DRIVERS SIDE DOOR WINDOW CRANK SHAFT (MANUAL WINDOW) SNAPPED OFF CLEAN INSIDE REGULATOR LEAVING WINDOW UTTERLY INOPERABLE. THIS HAPPENED DURING NORMAL OPERATION OF WINDOW DURING NORMAL OPERATING CONDITIONS AND WARM WEATHER. DEALER CLAIMED "IT HAPPENS A LOT". VERY DANGEROUS IF VEHICLE WAS IN A FIRE, ACCIDENT, SUBMERGED IN WATER E…
Read full complaint
DRIVERS SIDE DOOR WINDOW CRANK SHAFT (MANUAL WINDOW) SNAPPED OFF CLEAN INSIDE REGULATOR LEAVING WINDOW UTTERLY INOPERABLE. THIS HAPPENED DURING NORMAL OPERATION OF WINDOW DURING NORMAL OPERATING CONDITIONS AND WARM WEATHER. DEALER CLAIMED "IT HAPPENS A LOT". VERY DANGEROUS IF VEHICLE WAS IN A FIRE, ACCIDENT, SUBMERGED IN WATER ETC. *JB
NHTSA ODI #10174716
79,000 miles · Mar 14, 2005
VisibilityFire
RECALL CAMPAIGN 01V230000 CONCERNING HEATER BLOWER RESISTOR. ON TWO SEPARATE OCCASIONS VEHICLE CAUGHT ON FIRE WHILE IDLING IN THE DRIVEWAY. BOTH TIMES CONSUMER EXTINGUISHED THE FIRE, AND VEHICLE WAS TAKEN TO A REPAIR SHOP. THE MECHANIC DETERMINED THAT THE HEATER BLOWER WAS THE CAUSE OF BOTH FIRES. CONSUMER CONTRACTED THE DEALE…
Read full complaint
RECALL CAMPAIGN 01V230000 CONCERNING HEATER BLOWER RESISTOR. ON TWO SEPARATE OCCASIONS VEHICLE CAUGHT ON FIRE WHILE IDLING IN THE DRIVEWAY. BOTH TIMES CONSUMER EXTINGUISHED THE FIRE, AND VEHICLE WAS TAKEN TO A REPAIR SHOP. THE MECHANIC DETERMINED THAT THE HEATER BLOWER WAS THE CAUSE OF BOTH FIRES. CONSUMER CONTRACTED THE DEALER AND THE MANUFACTURER. BOTH CONFIRMED THAT THIS VEHICLE WAS NOT COVERED UNDER THE RECALL DUE TO VIN. *AK
NHTSA ODI #10115053
27,000 miles · Feb 19, 2004
Visibility
THE PASSENGER'S SIDE REAR VIEW MIRROR CAME OFF WITHOUT BEING IMPACTED. THIS OCCURRED WHILE THE OUTSIDE TEMPERATURE WAS 19 DEGREES. *AK
NHTSA ODI #10053686
Mileage unknown · Aug 5, 2003
Visibility
CONSUMER STATES THAT HEATER FAN HAS FAILED.*AK
NHTSA ODI #10032072
Mileage unknown · Mar 19, 2003
Visibility
THE HEATER WORKED INTERMITTENTLY. *JB
NHTSA ODI #10012133
Mileage unknown · Mar 7, 2003
Visibility
THE HEATER WAS INOPERATIVE.*JB
NHTSA ODI #10011158
Mileage unknown · Dec 5, 2002
Visibility
CONSUMER STATES THAT THE DEALERSHIP DIDN'T DO THE RECALL FOR THE HEATER BLOWER PROPERLY, AND AFTER THE RECALL WAS DONE THE HEATER BLOWER WAS INOPERVATIVE. TS
NHTSA ODI #8023801
Mileage unknown · Aug 5, 2002
Engine And Engine CoolingExterior LightingPower Train
CONSUMER STATES THAT THE VEHICLE POPPED OUT OF GEAR AND WENT INTO NEUTRAL WHILE MAKING A LEFT HAND TURN, CONSUMER ALSO STATES THAT THERE ARE INTERMITTENT PROBLEMS WITH GETTING VEHICLE INTO GEAR, VEHICLE EXPERIENCED SHIFT AND CLUTCH PROBLEMS. *SLC
NHTSA ODI #566887
Mileage unknown · Jul 24, 2002
Electrical SystemEngine And Engine CoolingSteering
THE VEHICLE STALLED INTERMITTENTLY WITHOUT WARNING. ONE DAY THE VEHICLE STALLED 12 TIMES. THE ENGINE LIGHT HAS BEEN ILLUMINATED SINCE PURCHASED. NLM THE VEHICLE STALLED THE SECOND DAY THE CONSUMER EVER DROVE IT. THE BLOWER ON THE A/C AND HEATER FAILED. ON ONE OCCASION THE VEHICLE WOULDN'T START. IT TURNED O…
Read full complaint
THE VEHICLE STALLED INTERMITTENTLY WITHOUT WARNING. ONE DAY THE VEHICLE STALLED 12 TIMES. THE ENGINE LIGHT HAS BEEN ILLUMINATED SINCE PURCHASED. NLM THE VEHICLE STALLED THE SECOND DAY THE CONSUMER EVER DROVE IT. THE BLOWER ON THE A/C AND HEATER FAILED. ON ONE OCCASION THE VEHICLE WOULDN'T START. IT TURNED OUT THE PROBLEM WAS WITH THE ALARM SYSTEM. *NM
NHTSA ODI #566836
Mileage unknown · May 9, 2002
Visibility
DURING THE WINTER I TURNED ON MY HEATING UNIT AND IT WOULD NOT BLOW UNLESS IT WAS ON HIGH. I WOULD HAVE TO CONSTANTLY TURN MY HEAT OFF AND ON BECAUSE IT WOULD BE TOO HOT THEN TOO COLD. I NOTICED ON REAL COLD DAYS THE HEATING SYSTEM WOULD MALFUNCTION ON MILDER DAYS THE HEATING SYSTEM WOULD WORK CORRECTLY. MY WINDOW WOULD GET O…
Read full complaint
DURING THE WINTER I TURNED ON MY HEATING UNIT AND IT WOULD NOT BLOW UNLESS IT WAS ON HIGH. I WOULD HAVE TO CONSTANTLY TURN MY HEAT OFF AND ON BECAUSE IT WOULD BE TOO HOT THEN TOO COLD. I NOTICED ON REAL COLD DAYS THE HEATING SYSTEM WOULD MALFUNCTION ON MILDER DAYS THE HEATING SYSTEM WOULD WORK CORRECTLY. MY WINDOW WOULD GET OFF TRACT AND I WOULD HAVE TO CONSTANTLY SET THE WINDOW IN PLACE WHILE I RAISE THE WINDOW. TOOK THE CAR TO THE DEALER AND THEY COULD NOT FIND ANYTHING WRONG WITH IT.*AK
VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT AT THE KANSAS CITY ASSEMBLY PLANT AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND THE DISTRICT OF COLUMBIA. THE FRONT COIL SPRINGS MAY FRACTURE AS A RESULT OF CORROSION IN HIGH CORROSION ENVIRONMENTS. DEPENDING ON THE LOCATION OF THE FRACTURE, A BROKEN SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.
Consequence & remedy
Consequence: SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.
Remedy: DEALERS WILL INSTALL SPRING CATCHER BRACKETS. OWNER NOTIFICATION BEGAN OCTOBER 23, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
ON CERTAIN MY 1996-1998 PASSENGER VEHICLES BUILT AT THE KANSAS CITY, CUAUTITLAN ASSEMBLY PLANTS OR ON MY 1999 PASSENGER VEHCLES BUILT AT THE AUTOMOTIVE ALLIANCE INTERNATIONAL ASSEMBLY PLANTS, THE ROUGH SURFACE OF THE HEATER BLOWER RESISTOR'S STAINLESS STEEL BLADES CAN DAMAGE THE COPPER SURFACE OF THE WIRING HARNESS CONNECTOR. THE DAMAGE COULD, OVER TIME, CAUSE INCREASED RESISTANCE IN THE CONNECTOR AND, DUE TO SUBSEQUENT TERMINAL RELAXATION, RESULT IN AN OPEN CIRCUIT CONDITION.
Consequence & remedy
Consequence: THE OPEN CIRCUIT COULD LEAD TO ELECTRICAL ARCING THAT COULD MELT THE CONNECTOR HOUSING MATERIAL CREASING THE POTENTIAL FOR A FIRE.
Remedy: DEALERS WILL INSTALL A NEW HEATER BLOWER RESISTOR AND A NEW WIRE JUMPER HARNESS. OWNER NOTIFICATION BEGAN AUGUST 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
VEHICLE DESCRIPTION: BI-FUEL VEHICLES. THESE VEHICLES MAY HAVE A FUEL TANK FILLER PIPE GROMMET THAT COULD HAVE BEEN DAMAGED DURING THE INSTALLATION OF THE BI-FUEL SYSTEM. IF THE GROMMET IS DAMAGED, FUEL COULD LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE. DEALERS WILL REPLACE THE FUEL TANK FILLER PIPE GROMMET.
Consequence & remedy
Consequence: IF THE GROMMET IS DAMAGED, FUEL COULD LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK FILLER PIPE GROMMET.
VEHICLE DESCRIPTION: PASSENGER VEHICLES NOT EQUIPPED WITH THE ANTI-LOCK BRAKING SYSTEM (ABS). A PRESSURE CONSCIOUS REDUCING VALVE (PCRV) IN THE REAR BRAKES MAY BE SUBJECT TO CORROSION AND RESULT IN MALFUNCTION, WHEN OPERATED IN AREAS THAT USE SALT COMPOUNDS ON THE ROADWAY FOR DE-ICING OR DUST CONTROL.
Consequence & remedy
Consequence: IF BOTH PCRV'S MALFUNCTION, VEHICLE HANDLING COULD BE ADVERSELY AFFECTED DURING BRAKING AS A RESULT OF THE REAR WHEELS LOCKING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL IMPROVED PCRV'S IN THE REAR BRAKE SYSTEM. THIS RECALL WAS EXPANDED IN SEPTEMBER 2000 TO INCLUDE 1999 AND 2000 FORD CONTOUR, MERCURY MYSTIQUE AND COUGAR VEHICLES.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSOR WIRING PIGTAIL INSULATION CAN BECOME BRITTLE AND CRACK OVER TIME DUE TO ACCUMULATION OF WATER IN THE PIGTAIL PROTECTIVE CONVOLUTE IN COMBINATION WITH HIGH UNDERHOOD TEMPERATURES RELATED TO THE ROUTING OF THE WIRING PIGTAIL NEAR THE RADIATOR. THIS CAN RESULT IN ENVIRONMENTAL STRESS CRACKING OF THE INSULATION.
Consequence & remedy
Consequence: IN SOME CASES, THE AIR BAG WARNING LIGHT CAN ILLUMINATE AND THE AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM DISABLED.
Remedy: DEALERS WILL INSTALL AIR BAG SENSORS WITH REVISED WIRING INSULATION. IN ADDITION, VEHICLES WHICH HAVE THE AIR BAG WARNING LIGHT ILLUMINATED WILL HAVE A NEW AIR BAG DIAGNOSTIC MONITOR INSTALLED.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ACCELERATOR CABLE MAY HAVE BEEN MANUFACTURED WITH A BURR ON OR NEAR THE END OF THE CABLE SLEEVE INTERIOR. THIS BURR COULD FRAY THE CORE WIRE RESULTING IN THE ACCELERATOR NOT RETURNING TO IDLE WHEN THE ACCELERATOR IS RELEASED.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN THE THROTTLE STICKING, BINDING, OR CAUSING HIGH ENGINE RPM.
Remedy: DEALERS WILL INSTALL A REVISED ACCELERATOR CABLE THAT HAS A FLARED CONDUIT SLEEVE END AND MOLDED ON END FITTING.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TERMINALS AT THE HEADLIGHT SWITCH AND WIRING HARNESS CONNECTOR CAN EXPERIENCE HEAT DAMAGE AS A RESULT OF OVERHEATING.
Consequence & remedy
Consequence: THE DAMAGE COULD RESULT IN DISTORTION OF THE TERMINAL CAUSING AN OPEN CIRCUIT IN THE INSTRUMENT PANEL ILLUMINATION, PARKING LAMP, AND TAIL LAMP CIRCUITS.
Remedy: DEALERS WILL INSTALL A HEADLAMP SWITCH WIRING CONNECTOR CONTAINING BRONZE TERMINALS AND AN INSPECTION, AND REPLACEMENT IF NECESSARY, OF THE HEADLAMP SWITCH.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FLOOR SHIFT AUTOMATIC TRANSMISSION CONTROL CAN BE DAMAGED IF SUBJECTED TO CERTAIN INTERIOR CLEANING PRODUCTS. THE GEAR POSITION INDICATOR CAN DETERIORATE AND NOT CORRECTLY INDICATE THE ACTUAL GEAR POSITION.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INCORRECT GEAR SELECTION.
Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FLOOR SHIFT CONTROL.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TEXT AND/OR GRAPHICS FOR THE VEHICLE HEADLAMP AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES ARE NOT SUFFICIENTLY CLEAR. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY BE CONFUSED BY THE AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES CAUSING THE HEADLAMPS TO BE IMPROPERLY AIMED.
Remedy: OWNER GUIDES CONTAINING REVISED AIMING INSTRUCTIONS WILL BE MAILED TO OWNERS OF THESE VEHICLES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7
RQ02006 · Incorrect Gear Indication
Opened Feb 26, 2002 · Closed Sep 12, 2002
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
EA01001 · Blower Switch/resistor Or Wiring Harness
Opened Jan 5, 2001 · Closed Jul 31, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
Additional source detail variants (2)
Electrical System
There is no summary currently available
Electrical System
There is no summary currently available
EA00025 · Fuel Expulsion During Refueling
Opened Oct 4, 2000 · Closed Jan 25, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE00027 · Fuel Expulsion During Refueling
Opened Jul 10, 2000 · Closed Oct 4, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE00023 · Blower Switch/resistor Or Wiring Harness
Opened Jun 14, 2000 · Closed Jan 5, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ99019 · Various Intermittent Electrical Issues
Opened Sep 15, 1999 · Closed Mar 7, 2001
Status: closed (inferred from source dates) · Unknown Or Other
There is no summary currently available
SQ98002 · Fuel Gauge Does Not Read Below 1/4
Opened Jan 27, 1998 · Closed Jul 31, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
FORD'S SERVICE BULLETIN DATED DECEMBER 8, 1997, POINTS OUT THAT THE FUEL GAUGE WILL NOT READ ABOVE 3/4 TANK OR BELOW 1/4 TANK OF FUEL.THE ERRONEOUS FUEL GAUGE READING WILL INDICATE SIGNIFICANTLY MORE FUEL RESERVE THAN ACTUALLY PRESENT IN THE FUEL TANK.ODI HAS ONE COMPLAINT WHERE THE DRIVER ALLEGED THAT HIS VEHICLE RAN OUT OF GAS DUE TO A FALSE FUEL GAUGE READING.THIS INVESTIGATION WASTO ASCERTAIN FACTS CONCERNING THE PROBLEM EXPERIENCE, SCOPE, AND RATIONAL FOR ELECTING NOT TO CONDUCT A SAFETY COMPAIGN.
1998 Ford Contour Problems, Complaints & Recalls | Skip That Year
Illustration