2010 Ford F-150

The contact owns a 2010 Ford F-150. The contact stated that after parking and then returning to the vehicle, while attempting to restart the vehicle, the engine failed to turn over. The vehicle was towed to an independent mechanic to be diagnosed. The contact was informed that the power junction box needed to be replaced. The vehicle was not repaired and remained at the dealer. Neither the dealer nor the manufacturer had been made aware of the failure. The approximate failure mileage was 200,000.

The contact owns a 2010 Ford F-150. The contact stated while driving approximately 25 MPH, he slowed down and when he made a right turn, the vehicle stopped completely. There were no warning lights illuminated on the instrument panel. The contact was able to get the vehicle safely in the parking lot. The failure had occurred several times. The vehicle was taken to an independent mechanic to be diagnosed. There was no failure found. The manufacturer was notified of the failure. The approximate failure mileage was 65,320.

All electric devices and warnings having to do with the left rear passenger door have shorted out due to excessive wear from repeated opening and closing of the door. Inspection of the harness immediately adjacent to the door frame shows excessive wear and broken wires. Possible confusion to the driver from unsafe dash warnings and false warnings that a rear passenger be seated next to a door that is not properly closed. Dome lights may not extinguish during driving. Electrical fire hazard. Required fix is Ford replacement part #9L3Z-14631-CAA. Internet search has shown this problem to be wide spread among F-150 crew cab back doors.

SEATBELT CHIME/ ALARM IS DEFECTIVE. SEE ALL YOUTUBE VIDEOS SHOWING SO. SEATBELT LIGHT AND CHIME CONTINUOUSLY STAY ON AND CHIME ALARM CONTINUOUSLY RINGS EVEN WHILE SEATBELTS ARE ON & LOCKED IN POSITION. THIS IS VERY DISTRACTING AND A DANGEROUS SITUATION FOR DRIVERS ATTEMPTING TO MAKE IT GO OFF/ WORK CORRECTLY WHILE DRIVING. THIS SEATBELT CHIME IS DEFECTIVE IS BOTH WHEN DRIVING / IN MOTION AND STATIONARY. BODY/WINDSHIELD AREA STRUCTURAL DEFECT- THERE IS A HOLE/OPENING THAT ALLOWS RAIN/ WATER TO LEAK INTO INTERIOR OF TRUCK, LEAKING WATER INSIDE TRUCK INTERIOR FROM UPPER BUILD SEAM, THROUGH THE GRAB HANDLE LOCATED AT SIDE OF WINDSHIELD IN FRONT OF FRONT PASSENGER, THEN LIQUID DRIPS DOWN ONTO CARPETED FLOORBOARD. THIS BODY STRUCTURE DEFECTIVE OPENING/ HOLE IS LOCATED SOMEWHERE BETWEEN UPPER WINDSHIELD SEAM AND THE INTERIOR FRONT PASSENGER GRAB HANDLE AT WINDSHIELD FRAME. WATER DRIPS THROUGH THIS HANDLE. THIS WINDSHIELD LEAK DEFECT OCCURS WHEN THE TRUCK IS IN MOTION AND WHEN STATIONARY. ELECTRICAL/IGNITION SWITCH- TURNING ON TRACK WITH IGNITION KEY, IGNITION SWITCH DOES NOT ALWAYS PERFORM CORRECTLY. IT OFTEN DISALLOWS THE AC, THE WINDSHIELD WIPERS, AND BACKUP CAMERA TO WORK, WHILE EVERYTHING ELSE IS WORKING. BECAUSE EVERYTHING ELSE MAY BE WORKING, THE DRIVER MAY NOT NOTICE THAT THE IGNITION SWITCH HAS BEEN TURNED ON INCORRECTLY.THIS DEFECT, ESPECIALLY THE BACK UP CAMERA NOT WORKING, AND WINDSHIELD WIPERS, IS DANGEROUS. THE SWITCH SHOULD BE MADE TO CONSISTENTLY WORK AT ALL TIMES THE SAME WAY. THIS DEFECT IS NOTICED WHEN STATIONARY, BUT OFTEN WHEN IT'S TOO LATE AND IN MOTION.

I WAS TRAVELING WITH MY WIFE AND 3 CHILDREN IN MY 2010 FORD F150 PLATINUM. IT HAD SNOWED THE NIGHT BEFORE SO I HAD CLEANED THE WINDOWS AND TURNED ON THE DEFROSTER, INCLUDING THE REAR DEFROSTER. I WAS RUNNING THE TRUCK FOR ABOUT 15 MIN WHEN THE REAR WINDOW STARTED TO SMOKE AND A SMALL FIRE, BURNING OCCURRED BEFORE THE GLASS IN THE RUBBER SEAL (OUTSIDE). I THREW WATER ON IT WHILE MY WIFE AND KIDS (11, 9, AND 3) EVACUATED THE TRUCK. I WAS ABLE TO CONTAIN IT, BUT THE WINDOW CRACKED DURING THE BURN/FIRE DUE TO THE HEAT. MY WIFE WAS TAKING MY DAUGHTER OUT OF HER CAR SEAT AS THIS HAPPENED. WE TURNED THE TRUCK OFF AND CONTACTED THE LOCAL FORD DEALER WHO SAID THE SERVICE DEPARTMENT WAS CLOSED UNTIL MONDAY BUT TO BRING IT IN AS THERE WAS A RECALL AND THEY WERE AWARE OF SIMILAR ISSUES. I TOOK THE TRUCK IN TODAY MONDAY JANUARY 18TH AND THE SERVICE DEPARTMENT SAID THERE WAS NO RECALL OR ANYTHING THEY COULD DO. NOT ONE DID ANYONE ASK FOR THE WELFARE OF MY FAMILY NOR DID THEY PRETEND TO CARE ABOUT THE SITUATION OF ONE OF THEIR PARTS/VEHICLES CAUSING A FIRE AND POTENTIALLY INJURING OR WORSE CAUSING DEATH TO ONE OF THERE CUSTOMERS. I WAS INFORMED TO CONTACT CUSTOMER SERVICE WHO GAVE ME THE SAME RESPONSE. THAT MY VIN HAD NO RECALL LISTED AND THAT WOULD NOT COVER ANY REPAIRS. I DID SOME RESEARCH AND READ ON NUMEROUS FORD FORUMS ABOUT THIS ISSUE WITH 2009-2012 FORD TRUCKS. ALL WITH THE SAME EXACT BURN/FIRE LOCATION AND EXACT REAR WINDOW (FAR RIGHT) CRACKING. THIS IS CONCERNING THAT FORD IS CLEARLY AWARE OF THIS ISSUE BUT TAKES NO RESPONSIBILITY TO ATTEMPT TO CORRECT AND LOOK OUT FOR THE WELFARE OF ITS CUSTOMERS. I WOULD UNDERSTAND A MECHANICAL ISSUE AND A PART BREAKING DOWN BUT I SHOULD NOT FEAR THAT MY VEHICLE WILL CATCH ON FIRE AND CAUSE HARM TO MY FAMILY. THANKFULLY NOTHING WORSE HAPPENED TO MY FAMILY AND I BUT IT SHOULD NOT TAKE THE WORST CASE SCENARIO FOR FORD TO ASSIST WITH THIS.

I WAS DRIVING MY TRUCK WHEN ALL OF A SUDDEN ALL OF MY DASH LIGHTS WENT ON AND MY HEADLIGHTS AND TAILLIGHTS SHUT OFF WHILE I WAS DRIVING IN THE DARK! IT WAS VERY DANGEROUS AS I WAS ON THE HIGHWAY AND MY TRUCK STARTED JUMPING AND SHIFTING WEIRD. THE TRACTION WAS MESSING UP. AFTER TAKING IT TO THE SHOP THEY TOLD ME IT WAS THE COMPUTER. I WAS IN A VERY DANGEROUS SITUATION BECAUSE OF A COMMON FAULT IN THIS YEAR MODEL. I WILL BE TAKING TO A LAWYER MONDAY. PLEASE GET BACK TO ME AS SOON AS POSSIBLE.

THE DAY I WENT TO PURCHASE THIS VEHICLE THE DEALERSHIP TOLD ME THEN THERE WAS AN ELECTRICAL PROBLEM THAT HAS CAUSED THE RADIO NOT TO WORK. THAT THEY WILL FIX IT NEXT DAY. I BASICALLY GOT THE RUN AROUND HAD THERE MECHANIC LOOK AT IT HE COULD NOT FIGURE OUT WHAT WAS WRONG. I INFORMED THEM THAT THERE IS MORE THEN JUST THE RADIO THE AIR BAG SYSTEM DOES NOT WORK OR SHOW THAT IT WORKS. ALSO POINTED OUT THAT CHUNKS OF METAL WAS FALLING FROM THE BOTTOM OF THIS EVERY TIME I SHUT THE DOOR. STILL NOTHING HAS BEEN DONE. THEY USED RUSTOLEUM BED LINER TO COVER EVERY INCH UNDER THE TRUCK. IT IS LITERALLY FALLING TO PIECES. 3 WEEKS GO BY AFTER SENDING NUMEROUS EMAILS ON UPDATE WHEN THIS WILL GET FIX AND THEY TELL ME THAT THEY WILL NOT FIX IT BECAUSE THE CO SIGNER LEFT A BAD REVIEW. I HAVE NO WORKING AIR BAGS. AND I'M PAYING 15 THOUSAND FOR THIS TRUCK.