NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
130 reportsClear category filter80,250 miles · Jul 26, 2004
Electrical System
CONSUMER STATED THAT THE TEMPERATURE GAUGE SYSTEM WAS DEFECTIVE. VEHICLE LOST POWER, AND BEGAN TO SMOKE. CONSUMER WAS TOLD THAT THE WIRING OF THE TEMPERATURE GAUGES WAS DONE INCORRECTLY. CONSUMER CONTACTED THE MANUFACTURER, AND WAS TOLD THAT THERE WAS NOTHING THAT THEY COULD DO.*AK THE VEHICLE'S ENGINE WAS DAMAGED AND HAD TO B…
Read full complaint
CONSUMER STATED THAT THE TEMPERATURE GAUGE SYSTEM WAS DEFECTIVE. VEHICLE LOST POWER, AND BEGAN TO SMOKE. CONSUMER WAS TOLD THAT THE WIRING OF THE TEMPERATURE GAUGES WAS DONE INCORRECTLY. CONSUMER CONTACTED THE MANUFACTURER, AND WAS TOLD THAT THERE WAS NOTHING THAT THEY COULD DO.*AK THE VEHICLE'S ENGINE WAS DAMAGED AND HAD TO BE REPLACED AS A RESULT OF THE OVERHEATING. *NM
NHTSA ODI #10079966
53,000 miles · Jun 10, 2004
Electrical SystemService Brakes, Hydraulic
1) A/C BLOWER SHUT OFF AND UPON INVESTIGATION A 60 AMP FUSE BROKE UNDER THE FUSE BOX IN THE FRONT OF THE CAR UNDER THE ENGINE HOOD WERE DAMAGED. AND FURTHER INSPECTION SHOWED SEVERAL OPEN WIRES COMING FROM THE BATTERY AND ONE COMMING FROM THE FUSE BOX WHICH IS BELIEVED TO HAVE CAUSED THE FUSE TO BREAK. 2) NOTIFIED BY 2 DIFFER…
Read full complaint
1) A/C BLOWER SHUT OFF AND UPON INVESTIGATION A 60 AMP FUSE BROKE UNDER THE FUSE BOX IN THE FRONT OF THE CAR UNDER THE ENGINE HOOD WERE DAMAGED. AND FURTHER INSPECTION SHOWED SEVERAL OPEN WIRES COMING FROM THE BATTERY AND ONE COMMING FROM THE FUSE BOX WHICH IS BELIEVED TO HAVE CAUSED THE FUSE TO BREAK. 2) NOTIFIED BY 2 DIFFERENT AUTO-ELECTRICAL REPAIR SHOPS THEY HAD SEEN SIMULAR DAMAGE AND INFORMED ME OFF THE COSTS OF A REPLACEMENT WIRING HARNESS AND LABOR WHICH RANGED FROM $3800 - $4400. CHECKING OTHER VARIOUS WEB SITES SHOWED A LOT MORE PEOPLE WITH THE SAME PROBLEMS WHICH RANGED FROM FIRES TO HAVING TO DRIVE WITH BROKEN FUSES OR HAVING TO PAY HIGH AMOUNTS TO REPLACE IT. 3) DOING PREVENTATIVE MAINTENTENCE BY CLEANING AREA AND SPRAYING A HIGH BASE IN THE AREA TO PREVENT FURTHER DAMAGE CAUSED BY EXPOSED WIRES TO THE ELEMENTS ON A WEEKLY BASES TILL I CAN AFFORD SUCH A LARGE REPAIR AND NOT REPLACING A FUSE WHICH CONTROLS MY BLOWER AND ABS. *AK
NHTSA ODI #10075148
93,000 miles · May 17, 2004
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
INTERMITTENTLY WHEN THE GAS PEDAL WAS APPLIED, THE VEHICLE FAILED TO ACCELERATE. THIS OCCURRED BECAUSE OF AN OBSTRUCTION IN THE FLOW OF FUEL TO THE ENGINE. THE DEALERSHIP HAS SERVICED THE VEHICLE 5 TIMES. THEY HAVE REPLACED THE FUEL PUMP, THE FILTER AND THE OXYGEN SENSOR. THE PROBLEM STILL EXIST. THE DEALERSHIP REFUSED TO SERVIC…
Read full complaint
INTERMITTENTLY WHEN THE GAS PEDAL WAS APPLIED, THE VEHICLE FAILED TO ACCELERATE. THIS OCCURRED BECAUSE OF AN OBSTRUCTION IN THE FLOW OF FUEL TO THE ENGINE. THE DEALERSHIP HAS SERVICED THE VEHICLE 5 TIMES. THEY HAVE REPLACED THE FUEL PUMP, THE FILTER AND THE OXYGEN SENSOR. THE PROBLEM STILL EXIST. THE DEALERSHIP REFUSED TO SERVICE THE VEHICLE ANYMORE BECAUSE THEY INDICATED THEY HAVE DONE ALL THEY COULD DO TO CORRECT THIS PROBLEM. *NM THE VEHICLE LEAKED OIL OVER THE ENTIRE ENGINE, THE FUEL PRESSURE DROPPED WHEN THE VEHICLE WAS DRIVEN ON MOUNTAINOUS AREAS, A SHORT WAS FOUND, AND WIRES WERE FOUND CHAFFED. *SC *JB
NHTSA ODI #10065523
Mileage unknown · Apr 4, 2004
Electrical SystemFire
FORD REFUSED TO HONOR RECALL CAMPAIGN #01V230000 MANUFACTURER'S CAMPAIGN #01S22 CLAIMING "WARRANTY HAD EXPIRED". *NM
NHTSA ODI #10064514
74,000 miles · Mar 15, 2004
Electrical System
CONSUMER RECEIVED RECALL 99MO3 REGARDING WIRING HARNESS, RECALL ONLY AFFECTED VEHICLES FROM 1995-1997. THE INSULATION ON THE WIRING HARNESS DETERIORATED, CAUSING THE SYSTEM TO SHORT OUT. DEALER WILL NOT FIX THE PROBLEM FREE OF CHARGE.*AK
NHTSA ODI #10063185
74,000 miles · Mar 8, 2004
Electrical System
I HAVE A 1998 FORD CONTOUR SVT SITTING MY DRIVEWAY WITH 74,000 MILES ON IT WHICH WILL NOT RUN BECAUSE IT HAS A DEFECTIVE WIRING HARNESS. I AM AWARE THAT THE 1995 THOURGH 1997 MODELS HAD A FACTORY RECALL BECAUSE THE WIRING HARNESS INSULATION FAILED. THIS CAR IS A 1998 MODEL THAT WAS BUILT IN MAY OF 1997 AND THE INSULATION IS FALL…
Read full complaint
I HAVE A 1998 FORD CONTOUR SVT SITTING MY DRIVEWAY WITH 74,000 MILES ON IT WHICH WILL NOT RUN BECAUSE IT HAS A DEFECTIVE WIRING HARNESS. I AM AWARE THAT THE 1995 THOURGH 1997 MODELS HAD A FACTORY RECALL BECAUSE THE WIRING HARNESS INSULATION FAILED. THIS CAR IS A 1998 MODEL THAT WAS BUILT IN MAY OF 1997 AND THE INSULATION IS FALLING OFF THE WIRING IN THE ENGINE COMPARTMENT. THE CAR WILL NOT RUN AT THIS TIME DUE TO THE FACT THAT THIS WIRING HAS CAUSED A PROBLEM SHORTING OUT. IT IS ALSO HAS MAJOR PROTENTIAL TO BE A LIFE THREATENING FIRE HAZZARD. *AK
NHTSA ODI #10060726
119,700 miles · Feb 26, 2004
Electrical SystemExterior Lighting
DEALERSHIP REPLACED THE BRONZE TERMINALS, BUT REFUSED TO REPLACE THE HEADLIGHT SWITCH AS STATED IN THE HEADLIGHT SWITCH/WIRE HARNESS RECALL 99V103000. INSTRUMENT PANEL LIGHTS AND HEADLIGHTS WERE NOT WORKING PROPERLY. *AK *MR
NHTSA ODI #10056114
80,500 miles · Feb 5, 2004
Electrical SystemFire
THE VEHICLE'S BLOWER SWITCH CAUGHT FIRE AROUND THE STEERING COLUMN. *NM
NHTSA ODI #10057576
79,000 miles · Jan 22, 2004
Electrical SystemExterior Lighting
VEHICLE IS WITHOUT DASH LIGHTS AND TAIL LIGHTS. DEALERSHIP WILL NOT HONOR RECALL. *AK
NHTSA ODI #10055708
63,000 miles · Oct 20, 2003
Electrical SystemEngine And Engine CoolingParking Brake
THIS CAR HAS BEEN NOTHING BUT PROBLEMS, SPRINGS, BRAKES LAST 4 MONTHS,WATER PUMPS WENT AT 63,000, TIRES WEAR OUT IN LESS THAN A YEAR, TEMPERATURE GAUGES DO NOT READ RIGHT. ENGINE RACES, SOLENOID WENT....VERY EXPENSIVE TO FIX. I DO NOT UNDERSTAND WHY EVERYONE IS HAVING THE SAME PROBLEMS BUT NO HELP? *LA
NHTSA ODI #10043239
Official recalls
9Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT AT THE KANSAS CITY ASSEMBLY PLANT AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND THE DISTRICT OF COLUMBIA. THE FRONT COIL SPRINGS MAY FRACTURE AS A RESULT OF CORROSION IN HIGH CORROSION ENVIRONMENTS. DEPENDING ON THE LOCATION OF THE FRACTURE, A BROKEN SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.
Consequence & remedy
Consequence: SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.
Remedy: DEALERS WILL INSTALL SPRING CATCHER BRACKETS. OWNER NOTIFICATION BEGAN OCTOBER 23, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Jul 9, 2001
ON CERTAIN MY 1996-1998 PASSENGER VEHICLES BUILT AT THE KANSAS CITY, CUAUTITLAN ASSEMBLY PLANTS OR ON MY 1999 PASSENGER VEHCLES BUILT AT THE AUTOMOTIVE ALLIANCE INTERNATIONAL ASSEMBLY PLANTS, THE ROUGH SURFACE OF THE HEATER BLOWER RESISTOR'S STAINLESS STEEL BLADES CAN DAMAGE THE COPPER SURFACE OF THE WIRING HARNESS CONNECTOR. THE DAMAGE COULD, OVER TIME, CAUSE INCREASED RESISTANCE IN THE CONNECTOR AND, DUE TO SUBSEQUENT TERMINAL RELAXATION, RESULT IN AN OPEN CIRCUIT CONDITION.
Consequence & remedy
Consequence: THE OPEN CIRCUIT COULD LEAD TO ELECTRICAL ARCING THAT COULD MELT THE CONNECTOR HOUSING MATERIAL CREASING THE POTENTIAL FOR A FIRE.
Remedy: DEALERS WILL INSTALL A NEW HEATER BLOWER RESISTOR AND A NEW WIRE JUMPER HARNESS. OWNER NOTIFICATION BEGAN AUGUST 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Oct 30, 2000
VEHICLE DESCRIPTION: BI-FUEL VEHICLES. THESE VEHICLES MAY HAVE A FUEL TANK FILLER PIPE GROMMET THAT COULD HAVE BEEN DAMAGED DURING THE INSTALLATION OF THE BI-FUEL SYSTEM. IF THE GROMMET IS DAMAGED, FUEL COULD LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE. DEALERS WILL REPLACE THE FUEL TANK FILLER PIPE GROMMET.
Consequence & remedy
Consequence: IF THE GROMMET IS DAMAGED, FUEL COULD LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK FILLER PIPE GROMMET.
Mar 9, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES NOT EQUIPPED WITH THE ANTI-LOCK BRAKING SYSTEM (ABS). A PRESSURE CONSCIOUS REDUCING VALVE (PCRV) IN THE REAR BRAKES MAY BE SUBJECT TO CORROSION AND RESULT IN MALFUNCTION, WHEN OPERATED IN AREAS THAT USE SALT COMPOUNDS ON THE ROADWAY FOR DE-ICING OR DUST CONTROL.
Consequence & remedy
Consequence: IF BOTH PCRV'S MALFUNCTION, VEHICLE HANDLING COULD BE ADVERSELY AFFECTED DURING BRAKING AS A RESULT OF THE REAR WHEELS LOCKING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL IMPROVED PCRV'S IN THE REAR BRAKE SYSTEM. THIS RECALL WAS EXPANDED IN SEPTEMBER 2000 TO INCLUDE 1999 AND 2000 FORD CONTOUR, MERCURY MYSTIQUE AND COUGAR VEHICLES.
Sep 8, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSOR WIRING PIGTAIL INSULATION CAN BECOME BRITTLE AND CRACK OVER TIME DUE TO ACCUMULATION OF WATER IN THE PIGTAIL PROTECTIVE CONVOLUTE IN COMBINATION WITH HIGH UNDERHOOD TEMPERATURES RELATED TO THE ROUTING OF THE WIRING PIGTAIL NEAR THE RADIATOR. THIS CAN RESULT IN ENVIRONMENTAL STRESS CRACKING OF THE INSULATION.
Consequence & remedy
Consequence: IN SOME CASES, THE AIR BAG WARNING LIGHT CAN ILLUMINATE AND THE AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM DISABLED.
Remedy: DEALERS WILL INSTALL AIR BAG SENSORS WITH REVISED WIRING INSULATION. IN ADDITION, VEHICLES WHICH HAVE THE AIR BAG WARNING LIGHT ILLUMINATED WILL HAVE A NEW AIR BAG DIAGNOSTIC MONITOR INSTALLED.
Jul 20, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ACCELERATOR CABLE MAY HAVE BEEN MANUFACTURED WITH A BURR ON OR NEAR THE END OF THE CABLE SLEEVE INTERIOR. THIS BURR COULD FRAY THE CORE WIRE RESULTING IN THE ACCELERATOR NOT RETURNING TO IDLE WHEN THE ACCELERATOR IS RELEASED.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN THE THROTTLE STICKING, BINDING, OR CAUSING HIGH ENGINE RPM.
Remedy: DEALERS WILL INSTALL A REVISED ACCELERATOR CABLE THAT HAS A FLARED CONDUIT SLEEVE END AND MOLDED ON END FITTING.
May 5, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TERMINALS AT THE HEADLIGHT SWITCH AND WIRING HARNESS CONNECTOR CAN EXPERIENCE HEAT DAMAGE AS A RESULT OF OVERHEATING.
Consequence & remedy
Consequence: THE DAMAGE COULD RESULT IN DISTORTION OF THE TERMINAL CAUSING AN OPEN CIRCUIT IN THE INSTRUMENT PANEL ILLUMINATION, PARKING LAMP, AND TAIL LAMP CIRCUITS.
Remedy: DEALERS WILL INSTALL A HEADLAMP SWITCH WIRING CONNECTOR CONTAINING BRONZE TERMINALS AND AN INSPECTION, AND REPLACEMENT IF NECESSARY, OF THE HEADLAMP SWITCH.
Sep 18, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FLOOR SHIFT AUTOMATIC TRANSMISSION CONTROL CAN BE DAMAGED IF SUBJECTED TO CERTAIN INTERIOR CLEANING PRODUCTS. THE GEAR POSITION INDICATOR CAN DETERIORATE AND NOT CORRECTLY INDICATE THE ACTUAL GEAR POSITION.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INCORRECT GEAR SELECTION.
Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FLOOR SHIFT CONTROL.
Feb 10, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TEXT AND/OR GRAPHICS FOR THE VEHICLE HEADLAMP AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES ARE NOT SUFFICIENTLY CLEAR. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY BE CONFUSED BY THE AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES CAUSING THE HEADLAMPS TO BE IMPROPERLY AIMED.
Remedy: OWNER GUIDES CONTAINING REVISED AIMING INSTRUCTIONS WILL BE MAILED TO OWNERS OF THESE VEHICLES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7RQ02006 · Incorrect Gear Indication
Opened Feb 26, 2002 · Closed Sep 12, 2002
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
EA01001 · Blower Switch/resistor Or Wiring Harness
Opened Jan 5, 2001 · Closed Jul 31, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
Additional source detail variants (2)
Electrical System
There is no summary currently available
Electrical System
There is no summary currently available
EA00025 · Fuel Expulsion During Refueling
Opened Oct 4, 2000 · Closed Jan 25, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE00027 · Fuel Expulsion During Refueling
Opened Jul 10, 2000 · Closed Oct 4, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE00023 · Blower Switch/resistor Or Wiring Harness
Opened Jun 14, 2000 · Closed Jan 5, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ99019 · Various Intermittent Electrical Issues
Opened Sep 15, 1999 · Closed Mar 7, 2001
Status: closed (inferred from source dates) · Unknown Or Other
There is no summary currently available
SQ98002 · Fuel Gauge Does Not Read Below 1/4
Opened Jan 27, 1998 · Closed Jul 31, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
FORD'S SERVICE BULLETIN DATED DECEMBER 8, 1997, POINTS OUT THAT THE FUEL GAUGE WILL NOT READ ABOVE 3/4 TANK OR BELOW 1/4 TANK OF FUEL.THE ERRONEOUS FUEL GAUGE READING WILL INDICATE SIGNIFICANTLY MORE FUEL RESERVE THAN ACTUALLY PRESENT IN THE FUEL TANK.ODI HAS ONE COMPLAINT WHERE THE DRIVER ALLEGED THAT HIS VEHICLE RAN OUT OF GAS DUE TO A FALSE FUEL GAUGE READING.THIS INVESTIGATION WASTO ASCERTAIN FACTS CONCERNING THE PROBLEM EXPERIENCE, SCOPE, AND RATIONAL FOR ELECTING NOT TO CONDUCT A SAFETY COMPAIGN.
Illustration