2017 Ford Escape

Purchased Vehicle on October 11, 2024. Took car out of town check engine light came on. Took back on October 16th as it had a P0301 cylinder 1 misfire code. They replaced a coil pack said it was good to go. Check engine light came back on a few days later, went to auto zone to scan same code informed dealership. Took it to dealership on November 5th, 2024 they kept overnight to do a leak down test and found coolant in cylinder 1. Engine is bad. Vehicle has 60,000 miles on it and since it is new to me I can’t confirm how long this has been a problem and been covered up.

The contact owns a 2017 Ford Escape. The contact stated while starting the vehicle, there was white smoke coming from the exhaust pipes. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to Customer Satisfaction Program: 22N12 (Rattle Noise at the Transmission Bellhousing Area – Flex plate Cracks); however, the VIN was not included in the Customer Satisfaction Program. The manufacturer was made aware of the failure. The failure mileage was 84,000.

The contact owns a 2017 Ford Escape. The contact stated that while starting the vehicle, the contact became aware of white exhaust smoke coming from the rear exhaust pipes. The vehicle was taken to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to Customer Satisfaction Program: 22N12 (transmission fluid pump, and torque converter); however, the VIN was not included in the Customer Satisfaction Program. The manufacturer was made aware of the failure. The failure mileage was 113,000.

On the way to work, MIL came on that stated, “high engine temperature stop safely”. After pulling over and turning car off for about 10 minutes, trip to work continued and MIL came on again. Had vehicle TOWED IN to a trusted mechanic and he checked and advised: CONFIRMED OVERHEAT CONDITION, VEHICLE WAS LOW ON COOLANT, OVERHEAT CODE STORED IN PCM. REFILLED WITH COOLANT AND FOUND STEADY STREAM OF COMBUSTION LEAVING THE COOLING SYSTEM THROUGH COOLANT BOTTLE. SUSPECT DAMAGE TO HEADGASKET AND POSSIBLY ENGINE BLOCK OR CYLINDER HEAD.

My 2017 Ford escape 1.5L ecoboost. Had the brake booster completely fail while driving down the highway on Oct. 27th. I took it the next day to the Ford Service center in my area. They informed me it was the Brake booster and would cost around $1100. They called me two days later and told me instead it was the vacuum pump, and that it was be cheaper to fix. They said it would be done that following Monday. On Monday I got a phone call asking me when the last time I changed/checked my oil. I told them it was changed on Aug 7th. It was checked (with video evidence) on October 19th. They told me they were “test driving my vehicle and heard a loud pop, followed by my car turning off.” They informed me that there was very little oil in my pan and that my car had thrown a rod. I explain that my oil level was fine, and that my car had no indication of needing oil. They replied with similar comments such as “the car gave no warning or indication light. It was driving just fine, it was shifting fine. Everything was fine until pop.” My husband asked his mechanic (who was unavailable at the time) and was told “when a vacuum pump goes out the engine will continue to supply oil in an attempt to cool the pump. The oil will then go to the exhaust and due to the eco system on the exhaust. The driver won’t know.” With this information, an investigation into a recall seems necessary.

Escape had a miss and the check engine light went on and stayed on. I took it to the dealer for a diagnostic. They informed me that the engine needed replacement due to coolant leaking into the cylinder bore. The cost of repair is $7,100. The vehicle has 105,000 miles on it. The service person told me that the leak was due to a design flaw and I had done nothing to cause it.

The contact's fiancé owns a 2017 Ford Escape. The contact stated that the vehicle was taken to the dealer for sale. The contact stated that while the dealer was test-driving the vehicle at an undisclosed speed, the check engine warning light illuminated. The dealer determined that the head gasket and engine block had failed, resulting in coolant intrusion into cylinders #1 and #3. The dealer also discovered that the engine had consumed a quart of oil, and there was smoke coming from the exhaust pipe due to engine blowby. The dealer added a quart of engine oil and informed the contact that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 24,000.