FIAT 500 E (ELECTRIC ENGINE) WAS FULLY CHARGED. STARTED CAR AND BACKED OUT OF DRIVEWAY. HEADED DOWN RESIDENTIAL STREET AT APPROXIMATELY 25MPH. WITHIN 1/8 MILE, "SERVICE ELECTRICAL VEHICLE SYSTEM" WARNING LIGHT CAME UP. CAR STARTED TO LOSE POWER, BUT WAS ABLE TO PULL OVER BEFORE CAR STOPPED. CAR WOULD START, SHOW WARNING LIG…
Read full complaint
FIAT 500 E (ELECTRIC ENGINE) WAS FULLY CHARGED. STARTED CAR AND BACKED OUT OF DRIVEWAY. HEADED DOWN RESIDENTIAL STREET AT APPROXIMATELY 25MPH. WITHIN 1/8 MILE, "SERVICE ELECTRICAL VEHICLE SYSTEM" WARNING LIGHT CAME UP. CAR STARTED TO LOSE POWER, BUT WAS ABLE TO PULL OVER BEFORE CAR STOPPED. CAR WOULD START, SHOW WARNING LIGHT, BUT COULD NOT BE PUT INTO DRIVE OR REVERSE TO BE DRIVEN. WAS ABLE TO PUT IT IN NEUTRAL AND PUSH IT TO THE SIDE OF THE ROAD. HAD TOWED (FLAT BED) TO FIAT DEALER - WHERE CAR RESTARTED WITHOUT PROBLEM. FIAT DEALER COULD NOT DUPLICATE PROBLEM. KEPT CAR FOR ONE WEEK, TESTED FOR 100+ MILES. TOLD ME "CORPORATE" KNEW OF THE PROBLEM AND WAS WORKING ON A "SOFTWARE FIX" - BUT TO TAKE THE CAR HOME AND DRIVE IT. THIS CAR HAS BEEN PART OF A FIAT RECALL (WORK COMPLETED TWO MONTHS PRIOR) TO PREVENT THIS TYPE OF PROBLEM. DID NOT HAVE THE PROBLEM BEFORE THE RECALL. SAME PROBLEM OCCURRED IN A FRIEND'S 2014 FIAT 500 E TONIGHT - EXACT SAME WAY - WITH ENGINE POWER FAILING WHILE CAR IS IN MOTION - WITH JUST BARELY ENOUGH TIME TO GET OUT OF TRAFFIC LANE. THIS FRIEND'S VEHICLE HAD ALSO HAD THE RECALL COMPLETED A MONTH PRIOR. THIS PROBLEM HAS BEEN REPORTED BY OTHER OWNERS ON THE INTERNET AND NEEDS TO BE ADDRESSED BEFORE A CAR FAILS IN MOVING TRAFFIC RESULTING IN AN ACCIDENT. *TR
NHTSA ODI #10655154
150 miles · Sep 15, 2014
Electrical SystemEngine
TL* THE CONTACT OWNS A 2013 FIAT 500E. THE CONTACT STATED THAT THE CHECK ELECTRICAL SYSTEM SENSOR BEGAN FLASHING AND REMAINED ILLUMINATED. THE SENSOR ILLUMINATED WHETHER THE VEHICLE WAS FULLY CHARGED, HALFWAY CHARGED, OR LOW. THE CONTACT NOTIFIED THE LOCAL AUTHORIZED DEALER SEVERAL TIMES, BUT NO REMEDY WAS PROVIDED. THE CONTACT …
Read full complaint
TL* THE CONTACT OWNS A 2013 FIAT 500E. THE CONTACT STATED THAT THE CHECK ELECTRICAL SYSTEM SENSOR BEGAN FLASHING AND REMAINED ILLUMINATED. THE SENSOR ILLUMINATED WHETHER THE VEHICLE WAS FULLY CHARGED, HALFWAY CHARGED, OR LOW. THE CONTACT NOTIFIED THE LOCAL AUTHORIZED DEALER SEVERAL TIMES, BUT NO REMEDY WAS PROVIDED. THE CONTACT WAS LATER INFORMED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V235000 (ENGINE). THE DEALER STATED THAT THE PARTS NEEDED TO REPAIR THE VEHICLE WOULD NOT BE AVAILABLE FOR MONTHS. THE MANUFACTURER WAS NOTIFIED. THE SENSOR REMAINED ILLUMINATED AND THE CONTACT HEARD A LOUD NOISE COMING FROM THE ENGINE COMPARTMENT EACH TIME THE VEHICLE WAS STARTED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 150.
NHTSA ODI #10633337
8,000 miles · Aug 7, 2014
Engine
TL* THE CONTACT OWNS A 2013 FIAT 500E. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED AND LOST POWER ON FOUR OCCASIONS. THE CONTACT MENTIONED THAT THE ABS AND THE ESC WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED. THE MANUFACTURER…
Read full complaint
TL* THE CONTACT OWNS A 2013 FIAT 500E. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED AND LOST POWER ON FOUR OCCASIONS. THE CONTACT MENTIONED THAT THE ABS AND THE ESC WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 8,000.
Chrysler (FCA US LLC) is recalling certain model year 2013-2016 Fiat 500e vehicles manufactured March 22, 2012, to January 29, 2016. The power inverter module (PIM) may experience voltage spikes which can cause the propulsion system to shut down and loss of motive power.
Consequence & remedy
Consequence: Loss of motive power can increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will update the PIM software, free of charge. The recall began on July 5, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S26.
Chrysler (FCA US LLC) is recalling certain model year 2013-2015 Fiat 500 EV vehicles manufactured March 27, 2012, to November 1, 2014. If the vehicle goes in to limp home mode, incompatible software between Electric Vehicle Control Unit (EVCU) and Battery Pack Control Module (BPCM) may cause the electric propulsion system to fully shut down.
Consequence & remedy
Consequence: An electric propulsion system shut down will cause a stall-like condition, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will update the vehicle software to ensure compatability between components, free of charge. The recall began on May 21, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R15.
Chrysler Group, LLC (Chrysler) is recalling certain model year 2013-2014 Fiat 500e Battery Electric Vehicles (BEV) vehicles manufactured September 24, 2012, through April 4, 2014. The affected vehicles have cooling plates for the Power Inverter Module (PIM) that may leak coolant into areas of the high voltage circuitry, resulting a short circuit that could cause the related service fuse to blow.
Consequence & remedy
Consequence: If the service fuse blows, the vehicle would have a loss of propulsion while driving, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the PIM, free of charge. The recall began in July 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P23.
Chrysler is recalling certain model year 2013 Fiat 500e electric vehicles manufactured December 16, 2012, through August 13, 2013. The half shaft joints may loosen and separate causing noise and a loss of driving capability.
Consequence & remedy
Consequence: A loss of driving capability increases the risk of a crash.
Remedy: Chrysler will notify owners and Fiat dealers will replace the fasteners attaching the half shaft inboard joints, free of charge. The recall began on September 4, 2013. Owners may contact Fiat at 1-888-242-6342. Chrysler's recall number is N51.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2013 Fiat 500E Problems, Complaints & Recalls | Skip That Year
Illustration