IllustrationAIR BAG LIGHT STARTED FLASHING CONSTANTLY, THEN HORN AND CRUISE CONTROL STOPPED WORKING. NOISE IN COLUMN SOUNDS LIKE LOOSE WIRES FLOPPING.
1993 Ford Aerostar
Owner reports · Recalls · Investigations
More warning signs than most Aerostar years
Owner complaints for the 1993 Ford Aerostar are substantially higher than the model-year median of 135.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Aerostar years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 18 of 374 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 99 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
37 crash reports38 fire reports28 injury reports
Steering complaints
17 reportsWHILE TURNING LEFT IN AN INTERSECTION THE STEERING WHEEL LOCK UP ON MY AEROSTAR FORD '93 THAT CAUSED ME TO TURN OVER TO THE LEFT AND HIT THE OPPOSITE LANE AND HIT A CAR. I WAS UNABLE TO STRAIGHTEN OUT THE WHEEL AS IT LOCKS UP. AFTER IT WAS RESTARTED THE STEERING WHEEL WAS FINE AND 2 MECHANICS THAT I BROUGHT IT TO CAN'T FIND ANY …
Read full complaint
WHILE TURNING LEFT IN AN INTERSECTION THE STEERING WHEEL LOCK UP ON MY AEROSTAR FORD '93 THAT CAUSED ME TO TURN OVER TO THE LEFT AND HIT THE OPPOSITE LANE AND HIT A CAR. I WAS UNABLE TO STRAIGHTEN OUT THE WHEEL AS IT LOCKS UP. AFTER IT WAS RESTARTED THE STEERING WHEEL WAS FINE AND 2 MECHANICS THAT I BROUGHT IT TO CAN'T FIND ANY PROBLEMS.*JB
THE FRONT END NEEDED TO BE ALIGNED BECAUSE NEW TIRES WERE INSTALLED. THE MECHANIC WAS UNABLE TO PERFORM THE FRONT END ALIGNMENT BECAUSE THE FRONT LEFT BALL JOINT AND INNER TIE ROD WERE WORN. *JB
THERE WAS A DESIGN FLAW IN STEERING COLUMN. WIRE RIBBON RING THAT'S INSIDE OF STEERING COLUMN, WHICH GIVES POWER TO AIR BAG/ CRUISE CONTROL, AND HORN HAS CRACKED AS A RESULT OF RIBBON BEING TOO SHORT AND FOLDED OVER, VEHICLE HAD NO HORN/NO CRUISE CONTROL OR AIR BAG.DEALER CONTACTED.*AK
THIS SPINDLE FAILURE HAPPENED WITH NO WARNING.THANK GOD THAT NONE OF MY THREE KIDS WERE INJURED AND ALSO MYSELF.THIS HAPPENED AT A VERY LOW SPEED UNDER BRAKING.I WAS IN ROUTE TO THOMASVILLE GEORGIA TO TAKE MY THREE KIDS TO GO BACK TO THERE MOMS.THANK GOD FOR SAVING OUR LIVES.*AK
POWER STEERING FLUID CONSTANTLY LEAKS CAUSING HARD STEERING. NLM
THE VEHICLE WAS PARKED AND ENGINE NOT RUNNING. I SAT DOWN TO ADJUST THE SEAT POSITION. THE INCLINATION OF THE SEAT BACK SUDDENLY FELL FULLY BACKWARDS TO IT'S FURTHEREST DOWN POSITION. THE INCLINATION HOLDING BOLT SHEARED OFF COMPLETELY. FORD'S PART #N805885-S58. FORD'S DESCRIPTION SCR-M10X1.5X44. THIS PART WAS REPLACED AT MY CO…
Read full complaint
THE VEHICLE WAS PARKED AND ENGINE NOT RUNNING. I SAT DOWN TO ADJUST THE SEAT POSITION. THE INCLINATION OF THE SEAT BACK SUDDENLY FELL FULLY BACKWARDS TO IT'S FURTHEREST DOWN POSITION. THE INCLINATION HOLDING BOLT SHEARED OFF COMPLETELY. FORD'S PART #N805885-S58. FORD'S DESCRIPTION SCR-M10X1.5X44. THIS PART WAS REPLACED AT MY COST. THIS WAS A DEFINITE MATERIAL FAILURE.*AK
I WIIL BE FAXING OVER THE INFORMATION REGARDING THIS 93 FORD AEROSTAR. NO SAFETY DEFECT LISTED IN THE SUMMARY. *AK THE VEHICLE HAD STARTING PROBLEMS. THE TRANSMISSION FAILED. THE A/C FAILED. RELAY STARTER MOTOR FAILED. THE HEATER CORE FAILED. POWER STEERING WAS INOPERATIVE. TIE RODS ON BOTH TIRES FAILED. WATER PUMP FAILED…
Read full complaint
I WIIL BE FAXING OVER THE INFORMATION REGARDING THIS 93 FORD AEROSTAR. NO SAFETY DEFECT LISTED IN THE SUMMARY. *AK THE VEHICLE HAD STARTING PROBLEMS. THE TRANSMISSION FAILED. THE A/C FAILED. RELAY STARTER MOTOR FAILED. THE HEATER CORE FAILED. POWER STEERING WAS INOPERATIVE. TIE RODS ON BOTH TIRES FAILED. WATER PUMP FAILED. *YH
I WAS TOLD BY THE FORD DEALER IN HAYS KANSAS THAT THIS SHIFT LINKAGE IS A COMMON PROBLEM BUT THERE WERE NO RECALLS ON IT THAT HE KNEW ABOUT.
STEERING LOCKS UP WITHOUT ANY PRIOR SIGN,WILL UNLOCK BY TURNING IT COUNTERCLOCKWISE,SEEMS TO BE THE COLUMM BEARING,OR AIR BAG SPRING,NO STEERING WHEEL IN MY LIFE EVER DID THAT AND I HAD MANY VEHICLES,LUCKY THING I WAS GOING FAIRLY SLOW ,IF IT WAS HIGHWAY SPEED COULD HAVE BEEN A TRAGEDY
Official recalls
299V029000 · Electrical System:ignition:switch
Feb 9, 1999
VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR, CREATING A SHORT CIRCUIT, ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE.
Consequence & remedy
Consequence: THIS CAN CAUSE OVER HEATING AND THE POTENTIAL FOR A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A JUMPER HARNESS WITH A RELAY WHICH WILL RE-ROUTE AND ACTIVATE ALL A2 ACCESSORIES THROUGH THE RELAY.
97V204000 · Power Train:transfer Case (4-WHEEL Drive)
Nov 13, 1997
VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, AND, IF THE EXPELLED FLUID CONTACTS THE EXHAUST SYSTEM, A VEHICLE FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW TRANSFER CASE REAR OUTPUT SHAFT BUSHING AND AN ALUMINUM DRIVESHAFT WILL BE INSTALLED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5PE02076 · Luggage Compartment Door Drops Abruptly
Opened Oct 10, 2002 · Closed Mar 10, 2003
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
ODI HAS IDENTIFIED 30 INCIDENTS RESULTING IN MINOR TO MODERATE PERSONAL INJURIES THAT HAVE BEEN CAUSED BY ABRUPT DOOR DROPS OVER THE APPROXIMATELY EIGHT - TWELVE YEAR PERIOD OF PRODUCT USAGE AND EXPOSURE (1991-1995 TO 2003).MOST OF THE INJURY INCIDENTS APPEAR TO HAVE BEEN CAUSED BY A FRACTURE OF THE GAS FILLED LIFT ASSIST CYLINDER MOUNTING STUD.STUD FRACTURES HAVE OCCURRED RANDOMLY OVER TIME AND DO NOT EXHIBIT ANY APPARENT TREND RELATING TO DATE OF VEHICLE PRODUCTION OR TIME-IN-SERVICE (EXPOSURE).THE ODI CLOSING REPORT SUMMARIZES THE DETAILS OF THIS INVESTIGATION.
EA99002 · Transfer Cases And Rear Drive Shaft
Opened Jan 7, 1999 · Closed Nov 14, 2000
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
RQ98012 · Transfer Cases And Rear Driveshaft
Opened Jul 31, 1998 · Closed Jan 7, 1999
Status: closed (inferred from source dates) · Power Train:transfer Case (4-WHEEL Drive)
There is no summary currently available
EA98016 · Fuel Sender Assembly Fires
Opened Jul 14, 1998 · Closed Feb 12, 1999
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Additional source detail variants (2)
Vehicle Speed Control:linkages
There is no summary currently available
Vehicle Speed Control:linkages
There is no summary currently available
PE98010 · Fuel Sender Assembly Fires
Opened Feb 13, 1998 · Closed Jul 14, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
OWNERS ALLEGE THAT FAILURE OF THE FUEL PUMP/SENDER CONNECTOR RESULTS IN SHORT CIRCUIT THAT HAS RESULTED IN VEHICLE FIRES.SYMPTOMS INCLUDE ERRATIC FUEL GAUGE OPERATION, , SMOKE FROM THE DASH ON THE DRIVER'S SIDE NEAR THE STEERING COLUMN (FUEL PUMP FUSIBLE LINK) AND PASSENGER SIDE (FUEL PUMP INERTIA CUTOFF SWITCH), INTERMITTENT STALL AND NO START CONCERNS, AND A BURNING ODOR. SEVERAL INCIDENTS HAVE RESULTED IN DAMAGE TO PLASTIC FUEL TUBES AND/OR FUEL SUPPLY/RETURN TUBES.