2015 Ford Expedition

WHILE DRIVING MY 2015 FORD EXPEDITION HOME FROM WORK, MY VEHICLE SUDDENLY LOST ALL GAS POWER TO THE VEHICLE. MY STEERING STILL WORKED AND POWER WAS STILL ON BUT I HAD NO GAS. I PULLED OVER, TURNED MY ENGINE OFF AND RESTARTED AND COULD GO AGAIN. IT TOOK 6 TIMES TO RESTART TO GET 2 MILES TO SAFE POINT. WHERE I THEN HAD MY VEHICLE TOWED TO THE NEAREST FORD DEALERSHIP. I THOUGHT IT WAS THE FUEL PUMP. TURNS OUT IT WAS THE ELECTRONIC THROTTLE BODY. WHICH IS A KNOWN ISSUE FOR THE FORD ENGINE, THE NHTSA HAD ENOUGH COMPLAINTS THAT FORD ISSUED A MANDATORY EXTENDED WARRANTY FOR 4 OTHER TYPE FORD VEHICLES BUT NOT THE EXPEDITION, WHICH HAS THE SAME TYPE OF ENGINE. I HAD TO PAY $560.00 TO HAVE THIS PART REPLACED ON MY VEHICLE WHEN IT'S A KNOWN FORD ISSUE. MY VEHICLE HAD 50,700 MILES ON IT AT THE TIME OF THE OCCURRENCE. I HOPE THAT THE NHTSA WILL LOOK INTO THIS ISSUE AND HAVE FORD EXPAND THEIR MAKE AND MODEL WARRANTY AS WELL AS REIMBURSE ME FOR MY EXPENSES FOR THIS REPLACEMENT.

VEHICLE LOST POWER WHILE DRIVING ON CITY STREET. NO WARNING PRIOR TO LOSING POWER. HAD A "WRENCH" LIGHT APPEAR ON DASH. I HAD TO COAST TO SIDE OF THE ROAD. HAD I BEEN ON THE HIGHWAY, MERGING, OR TURNING IN FRONT OF APPROACHING VEHICLES, THERE IS A HIGH PROBABILITY THERE WOULD HAVE BEEN AN ACCIDENT. I ATTACHED A TESTER ON THE VEHICLE AND P2112 DEFECT CODE APPEARED INDICATING A STUCK THROTTLE ACTUATOR CONTROL. THIS VEHICLE HAS LESS THAN 60,000 MILES AND WAS JUST IN FOR A MAJOR MILESTONE VEHICLE INSPECTION.

1/28/17 DRIVING 65 MPH ON A FLORIDA HIGHWAY (NOT ON CRUISE CONTROL) THE THROTTLE/GAS PEDDLE SENSOR (THROTTLE BODY) SHUTS OFF THE GAS TO THE ENGINE AND THE CAR SLOWS TO A STOP. THIS IS IN THE MIDDLE OF TRAFFIC. WE MANAGE TO PULL TO THE SIDE OF THE HIGHWAY, TURN THE CAR OFF AND ON AND THE PROBLEM DISAPPEARS FOR ANOTHER 50 MILES WE DRIVE THE CAR TO A FORD DEALER AND THEY REPLACE THE THROTTLE BODY FOR $500. I AM . OUT OF WARRANTY = OVER 36,000 MILES I TELL MY STORY TO 2 ST LOUIS FRIENDS, ALSO OWN FORDS (2006 EXPLORER, 2008 EDGE) AND THEY SAY THAT THEY HAVE HAD THE SAME EXPERIENCE AND NECESSARY REPAIR. I JUST NOTIFIED FORD CUSTOMER SERVICE 800-392-3673 AND THEY SAY THAT THEY DO NOT HAVE A RECALL OR ISSUE WITH THIS PROBLEM. THIS IS A VERY DANGEROUS SITUATION AND HAS BEEN IGNORED BY FORD FOR YEARS. I ALSO OWNED A TOYOTA DURING THEIR SUDDEN ACCELERATION PROBLEM A FEW YEARS AGO AND THIS SEEMS WORSE

OUR 2015 FORD EXPEDITION WITH 20,000 MILES IN CALIFORNIA HAS ALUMINUM BODY CORROSION ON THE FRONT HOOD AND REAR TAILGATE DOOR. FORD HAS KNOWN ABOUT THIS "IRON CONTAMINATION" PROBLEM SINCE THE YEAR 2000 AND HAS DONE NOTHING ABOUT IT, DOCUMENTED IN THREE TECHNICAL SERVICE BULLETINS 2004 TSB 04-25-1, 2006 TSB 06-25-15 AND 2016 TSB 16-0028. DEALERSHIPS ARE AWARE, BUT DO NOT DISCLOSE THE FACTORY DEFECT PRIOR TO SALE AND IS "NOT" COVERED UNDER THE CORROSION WARRANTY.

2015 FORD EXPEDITION WITH 20,000 MILES HAS GALVANIC CORROSION ON ALUMINUM HOOD AND ALUMINUM REAR HATCH DOOR AND ROOF WELD CRACKS. FORD HAS KNOWN ABOUT THIS PROBLEM SINCE THE YEAR 2000 NOTED IN TSB 16-0028. DEALERS ARE AWARE, BUT DO NOT DISCLOSE MANUFACTURING DEFECT PRIOR TO SALE, WHICH IS FRAUD. NOT PROPERLY SEPARATING THE OUTER ALUMINUM FROM THE STEEL INSIDE CAUSES EXTREME CORROSION. THIS LEADS TO HOOD AND DOOR LATCH METAL FAILING WITH HOODS OR DOORS OPENING DURING DRIVING CAUSING ACCIDENTS OR DEATH.

STARTED TO NOTICE VIOLENT SHAKING IN THE FRONT OF THE VEHICLE WHEN THE BRAKES ARE APPLIED AT INTERSTATE SPEEDS. THE 2015 EXPEDITION 4WD HAS 19,000 MILES ON THE ODOMETER. AT VERY LOW SPEEDS THERE IS THE SAME SHAKING OF THE FRONT BRAKES---BUT MUCH LESS NOTICEABLE APPARENTLY DUE TO THE LOW SPEED. TRYING TO SCHEDULE WARRANTY INSPECTION AT LOCAL FORD DEALER.

I WAS INVOLVED IN A MAJOR FRONT END COLLISION YESTERDAY THAT IS MOST LIKELY RESULTING IN TOTALING MY BRAND NEW CAR. MY ENTIRE FRONT END IS DEMOLISHED AND FRAME WAS DEFINITELY EFFECTED AS CAR DOORS COULDN'T EVEN BE OPENED. WITH ALL THAT SAID MY AIR BAGS DIDN'T DEPLOY, THE SAFETY FEATURE THAT IS SUPPOSED TO PROTECT MY FAMILY AND I GOD FORBID WE GET IN AN ACCIDENT WHICH WE DID AND I WANT TO KNOW WHY! I CONTACTED FORD LAST NIGHT AND THEY REFERRED MY TO MY DEALERSHIP AND WHEN I CALLED MY DEALERSHIP THEY TOLD ME THEY DON'T MAKE THE CARS! I JUST WANT ANSWERS.