ENGINE CHECK LIGHT REMAINED ILLUMINATED ON DASH,AND BRAKE FLUID WAS LEAKING. DEALER HAS REPLACED REAR BRAKE PRESSURE CONTROL VALVE. *AK THE CONSUMER STATED THAT THE BREAKS WERE FINE NOW SINCE REPLACING THE DEFECTIVE BRAKE VALVE. THE BLOWER MOTOR HAD NO 3RD SPEED DUE TO BLOWER MOTOR SWITCH FAILURE. IT WAS REPLACED BY THE DEALER…
Read full complaint
ENGINE CHECK LIGHT REMAINED ILLUMINATED ON DASH,AND BRAKE FLUID WAS LEAKING. DEALER HAS REPLACED REAR BRAKE PRESSURE CONTROL VALVE. *AK THE CONSUMER STATED THAT THE BREAKS WERE FINE NOW SINCE REPLACING THE DEFECTIVE BRAKE VALVE. THE BLOWER MOTOR HAD NO 3RD SPEED DUE TO BLOWER MOTOR SWITCH FAILURE. IT WAS REPLACED BY THE DEALER. THE VEHICLE TAKES FUEL VERY SLOW DUE TO FUEL PIPE FLAPPER VALVE FAILURE. *YH
NHTSA ODI #8001657
Mileage unknown · Nov 16, 2001
Electrical SystemEquipment
THE WIRING OF THE MAIN FUSE PANEL CRYSTALIZES DUE TO EXCESSIVE HEAT FROM THE ENGINE COMPARTMENT WHICH CAUSES A BREAKAGE IN THE WIRING AND THE WIRING TO OVERHEAT. THIS HAS MANIFESTED ITSELF BY CAUSING AIR CONDITIONER BLOWER MOTOR NOT TO WORK. THE WIRING GETS EXTREMELY HOT WHEN THIS HAPPENS. I KNOW OF OTHER CONTOURS THAT HAVE …
Read full complaint
THE WIRING OF THE MAIN FUSE PANEL CRYSTALIZES DUE TO EXCESSIVE HEAT FROM THE ENGINE COMPARTMENT WHICH CAUSES A BREAKAGE IN THE WIRING AND THE WIRING TO OVERHEAT. THIS HAS MANIFESTED ITSELF BY CAUSING AIR CONDITIONER BLOWER MOTOR NOT TO WORK. THE WIRING GETS EXTREMELY HOT WHEN THIS HAPPENS. I KNOW OF OTHER CONTOURS THAT HAVE EXPERIENCED THIS SAME PROBLEM.*AK
NHTSA ODI #754606
Mileage unknown · Nov 9, 2001
Equipment
AIR CONDITIONER UNIT GIVES OUT A MUSTY AND MILDEW ODOR. DEALERSHIP IS AWARE OF PROBLEM. *AK
NHTSA ODI #899003
Mileage unknown · Mar 12, 2001
Electrical SystemEngine And Engine CoolingEquipment
FIRST DAY CAR WAS BOUGHT ENGINE DIED, TOOK TO DEALER, AND THEY GAVE CONSUMER ANOTHER CONTOUR. CURRENTLY, VEHCILE WILL SHUT OFF IN MIDDLE OF INTERSECTION. DEALER REPLACED TRANSMISSION, AND ENGINE WAS ACTING UP. *AK CONSUMER STATES VEHICLE HAS BEEN IN 3 TIMES FOR TRANSMISSION PROBLEMS, IT JERKS AND VIBRATES, CONSUMER DOES …
Read full complaint
FIRST DAY CAR WAS BOUGHT ENGINE DIED, TOOK TO DEALER, AND THEY GAVE CONSUMER ANOTHER CONTOUR. CURRENTLY, VEHCILE WILL SHUT OFF IN MIDDLE OF INTERSECTION. DEALER REPLACED TRANSMISSION, AND ENGINE WAS ACTING UP. *AK CONSUMER STATES VEHICLE HAS BEEN IN 3 TIMES FOR TRANSMISSION PROBLEMS, IT JERKS AND VIBRATES, CONSUMER DOES NOT THINK THAT DEALER REPLACED TRANSMISSION LIKE THEY SAID. 1 TIME FOR ENGINE PROBLEMS. CONSUMER HAS BEEN IN 2 ACCIDENTS DUE TO SUDDEN ACCELERATION. FRONT SWAY BAR REPLACED, STEERING WOULD SHIMMY AND RATTLE. BLOWER MOTOR ASSEMBLY REPLACED, DUE TO RATTLING NOISE IN AIR CONDITIONER, ALSO CYCLING SWITCH REPLACED DUE TO AIR CONDITIONER NOT COOLING. LEFT FRONT SEAT BELT BUCKLE ASSEMBLY REPLACED, BELT WOULD NOT BUCKLE. STARTER FAILED AND WAS REPLACED. ENGINE LIGHT ILLUMINATED, DEALER FOUND LOOSE CONNECTION AT ACT. REAR STRUTS REPLACED, NOISY. *SLC
NHTSA ODI #882762
Mileage unknown · Dec 18, 2000
Equipment
A/C HEATER BLOWER CONSTANTLY BLOWING ON AND OFF. WIRE SHOWS EVIDENCE OF BURNING. WHEN WIRE IS JIGGLED IT MAY OR MAY NOT TURN THE BLOWER BACK ON. EXPERIENCED A COMPLETE OUTAGE BEGINING 12/12/00 AND STILL WILL NOT COME ON RESULTING IN NO HEAT OR A/C IN MY CAR. *AK
NHTSA ODI #737962
Mileage unknown · Nov 1, 2000
Electrical SystemEngine And Engine CoolingEquipment
A/C NOT COLD ENOUGH DUE TO FAULTY SEAL O-RINGS AT THE EVAPORATOR TOP AND LOWER LINE OUTLET. NLM
NHTSA ODI #557054
Mileage unknown · Aug 21, 2000
Engine And Engine CoolingEquipmentPower Train
I WAS IN TRANSIT TO REPLACE MY BRAKING SYSTEM FOR THE SECOND TIME IN 6 MONTHS WHEN MY TRANSMISSION FAILED. MY 'CHECK ENGINE' LIGHT STAYS ON AND THE CAR NOW STALLS WHEN IN A STOPPED POSITION AT A TRAFFIC LIGHT. THESE ISSUES, AMONGST A LIST OF OTHER MAJOR FAILURES HAS OCCURRED IN THE LAST 2.5 YEARS OF OWNERSHIP OF THIS LEMON ( CO…
Read full complaint
I WAS IN TRANSIT TO REPLACE MY BRAKING SYSTEM FOR THE SECOND TIME IN 6 MONTHS WHEN MY TRANSMISSION FAILED. MY 'CHECK ENGINE' LIGHT STAYS ON AND THE CAR NOW STALLS WHEN IN A STOPPED POSITION AT A TRAFFIC LIGHT. THESE ISSUES, AMONGST A LIST OF OTHER MAJOR FAILURES HAS OCCURRED IN THE LAST 2.5 YEARS OF OWNERSHIP OF THIS LEMON ( COMPLETE A/C SYSTEM HAS BEEN REPLACED, COMPLETE FUEL SYSTEM HAS BEEN REPLACED, WINDOW MOTOR HAS BEEN REPLACED, ETC.). NEITHER THE FORD MANUFACTURER OR DEALERSHIPS HAVE RESPONDED, AGREED OR OFFERED ANY INVESTIGATION, CORRECTION, COMPENSATION OR ASSISTANCE IN RESPONSE TO THESE PREVIOUSLY WRITTEN AND VERBAL MATTERS, AND LEGAL ACTION WILL COMMENCE. THE ISSUES LISTED IN THIS TABLE ARE ONLY THE RECENT (LAST 3 MONTHS), AND DO NOT INCLUDE THE MONTAGE OF PROBLEMS IN THE LAST 2 YEARS, SOME OF WHICH ARE MENTIONED IN THE COMMENTS SECTION.
NHTSA ODI #728526
Mileage unknown · Jul 17, 2000
Equipment
TOOK VEHICLE TO DEALER TO HAVE PROBLEM RESOLVED, GAVE INFO ON TSB ABOUT PROBLEM ABSOLUTELLY NOTHING WAS DONE TO VEHICLE. CABLE ASSEMBLY AT BLOWER RESISTOR MELTED WHILE A/C WAS RUNNING EARLIER THIS AFTERNOON. WILL DEFINITELY HAVE A DISCUSSION WITH DEALER TOMORROW. THERE ARE TWO TSB'S ON BLOWER MOTORS IN THE 98 CONTOUR. WHY DO…
Read full complaint
TOOK VEHICLE TO DEALER TO HAVE PROBLEM RESOLVED, GAVE INFO ON TSB ABOUT PROBLEM ABSOLUTELLY NOTHING WAS DONE TO VEHICLE. CABLE ASSEMBLY AT BLOWER RESISTOR MELTED WHILE A/C WAS RUNNING EARLIER THIS AFTERNOON. WILL DEFINITELY HAVE A DISCUSSION WITH DEALER TOMORROW. THERE ARE TWO TSB'S ON BLOWER MOTORS IN THE 98 CONTOUR. WHY DOESN'T THE DEALERS KNOW HOW TO CHECK TO SEE IF THEY APPLY TO A PARTICULAR VEHICLE. I INFORMED THE ASST SERVICE MANAGER OF THE TSB'S ON MY VEHICLE 99M07 & 99M08 BOTH OF WHICH DEAL WITH BLOWER AND BLOWER RESISTOR PROBLEMS. SEEMS MY TRIP TO GARY SMITH THIS DATE WAS A WASTE OF TIME AND ALMOST A WASTE OF MY VEHICLE. THERE COULD HAVE EASILY BEEN AN ELECTRICAL FIRE DUE TO THE OVERHEATING CABLE ASSEMBLY AND BLOWER RESISTOR. MAYBE NHTSA CAN HELP RESOLVE THIS PROBLEM BEFORE SOMEONE GETS HURT!!!!*AK
NHTSA ODI #725598
Mileage unknown · Dec 20, 1999
EquipmentService Brakes, HydraulicTires
CONSUMER SMELLS A MUSTY ODOR WHEN USING THE A/C. NLM
NHTSA ODI #550028
Mileage unknown · Nov 4, 1999
EquipmentSuspension
VEHICLE PULLS TO THE LEFT & THE AIR CONDITIONING UNIT HAS A MUSK SMELL. *YC
VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT AT THE KANSAS CITY ASSEMBLY PLANT AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND THE DISTRICT OF COLUMBIA. THE FRONT COIL SPRINGS MAY FRACTURE AS A RESULT OF CORROSION IN HIGH CORROSION ENVIRONMENTS. DEPENDING ON THE LOCATION OF THE FRACTURE, A BROKEN SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.
Consequence & remedy
Consequence: SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.
Remedy: DEALERS WILL INSTALL SPRING CATCHER BRACKETS. OWNER NOTIFICATION BEGAN OCTOBER 23, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
ON CERTAIN MY 1996-1998 PASSENGER VEHICLES BUILT AT THE KANSAS CITY, CUAUTITLAN ASSEMBLY PLANTS OR ON MY 1999 PASSENGER VEHCLES BUILT AT THE AUTOMOTIVE ALLIANCE INTERNATIONAL ASSEMBLY PLANTS, THE ROUGH SURFACE OF THE HEATER BLOWER RESISTOR'S STAINLESS STEEL BLADES CAN DAMAGE THE COPPER SURFACE OF THE WIRING HARNESS CONNECTOR. THE DAMAGE COULD, OVER TIME, CAUSE INCREASED RESISTANCE IN THE CONNECTOR AND, DUE TO SUBSEQUENT TERMINAL RELAXATION, RESULT IN AN OPEN CIRCUIT CONDITION.
Consequence & remedy
Consequence: THE OPEN CIRCUIT COULD LEAD TO ELECTRICAL ARCING THAT COULD MELT THE CONNECTOR HOUSING MATERIAL CREASING THE POTENTIAL FOR A FIRE.
Remedy: DEALERS WILL INSTALL A NEW HEATER BLOWER RESISTOR AND A NEW WIRE JUMPER HARNESS. OWNER NOTIFICATION BEGAN AUGUST 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
VEHICLE DESCRIPTION: BI-FUEL VEHICLES. THESE VEHICLES MAY HAVE A FUEL TANK FILLER PIPE GROMMET THAT COULD HAVE BEEN DAMAGED DURING THE INSTALLATION OF THE BI-FUEL SYSTEM. IF THE GROMMET IS DAMAGED, FUEL COULD LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE. DEALERS WILL REPLACE THE FUEL TANK FILLER PIPE GROMMET.
Consequence & remedy
Consequence: IF THE GROMMET IS DAMAGED, FUEL COULD LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK FILLER PIPE GROMMET.
VEHICLE DESCRIPTION: PASSENGER VEHICLES NOT EQUIPPED WITH THE ANTI-LOCK BRAKING SYSTEM (ABS). A PRESSURE CONSCIOUS REDUCING VALVE (PCRV) IN THE REAR BRAKES MAY BE SUBJECT TO CORROSION AND RESULT IN MALFUNCTION, WHEN OPERATED IN AREAS THAT USE SALT COMPOUNDS ON THE ROADWAY FOR DE-ICING OR DUST CONTROL.
Consequence & remedy
Consequence: IF BOTH PCRV'S MALFUNCTION, VEHICLE HANDLING COULD BE ADVERSELY AFFECTED DURING BRAKING AS A RESULT OF THE REAR WHEELS LOCKING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL IMPROVED PCRV'S IN THE REAR BRAKE SYSTEM. THIS RECALL WAS EXPANDED IN SEPTEMBER 2000 TO INCLUDE 1999 AND 2000 FORD CONTOUR, MERCURY MYSTIQUE AND COUGAR VEHICLES.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSOR WIRING PIGTAIL INSULATION CAN BECOME BRITTLE AND CRACK OVER TIME DUE TO ACCUMULATION OF WATER IN THE PIGTAIL PROTECTIVE CONVOLUTE IN COMBINATION WITH HIGH UNDERHOOD TEMPERATURES RELATED TO THE ROUTING OF THE WIRING PIGTAIL NEAR THE RADIATOR. THIS CAN RESULT IN ENVIRONMENTAL STRESS CRACKING OF THE INSULATION.
Consequence & remedy
Consequence: IN SOME CASES, THE AIR BAG WARNING LIGHT CAN ILLUMINATE AND THE AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM DISABLED.
Remedy: DEALERS WILL INSTALL AIR BAG SENSORS WITH REVISED WIRING INSULATION. IN ADDITION, VEHICLES WHICH HAVE THE AIR BAG WARNING LIGHT ILLUMINATED WILL HAVE A NEW AIR BAG DIAGNOSTIC MONITOR INSTALLED.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ACCELERATOR CABLE MAY HAVE BEEN MANUFACTURED WITH A BURR ON OR NEAR THE END OF THE CABLE SLEEVE INTERIOR. THIS BURR COULD FRAY THE CORE WIRE RESULTING IN THE ACCELERATOR NOT RETURNING TO IDLE WHEN THE ACCELERATOR IS RELEASED.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN THE THROTTLE STICKING, BINDING, OR CAUSING HIGH ENGINE RPM.
Remedy: DEALERS WILL INSTALL A REVISED ACCELERATOR CABLE THAT HAS A FLARED CONDUIT SLEEVE END AND MOLDED ON END FITTING.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TERMINALS AT THE HEADLIGHT SWITCH AND WIRING HARNESS CONNECTOR CAN EXPERIENCE HEAT DAMAGE AS A RESULT OF OVERHEATING.
Consequence & remedy
Consequence: THE DAMAGE COULD RESULT IN DISTORTION OF THE TERMINAL CAUSING AN OPEN CIRCUIT IN THE INSTRUMENT PANEL ILLUMINATION, PARKING LAMP, AND TAIL LAMP CIRCUITS.
Remedy: DEALERS WILL INSTALL A HEADLAMP SWITCH WIRING CONNECTOR CONTAINING BRONZE TERMINALS AND AN INSPECTION, AND REPLACEMENT IF NECESSARY, OF THE HEADLAMP SWITCH.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FLOOR SHIFT AUTOMATIC TRANSMISSION CONTROL CAN BE DAMAGED IF SUBJECTED TO CERTAIN INTERIOR CLEANING PRODUCTS. THE GEAR POSITION INDICATOR CAN DETERIORATE AND NOT CORRECTLY INDICATE THE ACTUAL GEAR POSITION.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INCORRECT GEAR SELECTION.
Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FLOOR SHIFT CONTROL.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TEXT AND/OR GRAPHICS FOR THE VEHICLE HEADLAMP AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES ARE NOT SUFFICIENTLY CLEAR. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY BE CONFUSED BY THE AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES CAUSING THE HEADLAMPS TO BE IMPROPERLY AIMED.
Remedy: OWNER GUIDES CONTAINING REVISED AIMING INSTRUCTIONS WILL BE MAILED TO OWNERS OF THESE VEHICLES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7
RQ02006 · Incorrect Gear Indication
Opened Feb 26, 2002 · Closed Sep 12, 2002
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
EA01001 · Blower Switch/resistor Or Wiring Harness
Opened Jan 5, 2001 · Closed Jul 31, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
Additional source detail variants (2)
Electrical System
There is no summary currently available
Electrical System
There is no summary currently available
EA00025 · Fuel Expulsion During Refueling
Opened Oct 4, 2000 · Closed Jan 25, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE00027 · Fuel Expulsion During Refueling
Opened Jul 10, 2000 · Closed Oct 4, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE00023 · Blower Switch/resistor Or Wiring Harness
Opened Jun 14, 2000 · Closed Jan 5, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ99019 · Various Intermittent Electrical Issues
Opened Sep 15, 1999 · Closed Mar 7, 2001
Status: closed (inferred from source dates) · Unknown Or Other
There is no summary currently available
SQ98002 · Fuel Gauge Does Not Read Below 1/4
Opened Jan 27, 1998 · Closed Jul 31, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
FORD'S SERVICE BULLETIN DATED DECEMBER 8, 1997, POINTS OUT THAT THE FUEL GAUGE WILL NOT READ ABOVE 3/4 TANK OR BELOW 1/4 TANK OF FUEL.THE ERRONEOUS FUEL GAUGE READING WILL INDICATE SIGNIFICANTLY MORE FUEL RESERVE THAN ACTUALLY PRESENT IN THE FUEL TANK.ODI HAS ONE COMPLAINT WHERE THE DRIVER ALLEGED THAT HIS VEHICLE RAN OUT OF GAS DUE TO A FALSE FUEL GAUGE READING.THIS INVESTIGATION WASTO ASCERTAIN FACTS CONCERNING THE PROBLEM EXPERIENCE, SCOPE, AND RATIONAL FOR ELECTING NOT TO CONDUCT A SAFETY COMPAIGN.
1998 Ford Contour Problems, Complaints & Recalls | Skip That Year
Illustration