2018 Ford Escape

The contact owns a 2018 Ford Escape. The contact stated that while driving at various speeds, the vehicle was jerking, and the vehicle hesitated while accelerating. The vehicle was taken to the local dealer who diagnosed that the transmission torque converter had malfunctioned and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 59,000.

On 3/15/2026 I was on my way home from Massachusetts to Pennsylvania, and about 35 minutes into my drive I got an alert stating "High Engine Temperature Stop Safely", so I pulled over immediately and turned the car off. After allowing the engine to cool down, I opened the hood and started the car to see if I could identify any issues, the "Engine Fault Service Now" alert came up. This was the first time this ever happened, this put me, my two dogs who were in the car with me, and possibly others on the road at risk, had the conditions escalated. (i.e. under hood fire). The vehicle was towed to an Authorized Ford Dealership, Mathieu Ford Sales, Inc. who diagnosed the issue on 3/17/2026. The dealership removed the spark plugs to inspect cylinders and found coolant intrusion into cylinders significantly on cylinder 2. Dealership referenced TSB 22-2322, is recommending short block assembly and related parts to remedy concern. Dealership advised it was safe and okay to drive the vehicle slowly to a nearby residence (to store the vehicle/retain possession), noting to pull over if an alert pops up and to have it towed if I received another message like before. The dealership advised it was not safe to drive the vehicle back to Pennsylvania. There weren't any issues driving the vehicle back on 3/17/2026 following the dealership's guidance; the car hasn't been driven since. The car needed to be jumped to start the vehicle on 4/17/2026 for a tow truck to load the vehicle onto its bed. The vehicle is currently back in possession of the dealership who diagnosed the issue. Upon doing research, this appears to be a widespread manufacturing design defect that Ford has failed to properly address/recall. My vehicle met the criteria under their Customer Satisfaction Program in 2022 - the vehicle is an Escape, 2017-2019, assembled in Louisville, that was Built before April 8, 2019, and which exhibited a covered condition, having low coolant. Ford Motor Co is failing to remedy-cure.

My 2018 Ford Escape has diagnostic codes P0302 and P0316 cylinder 2 misfire and no compression on cylinder 2 due to coolant intrusion into the engine block. This is a known defect documented in Ford TSB 22-2322 and Customer Satisfaction Program 21N12. My VIN was excluded from this program despite having the identical failure and identical fault codes as covered vehicles. This engine failure occurred at highway speed creating a dangerous safety hazard. Ford has refused goodwill assistance despite this being a known manufacturing defect.

Check engine light on. code = P0303. Safety issue for overheating with potential engine fire. Local dealership service has diagnosed as coolant intrusion into cylinder #3 and coolant loss. vehicle has not been inspected by manufacturer, police, insurance representative or other. Vehicle was serviced on January 29th of 2020 for customer satisfaction program 19B37. Vehicle has failed at 88000 miles due same design issue addressed by Ford Motor Company under customer satisfaction program 21N12.

Keep getting an error code for P0303 cylinder 3 misfire. I have replaced everything to correct this problem but keep getting the same error. Started noticing that coolant is leaving reservoir and only returns when I remove the cap. When I turn the car off I hear water rushing behind the dashboard. There are no leaks seen. I've started having very quick and sudden overheating that cools quickly after stopping the car. I get a dash message "engine fault service now" message that goes away after I remove the cap from the coolant, thus allowing the reservoir to refill. I've been dealing with the P0303 code off and on for a year now, but the coolant issue started a couple of months ago. Yesterday was the first overheating of the engine and the only place I could pull over was very dangerous and I was not able to fully get out of the road. I saw there is a recall on 2018 Ford Escapes for coolant intrusion. Why is this one not included?!

My 2018 Ford Escape, which has experienced catastrophic engine failure due to the well-documented coolant intrusion defect in the 1.5L EcoBoost engine. In early March 2026, without any prewarning or engine light, my vehicle displayed an “Engine Fault Service Now” warning and stored diagnostic trouble code P2601 (Coolant Pump A Control Circuit Performance/Range). I immediately took the vehicle to Bidwell Automotive in [XXX] , where on March 10–11, 2026, technician Gannon performed a thorough inspection. The findings were as follows: the coolant level was critically low; the water pump showed signs of leaking; the top of the piston in the affected cylinder appeared washed clean (a hallmark of coolant entering the combustion chamber); and the technician detected an odor consistent with combustion gases in the cooling system. The diagnosis was a suspected failed head gasket consistent with internal coolant intrusion. I then brought the vehicle to Future Ford Lincoln of Roseville, your authorized dealership, on March 12, 2026 (RO #XXX, Service Consultant [XXX] , Certified Technician [XXX] ). Future Ford verified the coolant intrusion into Cylinder 2 by removing the spark plugs and performing a borescope inspection. The dealership’s own technician referenced TSB 22-2322 and recommended either a short block replacement ($9,396.45) or a long block replacement ($13,331.01). The dealership confirmed that my vehicle has no remaining warranty coverage and offered no assistance beyond the paid repair estimate. Ford’s Documented Knowledge of This Defect Ford Motor Company has long been aware that the 1.5L EcoBoost engine in 2017–2019 Escape vehicles suffers from a structural design defect in the engine block’s cooling passages that causes coolant to intrude into the cylinders. Ford’s own actions confirm this knowledge. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The component that is failing in my vehicle is the engine, specifically the 1.5L EcoBoost engine short block, which is experiencing coolant intrusion into the cylinders. This defect causes misfires, rough running, loss of coolant without visible leaks, and can lead to catastrophic engine failure. The car and all its components are available for inspection upon request. My safety, my child's safety, as well as the safety of others on the road, has been put at risk because this engine defect can cause sudden misfires, loss of power, or complete engine failure while driving. I rely on this vehicle to transport my special needs toddler to and from essential care appointments and therapies. I have experienced sudden intermittent powertrain loss that has resulted in the vehicle randomly stopping on highway. A local auto shop diagnosed the issue free of charge. It was explained to me that this is a known defect that Ford has documented, and other owners have reported to the National Highway Traffic Safety Administration, demonstrating that it is reproducible in vehicles with this engine type. My vehicle has not been inspected by Ford for repair coverage, nor have police or insurance representatives been involved. Ford has reviewed my VIN internally but refused coverage based on a narrow eligibility range, leaving me responsible for repair costs that are financially burdensome and urgently needed for the safety and care of my child. As of now I experience random misfires, rough running, white thick smoke expelling from the exhaust, random powertrain loss, and unexplained loss of coolant. These symptoms appeared gradually but are consistent with the documented defect in other vehicles with the same engine type, model, and assembly plant, making it clear that my vehicle is affected by the same issue.

I was driving on the highway, and there was an abrupt loss of drive and failure of the car. The transmission failed suddenly when I was traveling at highway speed, and there was no prior warning. This nearly caused an accident with the cars behind me, but I managed to get off the road into the shoulder. This is a safety concern, since there were no prior signs at all of this happening. The transmission failure was immediate. I purchased the car new, and I'm the only owner. I kept up well with maintenance, even doing the oil changes prior to the oil light coming on. I spoke to several Ford dealers, including the Ford dealer I purchased my car in 2018. He admitted that the transmission in this make and model needs often replacement. The miles on my car is approximately 116,000.

Transmission Fault in red letters came on. Turned car off and then turned back on after 20 minutes and the message disappeared. Three days later same things happened- repeated what I did before and message went away. I've noticed when I try to accelerate it sounds as if I'm accelerating but I'm not getting passed 20 mph. Car does a hard jerk when trying to accelerate.

I was on my way to work on 2/4/2026 and all of a sudden the RPMs went up really high and wouldn’t accelerate and then down shifted really hard so I pulled over. It then showed on the dash “System Fault: Transmission Fault Service Now” I ended up needing a tow truck. This is NOT ok! It’s also apparently a common occurrence which means it should be recalled and fixed!