ELECTRICAL SMELL AND SMOKE CAME FROM DASH AREA. WIFE AND 2 CHILDREN ABANDONED CAR. CAR WAS SERVICED AT DEALER IN GEORGIA. TWO DAYS AFTER FIRST REPAIR SAME ELECTRICAL SMELL AND SMOKE. WIFE AND TWO CHILDREN ABONDONED CAR FOR A SECOND TIME. WIFE IS CONCERNED OVER CHILDRENS SAFETY. TAKEN TO SECOND DEALER. SERVICE MANAGER OBSERVED PR…
Read full complaint
ELECTRICAL SMELL AND SMOKE CAME FROM DASH AREA. WIFE AND 2 CHILDREN ABANDONED CAR. CAR WAS SERVICED AT DEALER IN GEORGIA. TWO DAYS AFTER FIRST REPAIR SAME ELECTRICAL SMELL AND SMOKE. WIFE AND TWO CHILDREN ABONDONED CAR FOR A SECOND TIME. WIFE IS CONCERNED OVER CHILDRENS SAFETY. TAKEN TO SECOND DEALER. SERVICE MANAGER OBSERVED PROBLEM WHILE HE WAS DRIVING VEHICLE. SMOKE WAS COMING FROM DASH. DEALER QUICKLY OPENED GLOVE BOX. VEHICLE WAS REPAIRED AT NO CHARGE THE SECOND TIME. PROBLEM WAS WITH WIRING HARNESS. NEITHER THE DEALER NOR FORD HAS INFORMED ME OF ROOT CAUSE. AM CONCERNED PROBLEM CAN AGAIN OCCUR WITHOUT WARNING. HAVE READ SIMILAR COMPLAINTS TO NHTSA. DESIRE TO KNOW ROOT CAUSE, AND FIX TO ASSURE SAFETY OF FAMILY.
NHTSA ODI #711505
Mileage unknown · Sep 2, 1999
Electrical System
WHENEVER IGNITION IS TURNED OFF, IT WOULD LOCK UP. KEY WOULD STILL BE IN IGNITION SWITCH. HAD TURNED TO LOCK POSITION WHILE NOTHING WAS IN USE AT THE TIME. BEEN TO DEALER 4 OR 5 TIMES FOR PROBLEM, BUT MECHANIC COULD NOT LOCATE CAUSE OF PROBLEM. *AK
NHTSA ODI #846529
Mileage unknown · Aug 30, 1999
Electrical SystemFuel System, OtherVehicle Speed Control
UNABLE TO FILL TANK UP WITH GAS DUE TO A DEFECTIVE FUEL TANK PRESSURE SENSOR. *YC
NHTSA ODI #548209
Mileage unknown · Aug 26, 1999
Electrical SystemFire
WHILE DRIVING DASH CAUGHT FIRE RIGHT BEHIND THE GLOVE COMPARTMENT. FIRE WAS ELECTRICAL. DEALER REPLACED WIRING HARNESS AND 3 RESISTOR BOARDS. *AK
NHTSA ODI #845921
Mileage unknown · Aug 12, 1999
Electrical SystemSteering
WHENEVER THE AUTOMOBILE IS DRIVEN THROUGH A PUDDLE OF WATER OR UPON PROLONGED DRIVING ON A WET ROAD, THE POWER STEERING LOCKS UP. WHEN THIS OCCURS, THE POWER STEERING REMAINS LOCKED FOR SEVERAL SECONDS UP TO OVER ONE MINUTE BEFORE RETURNING TO NORMAL. THESE CONDITIONS ALSO CAUSE THE "BATTERY" LIGHT TO ILLUMINATE. I RETURNED…
Read full complaint
WHENEVER THE AUTOMOBILE IS DRIVEN THROUGH A PUDDLE OF WATER OR UPON PROLONGED DRIVING ON A WET ROAD, THE POWER STEERING LOCKS UP. WHEN THIS OCCURS, THE POWER STEERING REMAINS LOCKED FOR SEVERAL SECONDS UP TO OVER ONE MINUTE BEFORE RETURNING TO NORMAL. THESE CONDITIONS ALSO CAUSE THE "BATTERY" LIGHT TO ILLUMINATE. I RETURNED THE VEHICLE TO THE DEALER IN APPROXIMATELY JUNE 1998, BUT THEIR FIX ACTION "REPLACING A HEADLIGHT WIRING ASSEMBLY" DID NOT APPEAR TO ADDRESS THE PROBLEM AND THE PROBLEM REOCCURRED IMMEDIATELY THE NEXT TIME THAT THE AUTOMBILE WAS DRIVEN ON A RAINY DAY. UPON RETURNING THE AUTOMOBILE A SECOND TME, I WAS INFORMED BY BOTH A SERVICE TECHNICIAN AND A SERVICE MANAGER THAT THIS IS A PROBLEM THAT THE FORD COMPANY IS AWARE OF BUT IS MAKING NO ATTEMPT TO INFORM THE AUTOMOBILE OWNERS UNTIL THEY ACTUALLY EXPERIENCE THE PROBLEM.
NHTSA ODI #709906
Mileage unknown · Jul 20, 1999
Electrical System
CAR WILL NOT START. *AK
NHTSA ODI #708859
Mileage unknown · Jul 15, 1999
Electrical SystemEquipmentExterior Lighting
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #708675
Mileage unknown · Jul 14, 1999
Electrical System
CONSUMER TURNED AIR CONDITIONER ON AND SMOKE CAME FROM KNOB AREA. INSIDE OF KNOB HAD MELTED CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS. *AK
NHTSA ODI #842364
Mileage unknown · Jun 30, 1999
Electrical System
THER E IS A PROBLEM WITHIN THE ELECTRICAL SYSTEM WHICH CAUSES SIGNAL AND BRAKE LIGHTS TO MALFUNCTION. DEALER IS AWARE OF THE PROBLEM, AND VEHICLE HAS BEEN AT DEALER FOUR TIMES FOR REPAIRS. *AK
NHTSA ODI #841527
Mileage unknown · Apr 19, 1999
Electrical System
WHEN THE HORN IS IN USE IT FAILS TO WORK PROPERLY WHEN PRESSED. HAS TAKEN VEHICLE TO DEALER FOR REPAIRS, WHICH WERE NOT DONE. HAD CONTACTED THE DEALER, AGAIN, AND WAS INFORMED THAT PARTS HAD TO BE ORDERED. *AK
VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT AT THE KANSAS CITY ASSEMBLY PLANT AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND THE DISTRICT OF COLUMBIA. THE FRONT COIL SPRINGS MAY FRACTURE AS A RESULT OF CORROSION IN HIGH CORROSION ENVIRONMENTS. DEPENDING ON THE LOCATION OF THE FRACTURE, A BROKEN SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.
Consequence & remedy
Consequence: SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.
Remedy: DEALERS WILL INSTALL SPRING CATCHER BRACKETS. OWNER NOTIFICATION BEGAN OCTOBER 23, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
ON CERTAIN MY 1996-1998 PASSENGER VEHICLES BUILT AT THE KANSAS CITY, CUAUTITLAN ASSEMBLY PLANTS OR ON MY 1999 PASSENGER VEHCLES BUILT AT THE AUTOMOTIVE ALLIANCE INTERNATIONAL ASSEMBLY PLANTS, THE ROUGH SURFACE OF THE HEATER BLOWER RESISTOR'S STAINLESS STEEL BLADES CAN DAMAGE THE COPPER SURFACE OF THE WIRING HARNESS CONNECTOR. THE DAMAGE COULD, OVER TIME, CAUSE INCREASED RESISTANCE IN THE CONNECTOR AND, DUE TO SUBSEQUENT TERMINAL RELAXATION, RESULT IN AN OPEN CIRCUIT CONDITION.
Consequence & remedy
Consequence: THE OPEN CIRCUIT COULD LEAD TO ELECTRICAL ARCING THAT COULD MELT THE CONNECTOR HOUSING MATERIAL CREASING THE POTENTIAL FOR A FIRE.
Remedy: DEALERS WILL INSTALL A NEW HEATER BLOWER RESISTOR AND A NEW WIRE JUMPER HARNESS. OWNER NOTIFICATION BEGAN AUGUST 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
VEHICLE DESCRIPTION: BI-FUEL VEHICLES. THESE VEHICLES MAY HAVE A FUEL TANK FILLER PIPE GROMMET THAT COULD HAVE BEEN DAMAGED DURING THE INSTALLATION OF THE BI-FUEL SYSTEM. IF THE GROMMET IS DAMAGED, FUEL COULD LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE. DEALERS WILL REPLACE THE FUEL TANK FILLER PIPE GROMMET.
Consequence & remedy
Consequence: IF THE GROMMET IS DAMAGED, FUEL COULD LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK FILLER PIPE GROMMET.
VEHICLE DESCRIPTION: PASSENGER VEHICLES NOT EQUIPPED WITH THE ANTI-LOCK BRAKING SYSTEM (ABS). A PRESSURE CONSCIOUS REDUCING VALVE (PCRV) IN THE REAR BRAKES MAY BE SUBJECT TO CORROSION AND RESULT IN MALFUNCTION, WHEN OPERATED IN AREAS THAT USE SALT COMPOUNDS ON THE ROADWAY FOR DE-ICING OR DUST CONTROL.
Consequence & remedy
Consequence: IF BOTH PCRV'S MALFUNCTION, VEHICLE HANDLING COULD BE ADVERSELY AFFECTED DURING BRAKING AS A RESULT OF THE REAR WHEELS LOCKING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL IMPROVED PCRV'S IN THE REAR BRAKE SYSTEM. THIS RECALL WAS EXPANDED IN SEPTEMBER 2000 TO INCLUDE 1999 AND 2000 FORD CONTOUR, MERCURY MYSTIQUE AND COUGAR VEHICLES.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSOR WIRING PIGTAIL INSULATION CAN BECOME BRITTLE AND CRACK OVER TIME DUE TO ACCUMULATION OF WATER IN THE PIGTAIL PROTECTIVE CONVOLUTE IN COMBINATION WITH HIGH UNDERHOOD TEMPERATURES RELATED TO THE ROUTING OF THE WIRING PIGTAIL NEAR THE RADIATOR. THIS CAN RESULT IN ENVIRONMENTAL STRESS CRACKING OF THE INSULATION.
Consequence & remedy
Consequence: IN SOME CASES, THE AIR BAG WARNING LIGHT CAN ILLUMINATE AND THE AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM DISABLED.
Remedy: DEALERS WILL INSTALL AIR BAG SENSORS WITH REVISED WIRING INSULATION. IN ADDITION, VEHICLES WHICH HAVE THE AIR BAG WARNING LIGHT ILLUMINATED WILL HAVE A NEW AIR BAG DIAGNOSTIC MONITOR INSTALLED.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ACCELERATOR CABLE MAY HAVE BEEN MANUFACTURED WITH A BURR ON OR NEAR THE END OF THE CABLE SLEEVE INTERIOR. THIS BURR COULD FRAY THE CORE WIRE RESULTING IN THE ACCELERATOR NOT RETURNING TO IDLE WHEN THE ACCELERATOR IS RELEASED.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN THE THROTTLE STICKING, BINDING, OR CAUSING HIGH ENGINE RPM.
Remedy: DEALERS WILL INSTALL A REVISED ACCELERATOR CABLE THAT HAS A FLARED CONDUIT SLEEVE END AND MOLDED ON END FITTING.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TERMINALS AT THE HEADLIGHT SWITCH AND WIRING HARNESS CONNECTOR CAN EXPERIENCE HEAT DAMAGE AS A RESULT OF OVERHEATING.
Consequence & remedy
Consequence: THE DAMAGE COULD RESULT IN DISTORTION OF THE TERMINAL CAUSING AN OPEN CIRCUIT IN THE INSTRUMENT PANEL ILLUMINATION, PARKING LAMP, AND TAIL LAMP CIRCUITS.
Remedy: DEALERS WILL INSTALL A HEADLAMP SWITCH WIRING CONNECTOR CONTAINING BRONZE TERMINALS AND AN INSPECTION, AND REPLACEMENT IF NECESSARY, OF THE HEADLAMP SWITCH.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FLOOR SHIFT AUTOMATIC TRANSMISSION CONTROL CAN BE DAMAGED IF SUBJECTED TO CERTAIN INTERIOR CLEANING PRODUCTS. THE GEAR POSITION INDICATOR CAN DETERIORATE AND NOT CORRECTLY INDICATE THE ACTUAL GEAR POSITION.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INCORRECT GEAR SELECTION.
Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FLOOR SHIFT CONTROL.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TEXT AND/OR GRAPHICS FOR THE VEHICLE HEADLAMP AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES ARE NOT SUFFICIENTLY CLEAR. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY BE CONFUSED BY THE AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES CAUSING THE HEADLAMPS TO BE IMPROPERLY AIMED.
Remedy: OWNER GUIDES CONTAINING REVISED AIMING INSTRUCTIONS WILL BE MAILED TO OWNERS OF THESE VEHICLES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7
RQ02006 · Incorrect Gear Indication
Opened Feb 26, 2002 · Closed Sep 12, 2002
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
EA01001 · Blower Switch/resistor Or Wiring Harness
Opened Jan 5, 2001 · Closed Jul 31, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
Additional source detail variants (2)
Electrical System
There is no summary currently available
Electrical System
There is no summary currently available
EA00025 · Fuel Expulsion During Refueling
Opened Oct 4, 2000 · Closed Jan 25, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE00027 · Fuel Expulsion During Refueling
Opened Jul 10, 2000 · Closed Oct 4, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE00023 · Blower Switch/resistor Or Wiring Harness
Opened Jun 14, 2000 · Closed Jan 5, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ99019 · Various Intermittent Electrical Issues
Opened Sep 15, 1999 · Closed Mar 7, 2001
Status: closed (inferred from source dates) · Unknown Or Other
There is no summary currently available
SQ98002 · Fuel Gauge Does Not Read Below 1/4
Opened Jan 27, 1998 · Closed Jul 31, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
FORD'S SERVICE BULLETIN DATED DECEMBER 8, 1997, POINTS OUT THAT THE FUEL GAUGE WILL NOT READ ABOVE 3/4 TANK OR BELOW 1/4 TANK OF FUEL.THE ERRONEOUS FUEL GAUGE READING WILL INDICATE SIGNIFICANTLY MORE FUEL RESERVE THAN ACTUALLY PRESENT IN THE FUEL TANK.ODI HAS ONE COMPLAINT WHERE THE DRIVER ALLEGED THAT HIS VEHICLE RAN OUT OF GAS DUE TO A FALSE FUEL GAUGE READING.THIS INVESTIGATION WASTO ASCERTAIN FACTS CONCERNING THE PROBLEM EXPERIENCE, SCOPE, AND RATIONAL FOR ELECTING NOT TO CONDUCT A SAFETY COMPAIGN.
1998 Ford Contour Problems, Complaints & Recalls | Skip That Year
Illustration