2017 Ford Escape

The contact owns a 2017 Ford Escape. The contact stated while driving 75 MPH, the transmission downshifted and upshifted intermittently, and the vehicle lost motive power. The check engine warning light was illuminated. The contact stated that while attempting to slow down and exiting the highway, the brake pedal was depressed however, the brake pedal was extremely stiff. The vehicle was shifted to neutral(N) for the vehicle to slow down. The vehicle was taken to an independent mechanic where a handheld diagnostic machine retrieved information that the cam shaft sensor was not working properly, and the engine needed to be replaced. Additionally, the brake booster was defective and failed to build up pressure as needed. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 150,000. The VIN was not available.

I have a 2017 Ford Escape and just had it in the Ford dealer for inspection and was informed that all of my lug nuts are swollen a;nd stripped and need replacement.  I checked online and found that this is a recurrent issue with Ford vehicles where the lug nuts can swell due to a two-piece design with a steel core and decorative outer shell, often made of aluminum or chrome. The outer shell can corrode, swell, and delaminate making it difficult or impossible to remove the lug nut with a standard lug wrench. This is a common issue among Ford models and can lead to drivers being stranded with flat tires.  There was a Class Action suit started in 2017 that was subsequently dismissed.  I feel that this is negligent on Ford's behalf as it is a known design fault and safety issue and they should be issuing a recall to replace these lug nuts at no cost. I agreed to have Ford replace the lug nuts as I was concerned for my safety, should I need to get the lug nuts off. The cost was $267.95 plus 6% tax = $284.03. I was also informed that the replacement lug nuts are the same design and are only guaranteed for 2 years. I fail to understand why this safety issue doesn't warrant a recall to be issued and I should be reimbursed for my replacement.

My car began throwing codes for a Cylinder 2 misfire in October of 23. We did a tune up. Within a few months, same issue. By Oct of 24 my head gasket needed replaced. Now it is August of 25 and I am having the same issue and signs that the head gasket is bad again. I am told by dealers this is due to a faulty head gasket that Ford knowingly put in the vehicles. There is a limited recall for the 1.6L but not the 2.0 EcoBoost motors. I am now out thousands of dollars for the new head gasket less than a year ago and am being told the only fix is to replace the engine as a whole which will be thousands of more. This is due to Ford putting in faulty parts, and not taking responsibility. I am now out of a car, while working full time with an [XXX] and a baby on the way because Ford my & my childrens safety is not worth driving a car that could break down at any moment. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

What component or system failed or malfunctioned, and is it available for inspection upon request? 1.5L short block, due to coolant intrusion to the cylinder bores How was your safety or the safety of others put at risk? The engine could stop running. I drive with two small children so their safety would be at risk. Has the problem been reproduced or confirmed by a dealer or independent service center?Confirmed by a dealer. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Check engine light. This is a known issue that Ford is aware of. I did not receive any communication that this should be fixed and am now facing a repair that exceeds that value of the vehicle.

The contact owns a 2017 Ford Escape. The contact stated that while at a complete stop at a red traffic light, a driver walked up to the contact and informed the contact that there was smoke coming from the rear of the vehicle. Additionally, the contact noticed an abnormal sweet odor coming from the exterior of the vehicle. The check engine warning light was illuminated. The contact drove the vehicle to the residence. The vehicle was taken to an independent mechanic, where it was determined that the engine was consuming coolant excessively. The contact was informed that the engine block assembly needed to be replaced. The contact was informed of Ford Technical Service Bulletin Number: 22-2229, which the contact related to the failure. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure and a case was filed. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 137,000.