Power Train. Review the 146 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 98 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

8 crash reports2 fire reports11 injury reports

Engine complaints

98 reports

Clear category filter

Mileage unknown · Sep 11, 2026

EnginePower Train

Read full complaint

My 2018 Ford Expedition with the 3.5L EcoBoost engine has developed a pronounced rattling/knocking noise at startup. This appears consistent with the well documented cam phaser/VCT problem affecting this engine family. At approximately 118,212 miles, an independent Firestone Complete Auto Care inspected the vehicle and recommended major timing system repairs. Their estimate calls for replacement of the timing chain components and variable timing sprockets/cam phasers, with a total recommended repair cost of $5,232.13. 220782OrderRevisions.Pdf The concern is not simply the noise. The cam phasers and timing system control critical valve timing. If these components continue to deteriorate, there is a risk of improper engine timing, severe drivability problems, loss of power, stalling, or significant internal engine damage. A failure while traveling at highway speeds or in traffic could create a serious safety hazard for the occupants and surrounding motorists. There have not yet been warning lights or dashboard messages associated with the condition. The primary symptom has been the recurring startup rattle/knock, which has now been confirmed by an independent repair facility as requiring substantial timing system repair. The vehicle remains available for inspection. This has been an ongoing issue for the last few months but was first diagnosed on September 12, 2026 during a repair for another unrelated issue. I am especially concerned because this is not an isolated or unusual type of failure on the 3.5L EcoBoost. Ford has previously recognized cam phaser/VCT startup noise on these engines through service guidance. A known timing-related defect requiring more than $5,000 in repairs, with the potential to progress into engine damage or loss of engine performance, represents a significant reliability and potential safety concern.

NHTSA ODI #11763749

Mileage unknown · Jul 16, 2026

EnginePower TrainVehicle Speed Control

Read full complaint

I noticed a loud rattle when starting my 2018 Ford Expedition, at first occasionally and then on every cold start. The Ford Dealer's service department diagnosed a cam phaser issue. There were no warning lights or messages available to me, but the service department's diagnosis showed several timing faults. I was told the cam phaser repair is $4000 - $5000 and continued use puts the engine and transmission at risk. I contacted Ford customer service and was told that my vehicle was not eligible for assistance with these repairs and that my level of loyalty also did not make me eligible for assistance. I have maintained this vehicle with oil changes, fluid changes, tire and brake maintenance for the life of the vehicle. I would like the NHTSA to investigate Ford for a recall of the cam phasers and effected parts since this is a known and prominent issue that also impacts road safey.

NHTSA ODI #11750763

Mileage unknown · Jun 30, 2026

Electrical SystemEnginePower Train

Engine light stays on along with manual light and charging system service now. Battery, alternator changed out, 3 mechanic repair shops can not find what is wrong. Vehicle bogs down and does not run right when the Manuel light comes one which is about 2 times a week.

NHTSA ODI #11747439

Mileage unknown · May 17, 2026

Engine

After Fords most recent recall for a PCM software update at the dealer the car immediately runs different and after full engine temperatures sounds like marbles or valve train issues including low rpm noise and transmission shutter between shifts. Dealer says there is no problem they can find and that I need new turbos. Very sus…

Read full complaint

NHTSA ODI #11738377

Mileage unknown · May 9, 2026

EnginePower Train

Read full complaint

Transmission will randomly over shift or down shift when driving. When turning left I have had the transmission over shift from 2nd to 8th causing the car to bog down and could not accelerate in the intersection. I was almost hit from behind on one occasion and had hit on the side another time. I do not feel comfortable making turns without having a protected right away. Ford have changed the transmission, reset the programming for the transmission and ford technician said it needed to be replaced by again and Ford denied even though it was under warranty and just reset again. If reset it does go away for a bit but just event returns and only gets worse

NHTSA ODI #11736798

Mileage unknown · May 8, 2026

Electrical SystemEngine

my car is a 2018 we bought it used in 2020 we had to had the transmission flushed and coils replaced . that didn't work . we had drum issues and gear slippage . now i. have to put a new transmission in the car

NHTSA ODI #11736669

35,540 miles · Apr 17, 2026

EngineEngine And Engine Cooling

The contact owns a 2018 Ford Expedition. The contact stated that while driving at an undisclosed speed, there was an abnormal rattling sound coming from the engine. The vehicle was taken to a dealer, where it was diagnosed with camshaft phaser and timing chain failures. The vehicle was repaired. The manufacturer was notified of …

Read full complaint

NHTSA ODI #11731887

Mileage unknown · Apr 6, 2026

EnginePower Train

Read full complaint

Vehicle experienced catastrophic timing system failure causing engine to jump time and stall at idle, creating a safety hazard due to risk of sudden loss of power. This is a repeat issue originally documented under warranty (2020) and again during recall/service program 21N03 (2021), where repair was declined as “not severe enough.” Recall 24E13 (software update intended to prevent timing chain failure) was completed in 2025, but failed to prevent this exact condition. Vehicle is now inoperable and unsafe. This raises concerns about the effectiveness of the recall remedy and prior service handling. We've also submitted a case to Ford: CXH07545978W9W1D2

NHTSA ODI #11729374

Mileage unknown · Mar 21, 2026

Engine

Read full complaint

I am writing to express concern regarding a significant engine issue with my 2018 Ford Expedition. At approximately 122,000 miles, the vehicle developed a cylinder 4 misfire accompanied by low compression, indicating an internal engine failure. This type of issue seems premature for a well-maintained vehicle and has resulted in major repair considerations, including potential engine replacement. Given Ford’s reputation for durability and reliability, I find this failure both unexpected and concerning. I have kept up with regular maintenance and did not anticipate facing a major engine issue at this mileage. I am requesting that Ford review this situation and consider a recall. I have seen and heard of a lot of folks having this same issue at such an early mileage

NHTSA ODI #11726007

Mileage unknown · Feb 5, 2026

Engine

My cam phasers failed. I had a 6 year, 72k mile warranty. All maintenance was done at the dealership at the correct time. The parts failed at 7 years, 75,600 miles. Had to replace the engine. Dealer wanted to charge me $19000. Found a local shop to do it with new Ford engine for $14000. The cam phasers are a known issue. There a…

Read full complaint

NHTSA ODI #11715730

Official recalls

26V402000 · Power Train:automatic Transmission

Jun 24, 2026

Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.

Consequence & remedy

Consequence: Park system damage may result in a vehicle rollaway, increasing the risk of a crash.

Remedy: Dealers will update the powertrain control module software, and inspect and replace any damaged transmission components as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed July 10, 2026. Additional letters will be sent once the remedy is available, anticipated in April 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 26, 2026.

26V368000 · Structure:interior Panels:center Console

Jun 9, 2026

Ford Motor Company (Ford) is recalling certain 2018-2024 Expedition vehicles. The chrome plating on the center console may bubble and peel, resulting in sharp edges.

Consequence & remedy

Consequence: Vehicle occupants may contact the center console's sharp edges, increasing the risk of injury.

Remedy: Dealers will inspect and replace the center consoles as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 16, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S38. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 10, 2026.

26V344000 · Seat Belts:pretensioner

May 27, 2026

Ford Motor Company (Ford) is recalling certain 2018-2022 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently lock the seat belt, which will not allow the belt to retract or extend.

Consequence & remedy

Consequence: Seat belts that do not retract or extend can fail to restrain an occupant as intended, increasing the risk of injury in a crash.

Remedy: Dealers will inspect and replace the seat belt retractors as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 8, 2026. Additional letters will be sent once the remedy is available, anticipated in August 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S34. This recall replaces and expands previous NHTSA recalls 24V099 and 25V197. Vehicles previously inspected or repaired under the prior recalls will need the new repair completed.

25V197000 · Seat Belts:pretensioner

May 23, 2025

Ford Motor Company (Ford) is recalling certain 2018-2020 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently lock the seat belt, which will not allow the belt to retract or extend.

Consequence & remedy

Consequence: Seat belts that do not retract or extend can fail to restrain an occupant as intended, increasing the risk of injury in a crash.

Remedy: Dealers will replace the seat belt retractors as necessary, free of charge. Owner notification letters were mailed October 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S31. Some vehicles in this recall that were previously inspected under recall 24V-099 and did not have parts replaced will need to have this new recall remedy completed.

25V236000 · Service Brakes, Hydraulic:foundation Components:master Cylinder; Service Brakes, Hydraulic:power Assist

Apr 11, 2025

Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.

Consequence & remedy

Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.

Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.

Additional source detail variants (2)

Service Brakes, Hydraulic:foundation Components:master Cylinder

Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.

Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.

Service Brakes, Hydraulic:power Assist

Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.

24V852000 · Equipment:other:labels

Nov 8, 2024

Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Consequence & remedy

Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.

Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.

24V099000 · Seat Belts:pretensioner

Feb 9, 2024

Ford Motor Company (Ford) is recalling certain 2018-2020 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently deploy and lock the seat belt, which will not allow the belt to retract or extend.

Consequence & remedy

Consequence: Seat belts that do not retract or extend may fail to restrain an occupant as intended, increasing the risk of injury in a crash.

Remedy: Dealers will replace the seat belt retractors, as necessary. Additionally, dealers will install an HVAC drain tube elbow if it is missing. Repairs will be performed free of charge. Owner notification letters were mailed on July 8, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S06.

23V420000 · Equipment:other:owners/service/other Manual

Jun 9, 2023

Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."

Consequence & remedy

Consequence: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.

Remedy: Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.

18V805000 · Seats:mid/rear Assembly

Nov 14, 2018

Ford Motor Company (Ford) is recalling certain 2018 Lincoln Navigator, and Ford Expedition vehicles. The second row center seat track assemblies may be missing one or both of the J-Channel reinforcement brackets, possibly allowing the seat to move in the event of a crash.

Consequence & remedy

Consequence: In the event of a crash, a seat that moves may not properly restrain the seat occupant, increasing their risk of injury.

Remedy: Ford will notify owners, and dealers will inspect the second row center seat for any missing J-channel reinforcement brackets, replacing the center seat frame assembly as necessary, free of charge. An interim owner notification was sent on December 21, 2018. A second letter will be mailed once the remedy is available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S37

18V392000 · Fuel System, Gasoline:delivery:fuel Pump

Jun 12, 2018

Ford Motor Company (Ford) is recalling certain 2018 Ford Expedition, F-150, and Lincoln Navigator vehicles equipped with 3.5L GTDI V6 engines. These vehicles have high pressure fuel pump assemblies with welds that can fracture, which may cause an oil or fuel leak.

Consequence & remedy

Consequence: A fuel leak in the presence of an ignition source may increase the risk of a fire.

Remedy: Ford will notify owners, and dealers will replace the high pressure fuel pump and associated components, free of charge. The recall began July 17, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S17.

18V213000 · Power Train:automatic Transmission

Apr 4, 2018

Ford Motor Company (Ford) is recalling certain 2017-2018 Ford F-150 and 2018 Ford Expedition and Mustang and Lincoln Navigator vehicles equipped with 10-speed automatic transmissions. A roll pin may not have been installed in the transmission, potentially causing a loss of the "Park" function.

Consequence & remedy

Consequence: Despite the transmission shift lever being placed in 'Park' and the instrument panel display indicating 'Park,' the vehicle may roll away after it has been exited if the parking brake has not been applied, increasing the risk of injury or a crash.

Remedy: Ford will notify owners, and dealers will inspect the transmission to make sure it has the roll pin, installing one if it is missing, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S09.

18V214000 · Power Train:automatic Transmission; Power Train:automatic Transmission:gear Position Indication (prndl)

Apr 4, 2018

Ford Motor Company (Ford) is recalling certain 2018 F-650 and F-750 vehicles equipped with 6-speed automatic transmissions and 2018 Ford F-150 and Expedition vehicles equipped with 10-speed automatic transmissions (excluding Expedition vehicles with a Rotary Gear Shift Dial on the console). The gear shift cable clip may not be properly seated, allowing the transmission to be in a different gear than indicated by the gear shift lever position.

Consequence & remedy

Consequence: If the gear shift cable clip becomes unseated or dislodged, the gear shift lever position may indicate that the transmission is in 'Park' when it may be in a different gear. Additionally, despite selecting 'Park', if the parking brake is not applied before the vehicle is exited, the vehicle may roll. Either scenario increases the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect the shift cable locking clip and properly seat it, if necessary, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for the recall is 18S10.

Additional source detail variants (2)

Power Train:automatic Transmission:gear Position Indication (prndl)

Consequence: If the gear shift cable clip becomes unseated or dislodged, the gear shift lever position may indicate that the transmission is in 'Park' when it may be in a different gear. Additionally, despite selecting 'Park', if the parking brake is not applied before the vehicle is exited, the vehicle may roll. Either scenario increases the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect the shift cable locking clip and properly seat it, if necessary, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for the recall is 18S10.

Power Train:automatic Transmission

18V058000 · Visibility:power Window Devices And Controls

Jan 16, 2018

Ford Motor Company (Ford) is recalling certain 2018 Ford Expedition and Lincoln Navigator vehicles. The second row window control modules may intermittently stop the movement of the power window. If something, such as a finger, is pinched by the window glass, the stopped window control module may prevent the window from automatically reversing. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 118, "Power-Operated Window Systems."

Consequence & remedy

Consequence: If the window does not automatically reverse when an obstruction is found, it can increase the risk of injury.

Remedy: Ford will notify owners, and dealers will inspect the second row window electronic control modules, and replace them as necessary based on their build date codes, free of charge. The recall began on February 16, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18C01.

17V775000 · Seats:mid/rear Assembly

Dec 1, 2017

Ford Motor Company (Ford) is recalling certain 2018 Expedition vehicles. The second row outboard seats may have excessive forward adjustment capability and/or may have an improperly installed bolt that secures the seat back to the seat base. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 202a, "Head Restraints", number 207, "Seating Systems", and number 210, "Seat Belt Anchorage System."

Consequence & remedy

Consequence: If the seat back is not adequately secured, and/or the seat occupant is improperly positioned, there can be an increased risk of injury in a crash.

Remedy: Ford will notify owners, and dealers will inspect the second row outboard seats for proper seat adjustment travel, replacing the seat frame assembly if necessary. Dealers will also inspect the bolts attaching the seat back to the seat base for the proper installation, correcting it as necessary. These repairs will be made free of charge. The recall began on January 10, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C20.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ24015 · Seat Belt Retractor Pretensioner Inadvertent Deployment

Opened Nov 15, 2024 · Closed Jul 23, 2025

Status: closed (inferred from source dates) · Seat Belts:pretensioner

On November 22, 2023, the Oﬃce of Defects Investigation (ODI) opened Preliminary Evaluation (PE) PE23021 to investigate complaints of front seat belt retractor pretensioner inadvertent deployment in model year (MY) 2019 Ford Expedition vehicles manufactured by Ford Motor Company. Some complaints alleged hearing a loud, explosion-like sound immediately followed by the seat belt tightening around the occupant’s torso area. The complaints did not state that a crash occurred that may have resulted in the deployment of the pretensioner system, suggesting that this deployment was inadvertent or otherwise unwarranted. On February 9, 2024, Ford issued safety recall 24V-099, recalling certain MY 2018-2020 Ford Expedition and Lincoln Navigator vehicles equipped with driver and front passenger seat belt retractor pretensioners built between October 1, 2018, and June 30, 2019. Ford described the defect as a seat belt retractor pretensioner assembly that may develop corroded squib pins, resulting in high resistance or an open circuit, which could result in an inadvertent deployment of a pretensioner and an increased risk of injury due to the loss of the pretensioner’s protection and a seat belt that remains in the locked position. This recall includes 77,574 vehicles. On November 15, 2024, ODI opened this Recall Query (RQ24015) after receiving 3 complaints involving vehicles not included in recall 23V-099 but that alleged a similar failure. As a result of this investigation, Ford issued safety recall 25V-197 on March 28, 2025, to expand the scope of 24V-099 to include MY 2018-2020 Ford Expedition and Lincoln Navigator vehicles equipped with driver and front passenger seat belt retractor pretensioners built between October 1, 2018, and July 31, 2020. This recall includes 105,322 vehicles, some of which are also included in 24V-099. Additionally, on May 23, 2025, Ford issued 25V-197 Amendment #1, which further expands the recall population’s scope for vehicles with build dates of September 2018. This amendment added 7,627 additional vehicles to the 25V-197 population. In response to ODI’s inquiries in RQ24015, Ford indicated that it cannot conclusively determine the root cause of the relevant failure. Ford was able to determine that certain pretensioners may develop corroded squib pins potentially resulting in inadvertent deployment, but it was unable to specify the cause of corrosion. Without a speciﬁc root cause, Ford assessed ﬁeld performance of pretensioners to determine the scope of the recalls. ODI is aware of three vehicles that experienced pretensioner inadvertent deployment that are not included in either 25V-197 or 24V-099. Two of these vehicles are MY 2018 Lincoln Navigator vehicles built prior to October 1, 2018, and both experienced failures after more than six years of use/exposure while the recalled vehicles experienced higher rate of failures with less exposure. The remaining incident involves a MY 2021 Ford Expedition that was built after July 31, 2020. ODI is not aware of any other relevant failures in vehicles built after July 31, 2020. As such, ODI has not currently identified a safety defect trend for this issue in vehicles outside of the recalled populations. ODI will continue to monitor allegations of pretensioner inadvertent deployment in subject vehicles that are not included in 25V-197. In view of the safety recall action being taken by Ford, ODI is closing this Recall Query (RQ24015). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identiﬁcation Number document, go to NHTSA.gov.