Engine And Engine Cooling. Review the 132 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 130 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 128 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

50 crash reports20 fire reports36 injury reports

Service Brakes, Hydraulic complaints

83 reports

Clear category filter

Mileage unknown · Sep 24, 2014

Fuel System, GasolineService Brakes, Hydraulic

1998 FORD CONTOUR. CONSUMER WRITES IN REGARDS TO VEHICLE BRAKE LINE CORROSION. *SMD THE CONSUMER STATED THE BRAKES THE FAILED. THE REPAIR SHOP, STATED THERE WAS NO BRAKE FLUID IN THE RESERVOIR. THE CONSUMER ALSO STATED THE GAS LINE LEADING TO THE TANK HAD TO BE REPLACED, DUE TO CORROSION. *JB

NHTSA ODI #10637919

133,000 miles · Jun 3, 2008

EquipmentService Brakes, Hydraulic

Read full complaint

TL*THE CONTACT OWNS A 1998 FORD CONTOUR. THE CONTACT PURCHASED BRAKESAFE FRONT DISC PADS FOR THE VEHICLE. APPROXIMATELY 30 MILES LATER, A GRINDING AND RATTLING NOISE WAS HEARD AND AN OUTER LINING ON THE PADDING FELL OFF. THE CONTACT TOOK THE VEHICLE TO THE MECHANIC AND WAS INFORMED THAT THE PADS WERE DEFECTIVE. HE PURCHASED NEW PADS, WHICH HE FELT WORKED AS THEY SHOULD HAVE. HE ATTEMPTED TO CALL THE AUTO PARTS STORE FROM WHERE HE PURCHASED THE DEFECTIVE PADS, BUT THEY WOULD NOT ASSIST. HE ALSO CALLED THE CORPORATE OFFICE AND RECEIVED NO ASSISTANCE. THE CONTACT FILED COMPLAINTS WITH THE FEDERAL TRADE COMMISSION AND OHIO ATTORNEY GENERAL. THE SERIAL NUMBER AND PART NUMBER WERE UNKNOWN. THE CURRENT MILEAGE WAS 135,000 AND FAILURE MILEAGE WAS 134,970. UPDATED 06/25/08. *CN THE CONSUMER STATED PASSENGER SIDE CALIPER WAS WARPED AND THE ROTOR WAS DAMAGED. UPDATED 06/25/08

NHTSA ODI #10229703

50,000 miles · Jun 29, 2005

Service Brakes, HydraulicSuspension

DT: VEHICLE STARTED MAKING LOUD NOISES AND THE BRAKES FAILED. CALLER WAS DRIVING ON A HIGHWAY AND HAD TO PULL OFF THE ROAD. CALLER SAID BRAKES DID NOT WORK VERY WELL WHEN SHE TRIED TO GET THE CAR HOME. DEALER SAID THE FRONT LEFT ROTOR BROKE ,AND REAR WHEEL BEARING WORE OUT . MANUFACTURER WILL NOT OFFER ANY HELP.*AK

NHTSA ODI #10127011

48,000 miles · Oct 4, 2004

Electrical SystemService Brakes, Hydraulic

THE BLOWER AND ABS SYSTEM WERE DEFECTIVE. THE ABS LIGHT WAS ON. THE FUSE NEEDED TO BE REPLACED, AFTER INSPECTION WIRING HARNESS WAS FOUND TO BE DEFECTIVE. THERE WAS A RECALL FOR VEHICLES THROUGH 1997. *AK

NHTSA ODI #10094947

118,410 miles · Aug 11, 2004

Service Brakes, Hydraulic

Read full complaint

BRAKE FAILURE. ON A 1998 FORD CONTOUR SVT (~118,440 MILES), THE BOLT ATTACHING THE REAR BRAKE CALIPER RESULTED IN A SINGLE POINT FAILURE TO THE BRAKING SYSTEM. *JB WHILE DRIVING NORTH ON US 301, JUST SOUTH OF LAPLATA, MD, I HEARD A POP AND THE CAR FELT AS IF I HAD RUN OVER SOMETHING, BUT NOTHING APEARED IN THE ROAD (FROM THE MIRRORS). LATER WHEN SLOWING WHILE APPROACHING AA TRAFFIC SIGNAL, I HAD NO BRAKES. THANKFULLY I WAS ON A SLIGHT INCLINE AND ABLE TO GEAR DOWN AND USE WHAT LITTLE BRAKES REMAINED TO STOP THE CAR AND CRAWL IT TO A PARKING LOT. AFTER HAVING THE CAR TOWED IN, MY MECHANIC TOLD ME THAT ONE BOLT ATTACHING ONE OF THE REAR CALIPERS HAD SHEARED OFF CAUSING THE LOSS OF BRAKING POWER ON THE CAR. THE CAR DID NOT LOSE ANY BRAKE FLUID DURING ALL OF THIS.

NHTSA ODI #10086659

122,000 miles · Jul 22, 2004

Service Brakes, Hydraulic

Read full complaint

HAD VEHICLE TAKEN IN FOR NORMAL PMI (PREVENTIVE MAINTENANCE INSPECTION) SERVICING AND DURING INSPECTION-- THE REAR PCRV (PRESSURE CONSCIOUS REDUCING VALVES WERE FOUND TO BE CORRODED AND LEAKING. THIS VEHICLE IS OPERATED IN WI (SALT IS USED ON ROADWAYS UP HERE). THERE IS A RECALL OUT FOR THIS ITEM, BUT IT COVERS NON-ABS VEHICLES ONLY....... MY VEHICLE HAS THE ABS SYSTEM. IT LOOKS LIKE THE RECALL WASN'T EXPANDED FAR ENOUGH..... PROBLEMS ARE STILL OUT THERE!!!!! THE TECHNICIAN THAT DID THE REPAIR ON THE CAR SAID THAT HE HAD DONE THAT SPECIFIC RECALL ON OTHER VEHICLES MULTIPLE TIMES, AND STATED THAT THE REPLACED PCRVS ON MY CAR WERE THE *OLD STYLE* VALVES..... THAT IS WHY HE WAS CONCERNED AND RECOMMENDED I REPLACE THE PCRVS ASAP--- WHICH WAS DONE THAT DAY. THERE WAS NO ACCIDENT/INJURY/FATALITY INVOLVED IN THIS INCIDENT OBVIOUSLY. BUT THERE COULD HAVE BEEN. THE RELATED RECALL INFORMATION THAT I'M REFERRING TO IS AS FOLLOWS: NHTSA CAMPAIGN ID: 00V075000. *JB

NHTSA ODI #10082437

78,600 miles · Jun 14, 2004

Service Brakes, Hydraulic

WHILE DRIVING 35 MPH DRIVER APPLIED THE BRAKES AND THE REAR BRAKES LOCKED UP. DRIVER WAS ABLE TO CONTROL THE VEHICLE. *AK THE VEHICLE HAS BEEN REPAIRED. *NM

NHTSA ODI #10065239

53,000 miles · Jun 10, 2004

Electrical SystemService Brakes, Hydraulic

Read full complaint

1) A/C BLOWER SHUT OFF AND UPON INVESTIGATION A 60 AMP FUSE BROKE UNDER THE FUSE BOX IN THE FRONT OF THE CAR UNDER THE ENGINE HOOD WERE DAMAGED. AND FURTHER INSPECTION SHOWED SEVERAL OPEN WIRES COMING FROM THE BATTERY AND ONE COMMING FROM THE FUSE BOX WHICH IS BELIEVED TO HAVE CAUSED THE FUSE TO BREAK. 2) NOTIFIED BY 2 DIFFERENT AUTO-ELECTRICAL REPAIR SHOPS THEY HAD SEEN SIMULAR DAMAGE AND INFORMED ME OFF THE COSTS OF A REPLACEMENT WIRING HARNESS AND LABOR WHICH RANGED FROM $3800 - $4400. CHECKING OTHER VARIOUS WEB SITES SHOWED A LOT MORE PEOPLE WITH THE SAME PROBLEMS WHICH RANGED FROM FIRES TO HAVING TO DRIVE WITH BROKEN FUSES OR HAVING TO PAY HIGH AMOUNTS TO REPLACE IT. 3) DOING PREVENTATIVE MAINTENTENCE BY CLEANING AREA AND SPRAYING A HIGH BASE IN THE AREA TO PREVENT FURTHER DAMAGE CAUSED BY EXPOSED WIRES TO THE ELEMENTS ON A WEEKLY BASES TILL I CAN AFFORD SUCH A LARGE REPAIR AND NOT REPLACING A FUSE WHICH CONTROLS MY BLOWER AND ABS. *AK

NHTSA ODI #10075148

Mileage unknown · May 19, 2003

Service Brakes, Hydraulic

WHEN THE DRIVER APPLIED THE BRAKES THEY LOCKED UP AND CAUSED THE VEHICLE TO EXPERIENCE EXTENDED STOPPING DISTANCE. *NLM

NHTSA ODI #10020049

Mileage unknown · Mar 11, 2003

EquipmentService Brakes, Hydraulic

Read full complaint

MY COMPLIANT IS THAT I WAS BACKING MY CAR UP AND THE FRONT BRAKES LOCKED UP SPECIFICALLY THE RIGHT FRONT. THE CAR WOULD NOT MOVE. YOU COULD SMELL BURNING AND SEE SMOKE FROM THE RIGHT FRONT WHEEL. I HAD TO HAVE THE CAR TOWED TO MY MECHANIC. AFTER EXTENSIVE WORK ON THE CAR WE FOUND OUT THAT THE BRAKE CALIPER PISTON WOULD NOT RETRACT INTO THE CALIPER, AFTER THE MECHANIC REASSEMBLED THE CAR, HE FOUND OUT THE RIGHT CALIPER WOULD NOT BLEED OUT, AFTER EXTENSIVE TESTING THE CONCLUSION WAS REACHED NO FLUID WOULD COME OUT OF THE PORT ON THE HYDRAULIC CONTROL UNIT TO THAT WHEEL. REPLACEMENT OF THE HCU AND MODULE ASSEMBLY WAS NECESSARY. MY CAR WAS TOWED TO THE MECHANICS ON 2-06-2003 AND WAS FINALLY FINISHED ON 2-20-2003. THE DELAY IN GETTING THE CAR FINISHED WAS BECAUSE IT WAS THE CONTOUR SVT MODEL 1998, CHANGES IN THE BRAKE PARTS HAD BEEN MADE AND WERE NOT EASY TO OBTAIN. THE FORD DEALER DID NOT HAVE THE PARTS NEEDED TO COMPLETE THE JOB THEY HAD TO BE ORDERED. I HAVE ALL THE PARTS THAT WERE PULLED OFF THE CAR. ALSO LETTER FROM MY MECHANIC. *JB

NHTSA ODI #10010322

Official recalls

01V255000 · Suspension:front:springs:coil Springs

Aug 8, 2001

VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT AT THE KANSAS CITY ASSEMBLY PLANT AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND THE DISTRICT OF COLUMBIA. THE FRONT COIL SPRINGS MAY FRACTURE AS A RESULT OF CORROSION IN HIGH CORROSION ENVIRONMENTS. DEPENDING ON THE LOCATION OF THE FRACTURE, A BROKEN SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.

Consequence & remedy

Consequence: SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.

Remedy: DEALERS WILL INSTALL SPRING CATCHER BRACKETS. OWNER NOTIFICATION BEGAN OCTOBER 23, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

01V230000 · Electrical System

Jul 9, 2001

ON CERTAIN MY 1996-1998 PASSENGER VEHICLES BUILT AT THE KANSAS CITY, CUAUTITLAN ASSEMBLY PLANTS OR ON MY 1999 PASSENGER VEHCLES BUILT AT THE AUTOMOTIVE ALLIANCE INTERNATIONAL ASSEMBLY PLANTS, THE ROUGH SURFACE OF THE HEATER BLOWER RESISTOR'S STAINLESS STEEL BLADES CAN DAMAGE THE COPPER SURFACE OF THE WIRING HARNESS CONNECTOR. THE DAMAGE COULD, OVER TIME, CAUSE INCREASED RESISTANCE IN THE CONNECTOR AND, DUE TO SUBSEQUENT TERMINAL RELAXATION, RESULT IN AN OPEN CIRCUIT CONDITION.

Consequence & remedy

Consequence: THE OPEN CIRCUIT COULD LEAD TO ELECTRICAL ARCING THAT COULD MELT THE CONNECTOR HOUSING MATERIAL CREASING THE POTENTIAL FOR A FIRE.

Remedy: DEALERS WILL INSTALL A NEW HEATER BLOWER RESISTOR AND A NEW WIRE JUMPER HARNESS. OWNER NOTIFICATION BEGAN AUGUST 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

00V350000 · Fuel System, Other:storage:tank Assembly

Oct 30, 2000

VEHICLE DESCRIPTION: BI-FUEL VEHICLES. THESE VEHICLES MAY HAVE A FUEL TANK FILLER PIPE GROMMET THAT COULD HAVE BEEN DAMAGED DURING THE INSTALLATION OF THE BI-FUEL SYSTEM. IF THE GROMMET IS DAMAGED, FUEL COULD LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE. DEALERS WILL REPLACE THE FUEL TANK FILLER PIPE GROMMET.

Consequence & remedy

Consequence: IF THE GROMMET IS DAMAGED, FUEL COULD LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL TANK FILLER PIPE GROMMET.

00V075000 · Service Brakes, Hydraulic:foundation Components

Mar 9, 2000

VEHICLE DESCRIPTION: PASSENGER VEHICLES NOT EQUIPPED WITH THE ANTI-LOCK BRAKING SYSTEM (ABS). A PRESSURE CONSCIOUS REDUCING VALVE (PCRV) IN THE REAR BRAKES MAY BE SUBJECT TO CORROSION AND RESULT IN MALFUNCTION, WHEN OPERATED IN AREAS THAT USE SALT COMPOUNDS ON THE ROADWAY FOR DE-ICING OR DUST CONTROL.

Consequence & remedy

Consequence: IF BOTH PCRV'S MALFUNCTION, VEHICLE HANDLING COULD BE ADVERSELY AFFECTED DURING BRAKING AS A RESULT OF THE REAR WHEELS LOCKING, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL IMPROVED PCRV'S IN THE REAR BRAKE SYSTEM. THIS RECALL WAS EXPANDED IN SEPTEMBER 2000 TO INCLUDE 1999 AND 2000 FORD CONTOUR, MERCURY MYSTIQUE AND COUGAR VEHICLES.

99V243000 · Air Bags:frontal:sensor/control MODULE-INACTIVE

Sep 8, 1999

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSOR WIRING PIGTAIL INSULATION CAN BECOME BRITTLE AND CRACK OVER TIME DUE TO ACCUMULATION OF WATER IN THE PIGTAIL PROTECTIVE CONVOLUTE IN COMBINATION WITH HIGH UNDERHOOD TEMPERATURES RELATED TO THE ROUTING OF THE WIRING PIGTAIL NEAR THE RADIATOR. THIS CAN RESULT IN ENVIRONMENTAL STRESS CRACKING OF THE INSULATION.

Consequence & remedy

Consequence: IN SOME CASES, THE AIR BAG WARNING LIGHT CAN ILLUMINATE AND THE AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM DISABLED.

Remedy: DEALERS WILL INSTALL AIR BAG SENSORS WITH REVISED WIRING INSULATION. IN ADDITION, VEHICLES WHICH HAVE THE AIR BAG WARNING LIGHT ILLUMINATED WILL HAVE A NEW AIR BAG DIAGNOSTIC MONITOR INSTALLED.

99V194000 · Vehicle Speed Control

Jul 20, 1999

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ACCELERATOR CABLE MAY HAVE BEEN MANUFACTURED WITH A BURR ON OR NEAR THE END OF THE CABLE SLEEVE INTERIOR. THIS BURR COULD FRAY THE CORE WIRE RESULTING IN THE ACCELERATOR NOT RETURNING TO IDLE WHEN THE ACCELERATOR IS RELEASED.

Consequence & remedy

Consequence: THIS CONDITION CAN RESULT IN THE THROTTLE STICKING, BINDING, OR CAUSING HIGH ENGINE RPM.

Remedy: DEALERS WILL INSTALL A REVISED ACCELERATOR CABLE THAT HAS A FLARED CONDUIT SLEEVE END AND MOLDED ON END FITTING.

99V103000 · Exterior Lighting:headlights:switch

May 5, 1999

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TERMINALS AT THE HEADLIGHT SWITCH AND WIRING HARNESS CONNECTOR CAN EXPERIENCE HEAT DAMAGE AS A RESULT OF OVERHEATING.

Consequence & remedy

Consequence: THE DAMAGE COULD RESULT IN DISTORTION OF THE TERMINAL CAUSING AN OPEN CIRCUIT IN THE INSTRUMENT PANEL ILLUMINATION, PARKING LAMP, AND TAIL LAMP CIRCUITS.

Remedy: DEALERS WILL INSTALL A HEADLAMP SWITCH WIRING CONNECTOR CONTAINING BRONZE TERMINALS AND AN INSPECTION, AND REPLACEMENT IF NECESSARY, OF THE HEADLAMP SWITCH.

98V233000 · Power Train:automatic Transmission:lever And Linkage:floor Shift

Sep 18, 1998

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FLOOR SHIFT AUTOMATIC TRANSMISSION CONTROL CAN BE DAMAGED IF SUBJECTED TO CERTAIN INTERIOR CLEANING PRODUCTS. THE GEAR POSITION INDICATOR CAN DETERIORATE AND NOT CORRECTLY INDICATE THE ACTUAL GEAR POSITION.

Consequence & remedy

Consequence: THIS CONDITION CAN RESULT IN INCORRECT GEAR SELECTION.

Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FLOOR SHIFT CONTROL.

98V028000 · Exterior Lighting:headlights

Feb 10, 1998

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TEXT AND/OR GRAPHICS FOR THE VEHICLE HEADLAMP AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES ARE NOT SUFFICIENTLY CLEAR. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence & remedy

Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY BE CONFUSED BY THE AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES CAUSING THE HEADLAMPS TO BE IMPROPERLY AIMED.

Remedy: OWNER GUIDES CONTAINING REVISED AIMING INSTRUCTIONS WILL BE MAILED TO OWNERS OF THESE VEHICLES.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗