2019 Ford Escape

I own a 2019 Ford Escape with a 1.5L EcoBoost engine. The vehicle began experiencing engine misfires and a powertrain malfunction warning. Diagnostic code P0302 appeared for cylinder 2 misfire. The coolant reservoir level began dropping without any visible external leaks. A mechanic performed a pressure test and confirmed there were no external coolant leaks, indicating coolant intrusion into the engine cylinder. This is a known defect affecting 2017 - 2019 Ford Escape 1.5L EcoBoost engines. The issue can cause engine misfires, reduced power, and potential engine failure while driving. This problem poses a safety concern because engine power can be reduced unexpectedly while driving.

I have a 2019 Escape with only 33k miles. The check engine light came on for P0304cyl 4 misfire and on/off again rough idle. Ford service had technician pulled plug on cylinder four and used a borescope and found coolant leaking into engine. Ford has a known TSB for coolant intrusion on this particular model and vin and manufacturing date. Ford refuses to help me with cost to replace the long block of the engine at a cost of $14000. The blue book is 10k. This appears to be a very common issue and needs a recall immediately. This is completely wrong of Ford to do this to customer fully knowing there is a problem but won't pay to fix it.

Ford at Jim Ellis dealership in [XXX] [XXX] look at my car last Thursday and gave me only one code P0304 which means tune up but texted me that my car need $8000 of labor and $6k of a new engine, without an explanation. Prior too the vin they pulled up showed Cust satisfaction 21N12 said yes a recall when the rep saw it. However, even expired 2022 another paragraph states If exceed mileage 84000 and 7 yrs ..that THIS IS NO COST. Yet ford still stating not related to Cust sat...engine fire, exhaust low coolant smoke rides rough which is what my car did last Saturday 3/14/26. To text me 15k pay or not with a conversation as to why but invoiced only one code about a tune up yet told the Tow guy my coolant going into the engine but didn't advise me of that same information is highly unprofessional this is a risk and unsafe I have seen 3 other complaints 2025 2022 same issues and on kbb. The rep said that depends on manuf well it showed [XXX] same manuf as Cust satisfaction. This should be listed as a new recall many more complaints on kbb.....I will notify FTC as I am also a govt worker its unruly unsafe and for Ford to act unworthy with no integrity is an outrage. I called there corp and complained as well. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

We just bought this vehicle 3 weeks ago, paid sales tax and first car payment. The check engine light came on for P0304cyl 4 misfire, notice white smoke blowing from exhaust and low coolant level. Had technician pull plug four and used a boriscope and found coolant leaking into engine. Ford has a known TSB for coolant intrusion on this particular model and vin and manufacturing date. Ford refuses to help me with cost to replace the long block of the engine at a cost of $7000, out of my pocket. I have not even put a thousand miles on this car. This is completely wrong of Ford to do this to customer fully knowing there is a problem but won't pay to fix it.

In June 2025 vehicle had no coolant in tank, refilled and monitored, July 2025 check engine light appeared and code for cylinder 3 misfire, Aug 2025 vehicle went to local certified automotive repair company who began running diagnostics, replaced spark plug and coil #3. After replacement was asked to drive, less than 10 miles check engine came back on with same code. Mechanic kept working on vehicle until December/January 2026 when it was determined and confirmed that there is a coolant leak, running a check engine with malfunction of cylinder 3 inevitably leading to full engine failure. Was quoted February 2026 by another local certified automotive repair company over $8,000 for the removal and install of a new engine.

I initially replaced the entire Y coolant hose to the coolant system. Six months later I had to replace a secondary coolant hose separate from the initial one. Initially, it cost me about $600 and then $300 for the second incident. Now March 22 I have to replace a coolant bypass valve because it has been failing and my car is overheating again. The HVAC system is not working properly and the car is overheating.

The contact owns a 2019 Ford Escape. The contact stated that while driving at an undisclosed speed or while the vehicle was parked, there was a loud ticking sound coming from the vehicle. There was no warning light illuminated. The vehicle was taken to a dealer, where it was diagnosed, and it was determined that the flex plate had failed and needed to be replaced, and that additional transmission parts needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 112,823.

The contact owns a 2019 Ford Escape. The contact stated that while coming to a stop, there was an abnormal clanking sound coming from the vehicle. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed, and it was determined that the flex plate had failed and needed to be repaired. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure, and a case was opened. The failure mileage was approximately 79,545.