2017 Ford Escape

The contact owns a 2017 Ford Escape. The contact stated while driving 40 MPH, the messages "Engine Hot - Stop Safely" and the "Engine Fault" were displayed. The vehicle was taken to an independent mechanic to be diagnosed, and the contact was informed that the head gasket needed to be replaced, and the engine needed to be disassembled and reassembled and coolant needed to be added. The vehicle was then taken to the dealer to be diagnosed, and the contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline to report the failure. The approximate failure mileage was 81,000.

The temp warning light came on our 2017 escape - temp gauge always remained on normal - had it towed to the Ford dealer in Texas. Service writer said it is the head gasket since there is no external leak but, coolant was low. Engine will have to be replaced at the expense of $12,000. I mention the recall and he said he would take another look to see if he can verified the damage in detail. this car has 58,241 - car was title to Texas on 06/15/2024 and had a emissions test and passed. This warning light just came on this day and never before. The car is still at the Ford dealer and not sure what the dealership will do next. I need help.

Brakes have failed twice and been repaired. Several sensors have failed and been repaired. The engine failed and had to be totally rebuilt. The vehicle has only 45000 miles. Minor, but paint has peeled down to bare metal. The engine has just been repaired by dealership - it was a bear to get that accomplished. Ford Corporation would not assist but the dealership itself was very proactive. When the incident happened several warnings came on but did not stay on - stopped right in the middle of a street which in my view created a huge safety hazard . We were able to restart and get off the road but had to have it towed. It would not go faster than 5-10 mph. I have done much research on the vehicle to find out that this failure was due to a design and numerous manufacturing flaws - coolant leaked into the engine block and cracked the heads. Ford Corporation has known this for a long time and was not forthcoming when the other repairs were done. The paint and the brakes are also well known problems. The vehicle is now repaired but the question is - for how long? It was inspected through Sam Galloway Ford in Fort Myers FL. I don’t feel like I can even sell/trade the vehicle and pass these issues on to someone else. Ford is certainly not being fair to other drivers who are having the same EcoBoost engine problems.

My 2017 Ford Escape experienced the same engine issue noted by many with Ford Escapes from 2012-2019. There is an issue where the engine block cracks and coolant leaks into the engine, ultimately requiring the engine and many other components be replaced. Our vehicle was serviced by Ford in July 2024 and we paid out of pocket for an engine diagnostic. This diagnostic resulted in a clean bill of health being reported for the engine, despite Ford knowing about the defects affecting this engine years earlier. By December 2024, the check engine light came on and when evaluated at both a Ford Service Center and independent auto mechanic, the resulting diagnosis was that the engine and many other components had to be replaced. The cost of this repair was to exceed $11,000 - none of which would be paid by Ford. This amount exceeded the value of the car at the time, resulting in a need to purchase a new vehicle without salvaging any value from the 2017 Ford Escape that only had 72,000 miles on it.

January 8, 2025 To the NHTSA: My wife, [XXX] and I, [XXX] , have a 2017 Ford Escape. We have been informed that our vehicle has a defective lower-engine block that is resulting in coolant seeping into the engine cylinders, which causes the engine to overheat. This damage can also result in the engine becoming completely destroyed. A fire can also result. Upon further investigation by ourselves, this defect can cause a fire and it poses a great risk to our health and safety. We read a litigation about affected consumer with this same issue and we also called a Ford Service Center in Minnesota. The service rep told us the issue is related to a faulty design in the bottom half of the engine block. Apparently there are grooves, that in some cases, allow coolant to seep in. The rep said Ford has given them a service bulletin which talks about the issues and the rep said Ford has "re-designed" their lower engine block as a replacement part for such vehicle in light of the issue. Our cost of replacing the lower engine block would be about $12,000, since our car has about 78,000 miles and is out of factory warranty. Ford should bear responsibility for this and should have caught this problem through its quality controls. While our car isn't burning coolant yet, we fear it's only a matter of time before we experience an issue that so many others have. We are extremely disappointed in Ford for this. We would like the NHTSA to force Ford Motor Company to do a recall for this. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2017 Ford Escape. The contact stated that while driving at an undisclosed speed, the vehicle was jerking. The check engine warning light was illuminated. The contact's son replaced the ignition coils and spark plugs, but the failure persisted. The vehicle was taken to the dealer, where it was diagnosed with engine oil intrusion into the cylinders. The contact was informed that the engine needed to be replaced. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 77,700.