHICLE TO SHAKE UNCONTROLLABLY AND YOU HAVE TO COME TO ALMOST A COMPLETE STOP. I HAVE HAD FORD WORK ON IT AND NOTHING HAS CURED THE PROBLEM. THIS ISSUE IS GOING TO CAUSE SERIOUS …
Read full complaint
TRUCK GOES INTO A DEATH WOBBLE WHEN DRIVING 60MPH OR FASTER. USUALLY HAPPENS WHEN YOU GO OVER A BRIDGE, CATTLE GUARD OR BUMP IN THE ROAD. CAUSE THE CEHICLE TO SHAKE UNCONTROLLABLY AND YOU HAVE TO COME TO ALMOST A COMPLETE STOP. I HAVE HAD FORD WORK ON IT AND NOTHING HAS CURED THE PROBLEM. THIS ISSUE IS GOING TO CAUSE SERIOUS ACCIDENTS IF NOT TAKEN SERIOUSLY.
NHTSA ODI #10903402
210,000 miles · Jul 22, 2016
Fuel/propulsion System
TL* THE CONTACT OWNS A 2011 FORD F-350 SD. WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE CHECK VALVE IN THE FUEL TANK FRACTURED, WHICH CAUSE A BLOCKAGE IN THE FUEL SYSTEM. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WA…
Read full complaint
TL* THE CONTACT OWNS A 2011 FORD F-350 SD. WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE CHECK VALVE IN THE FUEL TANK FRACTURED, WHICH CAUSE A BLOCKAGE IN THE FUEL SYSTEM. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 210,000.
NHTSA ODI #10887758
59,800 miles · Apr 11, 2016
Engine
TL* THE CONTACT OWNS A 2011 FORD F-350 SD. WHILE DRIVING 55 MPH, THE VEHICLE LOST POWER AND STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHO WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT WAS AWARE OF NH…
Read full complaint
TL* THE CONTACT OWNS A 2011 FORD F-350 SD. WHILE DRIVING 55 MPH, THE VEHICLE LOST POWER AND STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHO WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 13V535000 (ENGINE), BUT THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 59,800.
NHTSA ODI #10854821
17,815 miles · Oct 10, 2015
Tires
DRIVING ON INTERSTATE HIGHWAY AT NIGHT. NOTED VIBRATION AS WHEN TIRES ARE NOT BALANCED. EXITED INTERSTATE AT FIRST EXIT AND CHECKED ALL TIRES. TIRE PRESSURES GOOD AND EQUAL. NO KNOTS OR DAMAGE NOTED AND ALL TIRES SAME TEMPERATURE. THOUGHT A BALANCE WEIGHT HAD COME OFF AND TIRES NEEDED TO BE REBALANCED. BEGAN DRIVING ON INTERSTAT…
Read full complaint
DRIVING ON INTERSTATE HIGHWAY AT NIGHT. NOTED VIBRATION AS WHEN TIRES ARE NOT BALANCED. EXITED INTERSTATE AT FIRST EXIT AND CHECKED ALL TIRES. TIRE PRESSURES GOOD AND EQUAL. NO KNOTS OR DAMAGE NOTED AND ALL TIRES SAME TEMPERATURE. THOUGHT A BALANCE WEIGHT HAD COME OFF AND TIRES NEEDED TO BE REBALANCED. BEGAN DRIVING ON INTERSTATE WITH NO CHANGE IN VIBRATION. ABOUT 15 MINUTES LATER THERE WAS AN EXPLOSION AND THE TRUCK VIOLENTLY VEERED TO THE RIGHT. PULLED BACK INTO MY LANE AND THEN PULLED OVER TO RIGHT SHOULDER. RIGHT FRONT TIRE DESTROYED. CALLED AAA AND HIGHWAY PATROL. DESCRIBED INCIDENT TO TROOPER AND HE LOOKED AT THE TIRE AND SAID THE BELTS SEPARATED. SIGNIFICANT DAMAGE TO VEHICLE - BENT RIGHT FRONT BUMPER FORWARD, BLEW A 7 FOOT FACTORY RUNNING BOARD OFF OF THE VEHICLE AND DESTROYED THE RIGHT FRONT QUARTER PANEL. RIGHT FRONT TIRE CHANGED AND STAYED OVERNIGHT AT MOTEL. OBTAINED NEW TIRE REPLACEMENT NEXT MORNING. I BOUGHT THIS TRUCK TO PULL A TRAILER BUT HAVE NOT BOUGHT A TRAILER YET. LUCKILY I WAS NOT PULLING A TRAILER AND THERE WAS NOT A VEHICLE NEXT TO ME IN THE RIGHT LANE WHEN THE EXPLOSION OCCURRED. THERE WERE NO VEHICLES NEARBY OR THEY MAY HAVE HAD SOME MAJOR DEBRIS FLYING THEIR WAY. THE TIRE IS A CAPITOL H/T TIRE NOT CAPITOL PRECISION TRAC II (BUT FORM WOULD NOT ALLOW ME TO ADD THIS TIRE TO COMPLAINT)
NHTSA ODI #10781274
28,700 miles · Jun 20, 2015
Unknown Or Other
DRIVERS SIDE REAR (SIDE WINDOW) EXPLODED ON I95. 65 MPH. NO OTHER VEHICLES NEARBY, NO ROAD DEBRIS. WINDOW WAS IN A MILLION SMALL PIECES HELD TOGETHER BY WINDOW TINT. NO IMPACT POINT, NOT HOLE, NO SIGN OF ANYTHING HITTING (WHICH WOULD BE NEXT TO IMPOSSIBLE FROM THE SIDE WITH NO TRAFFIC AROUND). IT WAS AN EXTREMELY LOUD BANG LIK…
Read full complaint
DRIVERS SIDE REAR (SIDE WINDOW) EXPLODED ON I95. 65 MPH. NO OTHER VEHICLES NEARBY, NO ROAD DEBRIS. WINDOW WAS IN A MILLION SMALL PIECES HELD TOGETHER BY WINDOW TINT. NO IMPACT POINT, NOT HOLE, NO SIGN OF ANYTHING HITTING (WHICH WOULD BE NEXT TO IMPOSSIBLE FROM THE SIDE WITH NO TRAFFIC AROUND). IT WAS AN EXTREMELY LOUD BANG LIKE A GUN SHOT WHEN IT OCCURRED. 2011 FORD F350. GOOGLING ONLINE INDICATES THIS IS NOT A RARE EVENT.
NHTSA ODI #10726382
108,964 miles · Jun 7, 2015
Steering
I LOST STEERING IN THE TRUCK. THE STEERING WHEEL TURNED LEFT TO RIGHT AND VISE VERSA WITH A LOT OF PLAY. IT HAPPENS RANDOMLY. THE FRONT END WILL SHAKES BECAUSE OF NO STEERING MAKING THE TRUCK UNCONTROLLABLE. IT IS VERY RANDOM WHEN IT HAPPENS AND HAS HAPPENED AT INTERSTATE SPEED. THE DEALER SAYS THERE IS NOTHING WRONG AND HAVE RE…
Read full complaint
I LOST STEERING IN THE TRUCK. THE STEERING WHEEL TURNED LEFT TO RIGHT AND VISE VERSA WITH A LOT OF PLAY. IT HAPPENS RANDOMLY. THE FRONT END WILL SHAKES BECAUSE OF NO STEERING MAKING THE TRUCK UNCONTROLLABLE. IT IS VERY RANDOM WHEN IT HAPPENS AND HAS HAPPENED AT INTERSTATE SPEED. THE DEALER SAYS THERE IS NOTHING WRONG AND HAVE REPLACED TIE ROD ENDS ALONG WITH BRAKES.
NHTSA ODI #10723796
77,000 miles · Jun 3, 2015
EngineUnknown Or Other
UPON STARTING THE VEHICLE, I NOTICED THAT THE CHECK ENGINE LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT HAS BEEN DIAGNOSED WITH A BAD DEF PUMP, HEATER AND SENSOR. THESE ARE FOR EMISSION CONTROL AND I HAVE BEEN TOLD THAT THESE PARTS ARE NOT A WARRANTIED ITEM. SEEMS THAT THIS SHOULD BE COVERED AS IT FOR THE …
Read full complaint
UPON STARTING THE VEHICLE, I NOTICED THAT THE CHECK ENGINE LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT HAS BEEN DIAGNOSED WITH A BAD DEF PUMP, HEATER AND SENSOR. THESE ARE FOR EMISSION CONTROL AND I HAVE BEEN TOLD THAT THESE PARTS ARE NOT A WARRANTIED ITEM. SEEMS THAT THIS SHOULD BE COVERED AS IT FOR THE SAFETY OF THE ENVIRONMENT.
NHTSA ODI #10723241
40,000 miles · Jun 2, 2015
Tires
CATASTROPHIC TREAD SEPARATION (TIRE DID NOT DEFLATE) OF LEFT REAR TIRE ON PICKUP. NEARLY LOST CONTROL, BUT MAINTAINED CONTROL AND GOT TO SIDE OF ROAD. ESTIMATED $8,500 DAMAGES TO TRUCK. NO INJURIES AND NO OTHER VEHICLES INVOLVED. NO ROAD HAZARD HIT. TIRES ROTATED AS REQUIRED. IN FOR DEALER SERVICE THAT MORNING AND CORRECT INFLAT…
Read full complaint
CATASTROPHIC TREAD SEPARATION (TIRE DID NOT DEFLATE) OF LEFT REAR TIRE ON PICKUP. NEARLY LOST CONTROL, BUT MAINTAINED CONTROL AND GOT TO SIDE OF ROAD. ESTIMATED $8,500 DAMAGES TO TRUCK. NO INJURIES AND NO OTHER VEHICLES INVOLVED. NO ROAD HAZARD HIT. TIRES ROTATED AS REQUIRED. IN FOR DEALER SERVICE THAT MORNING AND CORRECT INFLATION VERIFIED.
NHTSA ODI #10722876
170,000 miles · May 22, 2015
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2011 FORD F-350 SUPER DUTY. WHILE DRIVING 60 MPH, THE ENGINE SHUT OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED SINCE THE GLOW PLUGS FRACTURED WITHIN THE ENGINE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS …
Read full complaint
TL* THE CONTACT OWNS A 2011 FORD F-350 SUPER DUTY. WHILE DRIVING 60 MPH, THE ENGINE SHUT OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED SINCE THE GLOW PLUGS FRACTURED WITHIN THE ENGINE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000. UPDATED 8/27/15*CN
NHTSA ODI #10720972
69,123 miles · Apr 13, 2015
Engine
MAR.2,2015 WAS TRAVELING WEST ON HWY. 82 ABOUT 10 MILES OUT OF PRATTVILLE,AL. THIS IS A HEAVILY TRAVELED HWY. BY TRUCK AND AUTO. I WAS GIVEN THE MESSAGE STOP SAFELY NOW AND 30 SEC. LATER LOST POWER ON A MAJOR HIGHWAY GOING UP HILL. TRUCK WAS TOWED TO FORD DEALER WHERE I WAS TOLD THE TRUCK HAD A RECALL, 14E03. I WAS TOLD EGT SENS…
Read full complaint
MAR.2,2015 WAS TRAVELING WEST ON HWY. 82 ABOUT 10 MILES OUT OF PRATTVILLE,AL. THIS IS A HEAVILY TRAVELED HWY. BY TRUCK AND AUTO. I WAS GIVEN THE MESSAGE STOP SAFELY NOW AND 30 SEC. LATER LOST POWER ON A MAJOR HIGHWAY GOING UP HILL. TRUCK WAS TOWED TO FORD DEALER WHERE I WAS TOLD THE TRUCK HAD A RECALL, 14E03. I WAS TOLD EGT SENSOR #2 WAS REPLACED AND THE 14E03 RECALL WAS DONE BUT THE TWO WERE NOT CONNECTED. I LEANED THIS PROBLEM WAS ADDRESSED IN A NOV.2013 RECALL FOR AMBULANCES BUT THIS WAS NOT ADDRESSED FOR THE HUNDREDS OF THOUSANDS OF PRIVATELY OWNED TRUCKS. WHY? I LEANED OF THE JAN.2015 RECALL 14E03 WHEN MY TRUCK WAS TOWED IN TO DEALER. THIS IS NOT ONLY A COSTLY BUT ALSO DANGEROUS GAME FORD IS PLAYING WITH IT'S CUSTOMERS. I WAS BLESSED! *TR
NHTSA ODI #10705436
Official recalls
7Mar 25, 2015
Ford Motor Company (Ford) is recalling certain model year 2011-2015 Ford F-350, F-450, and F-550 trucks manufactured February 22, 2010, to January 30, 2015, and equipped with ambulance or fire engine preparation packages. The affected vehicles may detect an incorrect Exhaust Gas Temperature Sensor (EGT) fault indicating that the vehicle is too hot, causing the engine management system to shut down the engine and prevent its immediate restart.
Consequence & remedy
Consequence: Engine shut down and a subsequent cool down period may delay medical treatment or assistance to those needing it, increasing their risk of injury.
Remedy: Ford will notify owners, and dealers will update the Powertrain Control Module (PCM) software, free of charge. The recall began on April 22, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S09.
Jun 23, 2014
Palfleet Truck Equipment Company, LLC (Palfleet) is recalling certain model year 2009-2013 Ford F-350, F-450, and F-550 super duty vehicles modified by Palfleet and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence & remedy
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Palfleet will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began on July 29, 2014. Owners may contact Palfleet customer service at 1- 502-376-2458.
Jun 13, 2014
Iowa Mold Tooling Co., Inc. will notify owners and dealers to inspect the Muncie PTO pressure switch to determine if it is from the range of defective switches and if required, remove the pressure switch assembly and put a plug in the port where the PTO switch had been installed. This switch was never being utilized. This will be done free of charge. The recall is expected to begin in mid-July 2014. Owners may contact Iowa Mold Tooling Co., Inc. at 1-800-247-5958.
Consequence & remedy
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Iowa Mold Tooling Co., Inc. will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began on July 28, 2014. Owners may contact Iowa Mold Tooling Co., Inc. at 1-800-247-5958.
Jun 12, 2014
Stahl is recalling certain model year 2009-2014 Ford F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty vehicles modified by Stahl and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence & remedy
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Stahl will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. Owners may contact Stahl customer service at 1-800-277-8245, or Muncie at 1-800-367-7867.
Jun 10, 2014
Utility Truck Equipment Company, LLC (Utility Truck) is recalling certain model year 2010-2013 UTLI41A, 2011 UTLN41, and 2012 UTLN46 aerial trucks manufactured December 2010 to September 2013 equipped with certain Muncie Power Products PTO Assemblies installed on 2010-2013 Ford F-350, F-450 and F-550 vehicles. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence & remedy
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Utility Truck will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began in June 2014. Owners may contact Utility Truck customer service at 1-254-857-8813.
Additional source detail variants (2)
Equipment
Utility Truck Equipment Company, LLC (Utility Truck) is recalling certain model year 2010-2013 UTLI41A, 2011 UTLN41, and 2012 UTLN46 aerial trucks manufactured December 2010 to September 2013 equipped with certain Muncie Power Products PTO Assemblies installed on 2010-2013 Ford F-350, F-450 and F-550 vehicles. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Utility Truck will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began in June 2014. Owners may contact Utility Truck customer service at 1-254-857-8813.
Engine And Engine Cooling:engine:gasoline
Utility Truck Equipment Company, LLC (Utility Truck) is recalling certain model year 2010-2013 UTLI41A, 2011 UTLN41, and 2012 UTLN46 aerial trucks manufactured December 2010 to September 2013 equipped with certain Muncie Power Products PTO Assemblies installed on 2010-2013 Ford F-350, F-450 and F-550 vehicles. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Utility Truck will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began in June 2014. Owners may contact Utility Truck customer service at 1-254-857-8813.
Jun 10, 2014
Somerset Welding & Steel, doing business as J&J Truck equipment (J&J), is recalling certain model year 2009-2013 Ford F-350, F-450, and F-550 Super Duty chassis with 6.8L gasoline engines modified by J&J to be equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence & remedy
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Somerset will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began August 2014. Owner's may contact Somerset customer service at 1-800-777-2671.
Additional source detail variants (2)
Equipment
Somerset Welding & Steel, doing business as J&J Truck equipment (J&J), is recalling certain model year 2009-2013 Ford F-350, F-450, and F-550 Super Duty chassis with 6.8L gasoline engines modified by J&J to be equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Somerset will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began August 2014. Owner's may contact Somerset customer service at 1-800-777-2671.
Engine And Engine Cooling:engine:gasoline
Somerset Welding & Steel, doing business as J&J Truck equipment (J&J), is recalling certain model year 2009-2013 Ford F-350, F-450, and F-550 Super Duty chassis with 6.8L gasoline engines modified by J&J to be equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Somerset will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began August 2014. Owner's may contact Somerset customer service at 1-800-777-2671.
Jun 4, 2014
Tactical Vehicle Outfitters (Tactical) is recalling certain model year 2010-2014 Ford F-350 and F-550 vehicles modified by Tactical and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence & remedy
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Tactical will notify owners, and dealers will install a new PTO pressure switch, free of charge. The recall began on August 1, 2014. Owners may contact Tactical customer service at 1-405-603-6700.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ14005 · Vehicle Commanded Engine Shutdown
Opened Jan 13, 2015 · Closed Mar 15, 2016
Status: closed (inferred from source dates) · Electrical System:software; Engine; Engine And Engine Cooling:engine:diesel; Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Additional source detail variants (5)
Electrical System:software
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine And Engine Cooling:engine:diesel
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine And Engine Cooling:exhaust System:emission Control
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine And Engine Cooling:exhaust System
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Illustration