NHTSA owner reports · September 18, 2026 snapshot.
Air Bags complaints
34 reportsClear category filterMileage unknown · Apr 13, 2021
Air BagsSuspension
THE REAR SUSPENSION STARTED WITH A LOWER NOISE IN THE REAR PASSENGER SIDE, WHENEVER I MAKE TURNS OR THE ROAD IS A LITTLE ROUGH. TO THIS DAY IS GETTING A LOT WORSE, MORE NOISE AND UNSTABLE WHEN I TAKE TURNS. ALSO THE SEAT BELT LIGHT COME ON, AND I WAS TOLD THAT THE MODULE IS MALFUNCTION AND NEED TO RESET OR REPLACE WITH A NEW ONE…
Read full complaint
THE REAR SUSPENSION STARTED WITH A LOWER NOISE IN THE REAR PASSENGER SIDE, WHENEVER I MAKE TURNS OR THE ROAD IS A LITTLE ROUGH. TO THIS DAY IS GETTING A LOT WORSE, MORE NOISE AND UNSTABLE WHEN I TAKE TURNS. ALSO THE SEAT BELT LIGHT COME ON, AND I WAS TOLD THAT THE MODULE IS MALFUNCTION AND NEED TO RESET OR REPLACE WITH A NEW ONE.
NHTSA ODI #11407826
56,573 miles · Dec 20, 2020
Air BagsElectrical System
CAR PULLED IN MY LANE MY CAR AUTO BREAKED, I ALSO PUT ON BREAK THEN ICON CAME ON ABOUT AIRBAG ISSUE. TOOK TO FORD RUN TEST. THE PIG TAIL THAT GOES TO AIRBAGS, NEED TO SAUTER 21 PINS THAT GOES TO CONNECTION OF PIGTAIL TO AIRBAG.
NHTSA ODI #11384294
46,500 miles · Oct 3, 2020
Air BagsElectrical SystemSeat Belts
THE SRS WARNING LIGHT ON THE DASH IS ILLUMINATED INDICATING THAT IN THE EVENT OF A COLLISION THE AIRBAGS WILL NOT DEPLOY. VEHICLE WAS TAKEN TO LOCAL FORD DEALER WHERE FAULT CODES INDICATE THAT TWO WIRE HARNESSES OR CONNECTORS NEED TO BE REPLACED. COST OF SERVICE WAS QUOTED AS $1600. HOWEVER, MILEAGE (46,500) AND AGE (4 YEARS)…
Read full complaint
THE SRS WARNING LIGHT ON THE DASH IS ILLUMINATED INDICATING THAT IN THE EVENT OF A COLLISION THE AIRBAGS WILL NOT DEPLOY. VEHICLE WAS TAKEN TO LOCAL FORD DEALER WHERE FAULT CODES INDICATE THAT TWO WIRE HARNESSES OR CONNECTORS NEED TO BE REPLACED. COST OF SERVICE WAS QUOTED AS $1600. HOWEVER, MILEAGE (46,500) AND AGE (4 YEARS) WOULD INDICATE THAT REPAIR SHOULD BE MADE UNDER 5 YR / 60,000 MI WARRANTY. FORD HAS DENIED WARRANTY. SERVICE DEPARTMENT AT LOCAL DEALERSHIP AND FORD CUSTOMER CARE HAVE BEEN CONTACTED BY PHONE AND EMAIL MULTIPLE TIMES WITHOUT RESOLUTION. THEY POINT TO THE WIRE HARNESS AS THE ROOT CAUSE OF THE SRS SYSTEM NOT WORKING AND CLAIM THAT THE WIRE HARNESS IS NOT COVERED BY WARRANTY.
NHTSA ODI #11362531
42,000 miles · Feb 13, 2020
Air Bags
TL* THE CONTACT OWNS A 2017 FORD EXPLORER. THE CONTACT STATED THAT UPON STARTING THE VEHICLE, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO SALERNO DUANE FORD 245 BROAD ST, SUMMIT, NJ 07901 WHERE THE CONTACT WAS INFORMED THAT THE AIR BAG WOULD NOT BE COVERED UNDER THE EXTENDED WARRANTY. THE MANUFACTURER WAS NOT…
Read full complaint
TL* THE CONTACT OWNS A 2017 FORD EXPLORER. THE CONTACT STATED THAT UPON STARTING THE VEHICLE, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO SALERNO DUANE FORD 245 BROAD ST, SUMMIT, NJ 07901 WHERE THE CONTACT WAS INFORMED THAT THE AIR BAG WOULD NOT BE COVERED UNDER THE EXTENDED WARRANTY. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 42,000.
NHTSA ODI #11309017
40,000 miles · Jan 14, 2020
Air Bags
WHEN STARTING I NOTICED THE FRONT AIRBAG LIGHT REMAINED ON INDICATING A MALFUNCTION FURTHER EXAMINATION INDICATED A PROBLEM WITH PASSENGER SRS NOT INDICATING PROPER ILLUMINATION UPON START UP AND THAT WAS THE REASON FOR THE ALWAYS ON FRONT AIRBAG WARNING UNLESS PASSENGER OCCUPYING SEAT IN OTHER WORDS IF THE INDICATOR TEST AT STA…
Read full complaint
WHEN STARTING I NOTICED THE FRONT AIRBAG LIGHT REMAINED ON INDICATING A MALFUNCTION FURTHER EXAMINATION INDICATED A PROBLEM WITH PASSENGER SRS NOT INDICATING PROPER ILLUMINATION UPON START UP AND THAT WAS THE REASON FOR THE ALWAYS ON FRONT AIRBAG WARNING UNLESS PASSENGER OCCUPYING SEAT IN OTHER WORDS IF THE INDICATOR TEST AT START UP FAILS THE SYSTEM TURNS ON THE FRONT AIRBAG LIGHT UNTIL SOMEONE IN SEAT/ IT ALSO MEANS IS A SUBSEQUENT FAILURE OF THE SYSTEM WILL NOT BE OBSERVED AS THE LIGHT HAS BEEN ALREADY TURNED ON FOR THE EARLIER REASON *LN INVALID VIN *JB*JB
NHTSA ODI #11299261
28,526 miles · Jun 28, 2019
Air BagsSteeringSuspension
VEHICLE HAS AN NHTSA RECALL NOTICE#:19V435 AND A FORD ISSUED RECALL#:19S17 WHICH INDICATES AS FOLLOWS: RECALL DESCRIPTION: REAR SUSPENSION TOE LINK REPLACEMENT. RISK TO SAFETY: A FRACTURE OF A REAR TOE LINK SIGNIFICANTLY DIMINISHES STEERING CONTROL, INCREASING THE RISK OF A CRASH! I HAVE CONTACTED 3 DIFFERENT DEALS IN MY AR…
Read full complaint
VEHICLE HAS AN NHTSA RECALL NOTICE#:19V435 AND A FORD ISSUED RECALL#:19S17 WHICH INDICATES AS FOLLOWS: RECALL DESCRIPTION: REAR SUSPENSION TOE LINK REPLACEMENT. RISK TO SAFETY: A FRACTURE OF A REAR TOE LINK SIGNIFICANTLY DIMINISHES STEERING CONTROL, INCREASING THE RISK OF A CRASH! I HAVE CONTACTED 3 DIFFERENT DEALS IN MY AREA (ECINO, CA, 91316) ALL SAID THAT THE REPLACEMENT PARTS ARE CURRENTLY UNAVAILABLE. IN ADDITION, ON THURSDAY, JUNE 27TH, 2019 I HAVE CONTACTED FORD MOTOR COMPANY TO SEE IF THE ISSUE CAN BE RESOLVED BUT I GOT THE SAME ANSWER. THEY SAID I HAVE TO WAIT UNTIL THE PARTS ARE AVAILABLE AND THEY ARE CURRENTLY BACK ORDERED WITH NO ESTIMATED TIME FOR THE ISSUE WITH THE VEHICLE CAN BE RESOLVED. THEY HAVE ASKED ME IF I WOULD LIKE FORD MOTOR COMPANY TO "LEMON" THE VEHICLE AND BUY IT BACK, I REPLIED: "ABSOLUTELY YES". THEY HAVE OPENED A CASE#: [XXX] I AM SERIOUSLY WORRIED FOR MY LIFE WHEN DRIVING THE FORD EXPLORER. I SUFFER FROM UNDERSTEERING WHENEVER I ATTEMPT A LEFT OR RIGHT TURN. AT SPEED OVER 40 MPH, THE VEHICLE WILL START SHAKING GIVING ME A SENSE OF ALMOST NO GRIP TO THE ROAD. IN ADDITION, I CONSTANTLY HAVE THE "FRONT AIRBAG" LIGHT ON (SEE PICTURE ATTACHED) THE DASHBOARD, BOTH WHEN VEHICLE IS IN MOTION & STATIONARY. THIS ISSUE HAPPENED BEFORE AND I TOOK THE CAR TO A FORD DEALER TO RESOLVE THE ISSUE (THE SERVICE TECH SAID THAT THE SENSOR WAS MALFUNCTIONED AND IN A CASE OF AN ACCIDENT, "FRONT AIRBAG" MIGHT NOT DEPLOY!!! THIS IS ABSOLUTELY ABSURD. I HERE BY CERTIFIE THAT MY VEHICLE IS SERVICED ON TIME (SEE PICTURE ATTACHED) AND CURRENTLY HAS 29,492 MILES ON IT (SEE PICTURE ATTACHED). I AM NOT SURE WHAT IS NHTSA PART IN ALL OF THIS, BUT IF YOU CAN HELP ME DEAL WITH FORD MOTOR COMPANY IN RESOLVING THESE ISSUES AND GET RID OF THIS VEHICLE, L WILL BE VERY PLEASED AND APPRECIATIVE. RESPECTFULLY, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT
NHTSA ODI #11223098
47,000 miles · Apr 7, 2019
Air BagsSeat Belts
THE SECOND ROW SEATBELT AIRBAGS CONTINUE TO SET OFF THE AIRBAG SENSOR ON THE CONTROL PANEL AND FORD TECHNICIANS CAN FIND NOTHING TO CORRECT. SENSOR SET OFF WHILE DRIVING AND PASSENGER BELTED INTO DRIVER SIDE SECOND ROW SEAT BELT THAT CONTAINS A SEATBELT AIRBAG.
NHTSA ODI #11194491
17,000 miles · Jul 9, 2018
Air BagsService BrakesUnknown Or OtherCrash
VEHICLE WAS TRAVELING APPROXIMATELY 40-50MPH ON THE HIGHWAY, TRAFFIC STOPPED ABRUPTLY, COLLISION WARNING SYSTEM WITH BRAKE SUPPORT DID NOT ACTIVATE, DRIVER ATTEMPTED TO MAKE A HARD STOP, BRAKES ENGAGED AT INITIAL PUSH OF THE PEDAL THEN BECAME UNRESPONSIVE REGARDLESS OF FORCE APPLIED TO THE PEDAL, VEHICLE REAR-END ANOTHER VEHICL…
Read full complaint
VEHICLE WAS TRAVELING APPROXIMATELY 40-50MPH ON THE HIGHWAY, TRAFFIC STOPPED ABRUPTLY, COLLISION WARNING SYSTEM WITH BRAKE SUPPORT DID NOT ACTIVATE, DRIVER ATTEMPTED TO MAKE A HARD STOP, BRAKES ENGAGED AT INITIAL PUSH OF THE PEDAL THEN BECAME UNRESPONSIVE REGARDLESS OF FORCE APPLIED TO THE PEDAL, VEHICLE REAR-END ANOTHER VEHICLE, AIR-BAGS DID NOT DEPLOY, SOS POST-CRASH ALERT SYSTEM DID NOT ACTIVATE, 911 ASSIST DID NOT ACTIVATE.
NHTSA ODI #11110171
Mileage unknown · Apr 11, 2018
Air BagsCrashInjury
I RENTED A 2017 FROM ENTERPRISE. I WAS IN A BAD CAR ACCIDENT ON A STREET DOING MAYBE 20MPH TOTAL LOSS FRONT DAMAGE AND THE AIRBAGS NEVER DEPLOYED I WENT INSIDE ANOTHER VEHICLE I NEVER SAW THE AIRBAG SHOWING ON WHILE DRIVING AND I HAD ON MY SEAT BELT. I NOW SUFFER WITH A SPINE PROBLEM CAUSE OF THIS ACCIDENT. I CANT BELIEVE AFTER…
Read full complaint
I RENTED A 2017 FROM ENTERPRISE. I WAS IN A BAD CAR ACCIDENT ON A STREET DOING MAYBE 20MPH TOTAL LOSS FRONT DAMAGE AND THE AIRBAGS NEVER DEPLOYED I WENT INSIDE ANOTHER VEHICLE I NEVER SAW THE AIRBAG SHOWING ON WHILE DRIVING AND I HAD ON MY SEAT BELT. I NOW SUFFER WITH A SPINE PROBLEM CAUSE OF THIS ACCIDENT. I CANT BELIEVE AFTER A HARD IMPACT THAT THE AIR BAGS NEVER DEPLOYED
NHTSA ODI #11084490
28,309 miles · Mar 28, 2018
Air Bags
PASSENGER SIDE AIR BAG DOES NOT STAY ON WHEN SOMEONE IS SITTING IN PASSENGER SEAT. GOES FROM ON TO OFF
NHTSA ODI #11081756
Official recalls
13Jul 14, 2026
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The roof rail covers may come loose and detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect the roof rail covers and as necessary, repair or replace the push-pins, rail clips, or roof rail covers, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 28, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S54. This recall expands previous NHTSA recall number 21V316. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
Feb 20, 2026
Ford Motor Company (Ford) is recalling certain 2017-2019 Explorer vehicles. The rear suspension toe links may fracture.
Consequence & remedy
Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the toe links, free of charge. Owner notification letters were mailed on March 16, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S08. This recall is an expansion of previous NHTSA recall number 21V537. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 25, 2026.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
May 23, 2025
Ford Motor Company (Ford) is recalling certain 2016-2017 Explorer vehicles. The driver and front passenger B-Pillar door trim may detach while driving.
Consequence & remedy
Consequence: Door trim that detaches while driving can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will repair the B-pillar trim, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 5, 2025. A second notice will be sent once the final remedy is available, anticipated November 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S53.
Jan 19, 2024
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
Consequence & remedy
Consequence: A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
Jul 15, 2021
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or ever registered, in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. Exposure to road salt can cause the cross-axis ball joint to corrode and seize, resulting in a fracture of the outboard section of the rear suspension toe link.
Consequence & remedy
Consequence: A rear toe-link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will inspect and replace as necessary, the cross-axis ball joint (CABJ) knuckle, and replace the rear suspension toe links, free of charge. This recall is an expansion of previous NHTSA recall numbers 16V-245, 19V-435, and 20V-675. Certain vehicles previously repaired will need to return for the new remedy. An interim notification letter notifying owners of the safety risk were mailed on September 10, 2021. Owner notification letters were mailed on March 16, 2022. Owners may contact Ford's customer service at 1-866-436-7332. Ford's number for this recall is 21S32.
May 5, 2021
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will install push-pins and replace any damaged rail clips and roof rail covers, as necessary, free of charge. The interim owner notification letter was mailed on June 22, 2021. Owner notification letters (remedy available) were mailed on October 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S22.
Mar 12, 2021
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin that were previously repaired under a prior recall numbers 16V-245 or 19V-435. The outboard section of a rear suspension toe link may fracture.
Consequence & remedy
Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the cross-axis ball joint (CABJ) knuckle attached to the rear suspension toe link and replace it as necessary, free of charge. The recall began November 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S62.
Sep 11, 2019
Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer vehicles equipped with power front seats. The seat frames may have sharp edges.
Consequence & remedy
Consequence: Occupants my contact the sharp edges when reaching between the power front seat and center console, increasing their risk of injury.
Remedy: Ford will notify owners, and dealers will install protective tape on the exposed inside edge and tab of the power seat frames, free of charge. The recall began November 8, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S29.
Jun 10, 2019
Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.
Consequence & remedy
Consequence: A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rear suspension toe links, and inspect both rear toe link ball joints, replacing the rear wheel knuckle(s), if necessary, free of charge. The recall began June 26, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S17.
Aug 28, 2017
Ford Motor Company (Ford) is recalling certain 2017 Explorer, Taurus and Police Interceptor Utility and Sedan vehicles. The steering gear heat shield fasteners may corrode, allowing the heat shield to detach.
Consequence & remedy
Consequence: If the heat shield detaches, the steering gear may overheat, increasing the steering effort required by the driver, especially at lower speeds, and increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers to inspect and replace the heat shield fasteners as needed, free of charge. The recall began on September 13, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S23.
May 22, 2017
Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: If the occupant is not adequately restrained in the event of a crash, they have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.
Additional source detail variants (2)
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."
Consequence: If the occupant is not adequately restrained in the event of a crash, they have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.
Seats
Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."
Consequence: If the occupant is not adequately restrained in the event of a crash, they have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.
Dec 22, 2016
Ford Motor Company (Ford) is recalling certain model year 2016 Ford Taurus, 2016-2017 Ford Flex, Lincoln MKT, 2017 Ford Explorer and Ford Explorer Police Interceptor Utility vehicles equipped with 3.5L GTDI engines. Improperly brazed turbocharger oil supply tubes may leak oil on engine components.
Consequence & remedy
Consequence: An oil leak, in the presence of an ignition source, increases the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect, and if necessary, replace the turbocharger oil supply tubes, free of charge. The recall began on January 31, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S46.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE23001 · Windshield Trim Molding Item Detachment
Opened Jan 27, 2023 · Closed Feb 8, 2024
Status: closed (inferred from source dates) · Structure:body:roof And Pillars
On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries. Some consumers have reported that the failure occurred while they were driving at highway speeds, with the detached trim panel entering the path of travel of the vehicle behind them, requiring the driver of the following vehicle to take evasive action. It is noteworthy that motorists who experience this type of road hazard are less likely to accurately identify the subject vehicle the item detached from and report the event to the NHTSA. In its April 17, 2023 response to ODI’s information request, Ford provided 175 consumer complaints (including field reports) and 14,162 warranty claims related to A-pillar trim panel detachment. Ford relayed that the subject vehicles utilize a plastic A-pillar bracket, which is bolted to the vehicle structure during assembly. The A-pillar trim panel is attached to the bracket utilizing 7 plastic clips. Contributory factors which have been identified by Ford as leading to the subject defect include incomplete installation at the assembly plant, inadequate part stack up, damage to fasteners during installation, and failure to follow proper repair procedure during windshield replacements or other services. On January 19, 2024, Ford filed safety recall 24V-031 for MY 2011-2019 Ford Explorer vehicles to address the subject defect. In the Part 573 Safety Recall Report, Ford identified that a detached A-pillar trim panel can create a road hazard for other road users, increasing the risk of a crash. The recall remedy includes an inspection of the existing A-pillar trim panel and, if necessary, the replacement of the component. The remedy A-pillar trim panels will be installed with an additional adhesive for robustness and utilize an inspection procedure to ensure full engagement of all the retention clips during installation. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA17002 · Exhaust Odor In Passenger Cab
Opened Jul 27, 2017 · Closed Jan 17, 2023
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe; Structure:body
During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve
Structure:body
During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve
Illustration