Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 18 of 374 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 99 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
37 crash reports38 fire reports28 injury reports
What owners actually said
374 reports
Mileage unknown · Mar 2, 2005
Air BagsCrashInjury
THE CONSUMER WAS INVOLVED IN AN ACCIDENT IN HER 1993 FORD AEROSTAR IN WHICH THE VEHICLE ROLLED FOUR TIMES. NONE OF THE VEHICLE'S AIR BAGS DEPLOYED. *NM THE CONSUMER SUSTAINED LIFE THREATENING INJURIES INCLUDING A BROKEN BONE IN HER BACK. THE MANUFACTURER WAS CONTACTED BUT THE CONSUMER HAS NOT RECEIVED A RESPONSE FROM THEM. *…
Read full complaint
THE CONSUMER WAS INVOLVED IN AN ACCIDENT IN HER 1993 FORD AEROSTAR IN WHICH THE VEHICLE ROLLED FOUR TIMES. NONE OF THE VEHICLE'S AIR BAGS DEPLOYED. *NM THE CONSUMER SUSTAINED LIFE THREATENING INJURIES INCLUDING A BROKEN BONE IN HER BACK. THE MANUFACTURER WAS CONTACTED BUT THE CONSUMER HAS NOT RECEIVED A RESPONSE FROM THEM. *NM
NHTSA ODI #10113755
150,000 miles · Mar 2, 2005
Electrical SystemFire
WHILE DRIVING 15 MPH, THE VEHICLE STALLED. THE CONSUMER TRIED TO RESTART THE VEHICLE AND WAS ABLE TO DO SO. WHILE OPENING THE HOOD, THE VEHICLE CAUGHT ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS TOWED TO A GARAGE FOR INSPECTION. THE CAUSE HAS NOT BEEN DETERMINED. PLEASE PROVIDE FURTHER DETAILS. …
Read full complaint
WHILE DRIVING 15 MPH, THE VEHICLE STALLED. THE CONSUMER TRIED TO RESTART THE VEHICLE AND WAS ABLE TO DO SO. WHILE OPENING THE HOOD, THE VEHICLE CAUGHT ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS TOWED TO A GARAGE FOR INSPECTION. THE CAUSE HAS NOT BEEN DETERMINED. PLEASE PROVIDE FURTHER DETAILS. *JB RECALL CAMPAIGN; NHTSA CAMPAIGN ID NUMBER : 99V029000. THE CONSUMER STATED THAT HE SAW SMOKE COMING OUT OF THE EDGE OF THE HOOD. AFTER HE OPENED THE HOOD HE SAW A SMALL FIRE AT THE REAR OF THE ENGINE. *TC
NHTSA ODI #10109761
175,000 miles · Feb 25, 2005
Exterior Lighting
BRAKE LIGHTS CONSTANTLY SHORTING OUT. I HAVE TO REPLACE THEM 2 OR MORE TIMES PER YEAR. I USE LONG-LIFE BULBS, BUT THEY CONTINUALLY GO OUT. I SEE MANY OTHER AEROSTAR VEHICLES WITH SIMILAR SITUATION. WHILE THIS HAS NOT CAUSED AN ACCIDENT YET, UNLESS I CONSTANTLY CHECK THE LIGHTS, I MAY BE INVOLVED IN AN ACCIDENT AND/OR TICKET …
Read full complaint
BRAKE LIGHTS CONSTANTLY SHORTING OUT. I HAVE TO REPLACE THEM 2 OR MORE TIMES PER YEAR. I USE LONG-LIFE BULBS, BUT THEY CONTINUALLY GO OUT. I SEE MANY OTHER AEROSTAR VEHICLES WITH SIMILAR SITUATION. WHILE THIS HAS NOT CAUSED AN ACCIDENT YET, UNLESS I CONSTANTLY CHECK THE LIGHTS, I MAY BE INVOLVED IN AN ACCIDENT AND/OR TICKET DUE TO THIS DEFECT. *NM
NHTSA ODI #10112157
149,000 miles · Dec 16, 2004
Exterior Lighting
HEADLIGHTS SWITCH BURNED OUT TWICE. THE CONNECTOR TO THE SWITCH KEPT BURNING. THE MANUFACTURER OFFERED NO HELP.*AK
NHTSA ODI #10104971
91,400 miles · Oct 30, 2004
SteeringCrash
WHILE TURNING LEFT IN AN INTERSECTION THE STEERING WHEEL LOCK UP ON MY AEROSTAR FORD '93 THAT CAUSED ME TO TURN OVER TO THE LEFT AND HIT THE OPPOSITE LANE AND HIT A CAR. I WAS UNABLE TO STRAIGHTEN OUT THE WHEEL AS IT LOCKS UP. AFTER IT WAS RESTARTED THE STEERING WHEEL WAS FINE AND 2 MECHANICS THAT I BROUGHT IT TO CAN'T FIND ANY …
Read full complaint
WHILE TURNING LEFT IN AN INTERSECTION THE STEERING WHEEL LOCK UP ON MY AEROSTAR FORD '93 THAT CAUSED ME TO TURN OVER TO THE LEFT AND HIT THE OPPOSITE LANE AND HIT A CAR. I WAS UNABLE TO STRAIGHTEN OUT THE WHEEL AS IT LOCKS UP. AFTER IT WAS RESTARTED THE STEERING WHEEL WAS FINE AND 2 MECHANICS THAT I BROUGHT IT TO CAN'T FIND ANY PROBLEMS.*JB
NHTSA ODI #10098011
Mileage unknown · Oct 8, 2004
SteeringSuspension
THE FRONT END NEEDED TO BE ALIGNED BECAUSE NEW TIRES WERE INSTALLED. THE MECHANIC WAS UNABLE TO PERFORM THE FRONT END ALIGNMENT BECAUSE THE FRONT LEFT BALL JOINT AND INNER TIE ROD WERE WORN. *JB
NHTSA ODI #10095474
130,000 miles · Aug 6, 2004
Electrical SystemFire
WHILE DRIVING ON THE HIGHWAY VEHICLE CAUGHT ON FIRE BECAUSE OF THE DEFECT DESCRIBED IN IGNITION SWITCH ELECTRICAL SHORT 99V029000 RECALL. MANUFACTURER PROVIDED CONFLICTING INFORMATION. THEY TOLD CONSUMER BY PHONE THAT THE VIN NUMBER WAS INCLUDED IN THE RECALL ,AND THEN SENT A LETTER INDICATING THAT THE VIN NUMBER WASN'T INCLUDE…
Read full complaint
WHILE DRIVING ON THE HIGHWAY VEHICLE CAUGHT ON FIRE BECAUSE OF THE DEFECT DESCRIBED IN IGNITION SWITCH ELECTRICAL SHORT 99V029000 RECALL. MANUFACTURER PROVIDED CONFLICTING INFORMATION. THEY TOLD CONSUMER BY PHONE THAT THE VIN NUMBER WAS INCLUDED IN THE RECALL ,AND THEN SENT A LETTER INDICATING THAT THE VIN NUMBER WASN'T INCLUDED. *AK
NHTSA ODI #10087331
Mileage unknown · Jun 1, 2004
Tires
I BOUGHT 4-TIRES AT SEAR IN KINGSPORT TENNESSEE IN FEBRUARY 2004 AND NOTICED THAT ALL 4-TIRES HAD BAD PLACES ON THE TIRES ,TOOK THE VEHICLE BACK THEY SAID IT WAS THE BELTS BROKE IN THEM BUT IT WAS OKAY TO DRIVE .I ASKED THEM TO REPLACE THESE TIRES BECAUSE I EAS GOING ON VACATION AND IT NEEDED TO BE DONE NOW.THEN THEY SAY THE TIR…
Read full complaint
I BOUGHT 4-TIRES AT SEAR IN KINGSPORT TENNESSEE IN FEBRUARY 2004 AND NOTICED THAT ALL 4-TIRES HAD BAD PLACES ON THE TIRES ,TOOK THE VEHICLE BACK THEY SAID IT WAS THE BELTS BROKE IN THEM BUT IT WAS OKAY TO DRIVE .I ASKED THEM TO REPLACE THESE TIRES BECAUSE I EAS GOING ON VACATION AND IT NEEDED TO BE DONE NOW.THEN THEY SAY THE TIRES ARE LIKE THAT ,SO I CHECKED THE TIRES ON THE WALL THERE AND THERE WASNT A TIRE THERE LIKE MINE WITH THESE PLACES ON THEM. ALKL THE WAY TO THE BEACH THE VAN SHOOK BECAUSE THEY SAID THESE TIRES WERE OK,SEARS LOGO IS SATISFACTIONED GUARANTEED RIGHT. IF ONE OF MY KIDS OR FAMILY GETS HURT BECAUSE OF THESE TIRES SEARS WILL BE IN A LAWSUIT OVER 4- TIRES THAT SHOULD BE REPLACED INSTEAD OF ASKING ANY QUESTIONS.*AK
NHTSA ODI #10074572
115,000 miles · May 28, 2004
Tires
THE VEHICLE'S REAR TIRES HAVE PRODUCED A LARGE BUBBLE ON IT. THE CAUSE HAS YET TO BE DETERMINED. PLEASE PROVIDE ADDITIONAL INFORMATION. *LA
NHTSA ODI #10074412
Mileage unknown · Feb 23, 2004
Structure
ELECTRONIC DASH READOUT CANNOT BE SEEN WHEN SUNLIGHT ENTERS THE CAR AT NUMEROUS ANGLES. *LA *JB
VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR, CREATING A SHORT CIRCUIT, ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE.
Consequence & remedy
Consequence: THIS CAN CAUSE OVER HEATING AND THE POTENTIAL FOR A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A JUMPER HARNESS WITH A RELAY WHICH WILL RE-ROUTE AND ACTIVATE ALL A2 ACCESSORIES THROUGH THE RELAY.
VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, AND, IF THE EXPELLED FLUID CONTACTS THE EXHAUST SYSTEM, A VEHICLE FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW TRANSFER CASE REAR OUTPUT SHAFT BUSHING AND AN ALUMINUM DRIVESHAFT WILL BE INSTALLED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
PE02076 · Luggage Compartment Door Drops Abruptly
Opened Oct 10, 2002 · Closed Mar 10, 2003
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
ODI HAS IDENTIFIED 30 INCIDENTS RESULTING IN MINOR TO MODERATE PERSONAL INJURIES THAT HAVE BEEN CAUSED BY ABRUPT DOOR DROPS OVER THE APPROXIMATELY EIGHT - TWELVE YEAR PERIOD OF PRODUCT USAGE AND EXPOSURE (1991-1995 TO 2003).MOST OF THE INJURY INCIDENTS APPEAR TO HAVE BEEN CAUSED BY A FRACTURE OF THE GAS FILLED LIFT ASSIST CYLINDER MOUNTING STUD.STUD FRACTURES HAVE OCCURRED RANDOMLY OVER TIME AND DO NOT EXHIBIT ANY APPARENT TREND RELATING TO DATE OF VEHICLE PRODUCTION OR TIME-IN-SERVICE (EXPOSURE).THE ODI CLOSING REPORT SUMMARIZES THE DETAILS OF THIS INVESTIGATION.
EA99002 · Transfer Cases And Rear Drive Shaft
Opened Jan 7, 1999 · Closed Nov 14, 2000
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
RQ98012 · Transfer Cases And Rear Driveshaft
Opened Jul 31, 1998 · Closed Jan 7, 1999
Status: closed (inferred from source dates) · Power Train:transfer Case (4-WHEEL Drive)
There is no summary currently available
EA98016 · Fuel Sender Assembly Fires
Opened Jul 14, 1998 · Closed Feb 12, 1999
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Additional source detail variants (2)
Vehicle Speed Control:linkages
There is no summary currently available
Vehicle Speed Control:linkages
There is no summary currently available
PE98010 · Fuel Sender Assembly Fires
Opened Feb 13, 1998 · Closed Jul 14, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
OWNERS ALLEGE THAT FAILURE OF THE FUEL PUMP/SENDER CONNECTOR RESULTS IN SHORT CIRCUIT THAT HAS RESULTED IN VEHICLE FIRES.SYMPTOMS INCLUDE ERRATIC FUEL GAUGE OPERATION, , SMOKE FROM THE DASH ON THE DRIVER'S SIDE NEAR THE STEERING COLUMN (FUEL PUMP FUSIBLE LINK) AND PASSENGER SIDE (FUEL PUMP INERTIA CUTOFF SWITCH), INTERMITTENT STALL AND NO START CONCERNS, AND A BURNING ODOR. SEVERAL INCIDENTS HAVE RESULTED IN DAMAGE TO PLASTIC FUEL TUBES AND/OR FUEL SUPPLY/RETURN TUBES.
1993 Ford Aerostar Problems, Complaints & Recalls | Skip That Year
Illustration