NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
173 reports41,951 miles · Aug 25, 2008
Engine And Engine Cooling
RAPPING SOUND WAS HEARD FROM 2002 DODGE NEON ENGINE UPON COLD START WHICH WOULD STOP AFTER ABOUT 30 SECONDS. FIRST DEALER WE TOOK CAR TO SAID IT WAS CARBON BUILDUP; I KNEW IT WAS MORE THAN THAT AND BROUGHT IT ANOTHER DEALER WHO AT FIRST DENIED THEY HEARD THE SOUND AT STARTUP. I TOLD THEM TO KEEP THE CAR AND TRY ANOTHER COLD ST…
Read full complaint
RAPPING SOUND WAS HEARD FROM 2002 DODGE NEON ENGINE UPON COLD START WHICH WOULD STOP AFTER ABOUT 30 SECONDS. FIRST DEALER WE TOOK CAR TO SAID IT WAS CARBON BUILDUP; I KNEW IT WAS MORE THAN THAT AND BROUGHT IT ANOTHER DEALER WHO AT FIRST DENIED THEY HEARD THE SOUND AT STARTUP. I TOLD THEM TO KEEP THE CAR AND TRY ANOTHER COLD START - ENDED UP THAT THIRD CYLINDER PISTON WAS CRACKED AND FOURTH CYLINDER WAS SCORED AND THEY REPLACED THE SHORT BLOCK. LUCKY FOR ME, I WAS UNDER WARRANTY AND THE COST WAS $100 FOR THE DEDUCTIBLE. CAR HAD JUST UNDER 42,000 MILES ON IT AND HAS BEEN MAINTAINED PROPERLY - OIL CHANGES EVERY 3,000 MILES, AND IS DRIVEN IN A MODERATE MANNER (NOT BEAT ON). *TR
NHTSA ODI #10239713
84,000 miles · Aug 20, 2008
Air BagsCrashInjury
TL*THE CONTACT OWNS A 2002 DODGE NEON. WHILE DRIVING APPROXIMATELY 5 MPH IN THE RAIN, THE CONTACT'S VEHICLE WAS REAR ENDED BY ANOTHER VEHICLE TRAVELING APPROXIMATELY 30 MPH IN THE PARKING LOT. THE CONTACT THEN REAR ENDED THE PRECEDING VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO WARNING LIGHTS ILLUMINATED ON THE INS…
Read full complaint
TL*THE CONTACT OWNS A 2002 DODGE NEON. WHILE DRIVING APPROXIMATELY 5 MPH IN THE RAIN, THE CONTACT'S VEHICLE WAS REAR ENDED BY ANOTHER VEHICLE TRAVELING APPROXIMATELY 30 MPH IN THE PARKING LOT. THE CONTACT THEN REAR ENDED THE PRECEDING VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL PRIOR TO THE FAILURE. THE CONTACT SUSTAINED INJURY TO HER BACK. THE POLICE WAS NOT CALLED TO THE SCENE. THE VEHICLE WAS TAKEN TO AN AUTO COLLISION SHOP FOR REPAIR ESTIMATES. THE INSURANCE COMPANY HAS NOT YET DETERMINED IF THE VEHICLE WAS COMPLETELY DESTROYED. THE FAILURE AND CURRENT MILEAGES WERE 84,000.
NHTSA ODI #10239055
81,000 miles · Aug 18, 2008
Power Train
WHILE DRIVING ON THE HIGHWAY FELT A JOLT AND LOSS OF POWER. THE SPEEDOMETER THEN DIALED ALL THE WAY UP AND THEN BACK TO ZERO. PULLED OFF TO CHECK IT OUT, AS I SLOWED DOWN ON THE OFFRAMP HEARD A CRUNCHING SOUND AND THE CAR SHUT OFF. STARTED RIGHT BACK UP BUT WOULDN'T GO INTO GEAR, THE TRANSMISSION HAD LOCKED UP! I COULDN'T EVEN P…
Read full complaint
WHILE DRIVING ON THE HIGHWAY FELT A JOLT AND LOSS OF POWER. THE SPEEDOMETER THEN DIALED ALL THE WAY UP AND THEN BACK TO ZERO. PULLED OFF TO CHECK IT OUT, AS I SLOWED DOWN ON THE OFFRAMP HEARD A CRUNCHING SOUND AND THE CAR SHUT OFF. STARTED RIGHT BACK UP BUT WOULDN'T GO INTO GEAR, THE TRANSMISSION HAD LOCKED UP! I COULDN'T EVEN PUT IT IN NEUTRAL TO PUSH IT OFF THE OFFRAMP. HAD IT TOWED TO A SHOP WHERE THEY PUT IN A USED, NOT NEW OR REBUILT BUT A USED TRANSMISSIONS WITH 60,000 MILES ON IT FOR $1,800. THE CAR HAD 81,000 MILES AT THE TIME OF FAILURE AND IS BARELY SIX YEARS OLD! I HAVE ALSO HAD TO REPLACE THE THROTTLE BODY AND CATALYTIC CONVERTER BEFORE 75,000 MILES. BY FAR THE TRANSMISSION IS THE MOST UNACCEPTABLE COMPONENT FAILURE. AT ONLY 81,000 MILES AND SIX YEARS OLD DODGE NEEDS TO RECALL THESE AUTOMATIC TRANSMISSIONS! *TR
NHTSA ODI #10238623
Mileage unknown · Aug 15, 2008
Engine And Engine Cooling
2002 NEON DEVELOPED A TAPPING NOISE AT COLD START; THE NOISE CONTINUES UNTIL THE CAR IS WARMED UP. NO WARNING LIGHTS TO INDICATE A PROBLEM. CAR WAS TAKEN TO DEALER FOR DIAGNOSIS; OWNER TOLD IT IS A ROD OR WRIST PIN, BEST TO REPLACE THE ENGINE FOR 4,600. THIS CAR ONLY HAS 44,000 MILES ON IT AND HAS BEEN PROPERLY MAINTAINED. *…
Read full complaint
2002 NEON DEVELOPED A TAPPING NOISE AT COLD START; THE NOISE CONTINUES UNTIL THE CAR IS WARMED UP. NO WARNING LIGHTS TO INDICATE A PROBLEM. CAR WAS TAKEN TO DEALER FOR DIAGNOSIS; OWNER TOLD IT IS A ROD OR WRIST PIN, BEST TO REPLACE THE ENGINE FOR 4,600. THIS CAR ONLY HAS 44,000 MILES ON IT AND HAS BEEN PROPERLY MAINTAINED. *TR
NHTSA ODI #10238425
90,000 miles · Jul 29, 2008
Electrical SystemExterior Lighting
I HAVE A 2002 DODGE NEON SXT. FOR ABOUT A YEAR NOW MY FOG LIGHTS HAVE NOT WORKED PROPERLY. WHEN MY HEADLIGHTS ARE ON MY FOG LIGHTS FLICKER ON AND OF ON THEIR OWN. IF I GO OVER A BUMP THE TURN ON ANOTHER BUMP TURNS THEM OFF. THEY EVEN FLICKER ON AND OFF ON SMOOTH ROAD. I THOUGHT NOTHING ABOUT IT UNTIL I STARTED SMELLING SOME…
Read full complaint
I HAVE A 2002 DODGE NEON SXT. FOR ABOUT A YEAR NOW MY FOG LIGHTS HAVE NOT WORKED PROPERLY. WHEN MY HEADLIGHTS ARE ON MY FOG LIGHTS FLICKER ON AND OF ON THEIR OWN. IF I GO OVER A BUMP THE TURN ON ANOTHER BUMP TURNS THEM OFF. THEY EVEN FLICKER ON AND OFF ON SMOOTH ROAD. I THOUGHT NOTHING ABOUT IT UNTIL I STARTED SMELLING SOMETHING ELECTRICAL BURNING. I THEN SAW A STREAM OF WHITE SMOKE COMING OUT OF THE TOP OF MY STEERING COLUMN THROUGH THE HAZARD LIGHT BUTTON. THIS HAPPENS EVERYTIME I TURN ON MY HEADLIGHTS. I HAVE NOT HAD THE PROBLEM REPAIRED YET BUT I NEED TO VERY SOON. I AM MOST SCARED THAT A FIRE WILL IGNITE WHILE I AM DRIVING OR THE ELECTRICAL PROBLEM WILL CAUSE MY AIRBAG TO DEPLOY AND CAUSE AN ACCIDENT RESULTING IN INJURY OR DEATH. *TR
NHTSA ODI #10236230
82,835 miles · Jul 7, 2008
Engine And Engine Cooling
THE RADIATOR BROKE IN MY 2002 DODGE NEON. THE COOLANT WENT INTO THE TRANSMISSION. THIS WAS LAST 7/2007. NEXT THE TRANSMISSION SOLENOID WENT 4/2008. NOW THE TRANSMISSION NEEDS TO BE REBUILT. 7/2008 IN TALKING TO NUMEROUS REPAIR SHOPS I AM FINDING OUT THIS IS A COMMON PROBLEM AND HAPPENS ALL THE TIME WITH THESE NEONS. THIS IS A SA…
Read full complaint
THE RADIATOR BROKE IN MY 2002 DODGE NEON. THE COOLANT WENT INTO THE TRANSMISSION. THIS WAS LAST 7/2007. NEXT THE TRANSMISSION SOLENOID WENT 4/2008. NOW THE TRANSMISSION NEEDS TO BE REBUILT. 7/2008 IN TALKING TO NUMEROUS REPAIR SHOPS I AM FINDING OUT THIS IS A COMMON PROBLEM AND HAPPENS ALL THE TIME WITH THESE NEONS. THIS IS A SAFETY ISSUE. I THINK ITS A DEFECT WITH THE WAY THIS WAS BUILT. *TR
NHTSA ODI #10233455
Mileage unknown · Jun 15, 2008
Structure
MY 2002 DODGE NEON TRUNK ALSO FILLS UP WITH WATER WHEN IT RAINS AND FLOWS INTO THE BACKSEAT AND ON THE FLOOR OF THE BACK. IT'S BEEN ON GOING FOR A YEAR OR TWO. WHEN I FIRST NOTICED IT, I TOOK IT TO A DODGE DEALERSHIP AND THE GUY SAID THAT HE HAD NEVER HEARD OF THIS PROBLEM BEFORE AND TOOK APART MY BACK SEAT AND SAID HE COULDN'…
Read full complaint
MY 2002 DODGE NEON TRUNK ALSO FILLS UP WITH WATER WHEN IT RAINS AND FLOWS INTO THE BACKSEAT AND ON THE FLOOR OF THE BACK. IT'S BEEN ON GOING FOR A YEAR OR TWO. WHEN I FIRST NOTICED IT, I TOOK IT TO A DODGE DEALERSHIP AND THE GUY SAID THAT HE HAD NEVER HEARD OF THIS PROBLEM BEFORE AND TOOK APART MY BACK SEAT AND SAID HE COULDN'T FIND WHERE THE LEAK WAS FROM. HE SAID HE WOULD HAVE TO CHARGE ME LIKE $100 TO JUST SPRAY IT WITH A HOSE AND SEE WHERE THE LEAK WAS. I SAID FORGET IT. I WENT TO OTHER SITES AND SAW THAT IT'S A COMMON FLAW IN THIS CAR. EVENTUALLY, MY BROTHER IN LAW LOOKED AT IT, AND HE UNPLUGGED A HOLE IN THE WHEEL WELL OF MY TRUNK...PROBLEM SOLVED! I WILL NEVER BUY A DODGE AGAIN, ESPECIALLY A NEON. *TR
NHTSA ODI #10231066
Mileage unknown · May 17, 2008
Structure
EVERYTIME IT RAINS, I GET A TRUNK FULL OF WATER AND MY REAR FLOORBOARDS GET SOAKED. BY LOOKING AT THIS COMPLAINT SITE, I SEE THIS IS A MANUFACTURING PROBLEM. WRITING DODGE MAY NOT HELP, BUT I HAVE TO START SOMEWHERE. *TR
NHTSA ODI #10228070
24,000 miles · Apr 24, 2008
Structure
DODGE NEON FILLS WITH WATER IN THE TRUNK EACH TIME IT RAINS, AND FILLS THE REAR FLOORBOARDS. I DISASSEMBLED THE CAR TO GET THE MOLD OUT. THIS IS DUE TO FAULTY REAR TAIL-LIGHT SEALS. I HAVE REPLACED THEM 3 TIMES. THEY LAST ABOUT 4 OR 5 MONTHS AND START LEAKING AGAIN. DODGE SHOULD BE ASHAMED. THEY ARE AWARE OF THE PROBLEM. …
Read full complaint
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
NHTSA ODI #10225642
63,000 miles · Feb 1, 2008
Exterior LightingPower Train
TL*THE CONTACT OWNS A 2002 DODGE NEON. WHILE DRIVING 40 MPH, THE HEADLIGHTS WERE FOGGY AND PROVIDED POOR ILLUMINATION. THE LIGHTS ALSO FACE DOWNWARD INSTEAD OF STRAIGHT AHEAD. THE CONTACT WAS ALSO EXPERIENCING TRANSMISSION FAILURE. WHEN SHE WOULD SHIFT INTO DRIVE, THE GEAR WOULD SHIFT INTO REVERSE OR NEUTRAL. THE DEALER STA…
Read full complaint
TL*THE CONTACT OWNS A 2002 DODGE NEON. WHILE DRIVING 40 MPH, THE HEADLIGHTS WERE FOGGY AND PROVIDED POOR ILLUMINATION. THE LIGHTS ALSO FACE DOWNWARD INSTEAD OF STRAIGHT AHEAD. THE CONTACT WAS ALSO EXPERIENCING TRANSMISSION FAILURE. WHEN SHE WOULD SHIFT INTO DRIVE, THE GEAR WOULD SHIFT INTO REVERSE OR NEUTRAL. THE DEALER STATED THAT THERE WERE NO RECALLS FOR THE HEADLIGHTS. THE PURCHASE DATE AND POWERTRAIN WERE UNKNOWN. THE CURRENT MILEAGE WAS 75,250 AND FAILURE MILEAGE WAS APPROXIMATELY 63,000. UPDATED 03/18/08. *LJ THE CONSUMER STATED VEHICLE'S TRANSMISSION WAS REBUILT IN 02/08 AT THE COST OF $1,864.18. UPDATED 03/18/08 *TR
NHTSA ODI #10216716
NHTSA investigations
3EA06019 · Headlight Failure
Opened Nov 22, 2006 · Closed Nov 7, 2007
Status: closed (inferred from source dates) · Exterior Lighting:fog Lights; Exterior Lighting:fog Lights:switch; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
THIS EA WAS OPENED AFTER RECEIVING REPORTS THAT THE MULTIFUNCTION SWITCH ON THESE VEHICLES WOULD FAIL, CAUSING A LOSS OF HEADLIGHT ILLUMINATION.SOME COMPLAINANTS REPORT LOSS OF HEADLIGHT FUNCTION WHILE FOR OTHERS TEMPORARY LIGHTING WAS AVAILABLE BY PULLING ON THE MULTIFUNCTION SWITCH STALK TO ILLUMINATE HIGH BEAM LIGHTING.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA SHOW A LOW AND DECLINING FAILURE TREND.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (4)
Exterior Lighting:fog Lights
THIS EA WAS OPENED AFTER RECEIVING REPORTS THAT THE MULTIFUNCTION SWITCH ON THESE VEHICLES WOULD FAIL, CAUSING A LOSS OF HEADLIGHT ILLUMINATION.SOME COMPLAINANTS REPORT LOSS OF HEADLIGHT FUNCTION WHILE FOR OTHERS TEMPORARY LIGHTING WAS AVAILABLE BY PULLING ON THE MULTIFUNCTION SWITCH STALK TO ILLUMINATE HIGH BEAM LIGHTING.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA SHOW A LOW AND DECLINING FAILURE TREND.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Exterior Lighting:fog Lights:switch
THIS EA WAS OPENED AFTER RECEIVING REPORTS THAT THE MULTIFUNCTION SWITCH ON THESE VEHICLES WOULD FAIL, CAUSING A LOSS OF HEADLIGHT ILLUMINATION.SOME COMPLAINANTS REPORT LOSS OF HEADLIGHT FUNCTION WHILE FOR OTHERS TEMPORARY LIGHTING WAS AVAILABLE BY PULLING ON THE MULTIFUNCTION SWITCH STALK TO ILLUMINATE HIGH BEAM LIGHTING.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA SHOW A LOW AND DECLINING FAILURE TREND.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Exterior Lighting:headlights
THIS EA WAS OPENED AFTER RECEIVING REPORTS THAT THE MULTIFUNCTION SWITCH ON THESE VEHICLES WOULD FAIL, CAUSING A LOSS OF HEADLIGHT ILLUMINATION.SOME COMPLAINANTS REPORT LOSS OF HEADLIGHT FUNCTION WHILE FOR OTHERS TEMPORARY LIGHTING WAS AVAILABLE BY PULLING ON THE MULTIFUNCTION SWITCH STALK TO ILLUMINATE HIGH BEAM LIGHTING.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA SHOW A LOW AND DECLINING FAILURE TREND.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Exterior Lighting:headlights:switch
THIS EA WAS OPENED AFTER RECEIVING REPORTS THAT THE MULTIFUNCTION SWITCH ON THESE VEHICLES WOULD FAIL, CAUSING A LOSS OF HEADLIGHT ILLUMINATION.SOME COMPLAINANTS REPORT LOSS OF HEADLIGHT FUNCTION WHILE FOR OTHERS TEMPORARY LIGHTING WAS AVAILABLE BY PULLING ON THE MULTIFUNCTION SWITCH STALK TO ILLUMINATE HIGH BEAM LIGHTING.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA SHOW A LOW AND DECLINING FAILURE TREND.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE06028 · Headlight Failure
Opened Jul 28, 2006 · Closed Nov 22, 2006
Status: closed (inferred from source dates) · Exterior Lighting:fog Lights; Exterior Lighting:fog Lights:switch; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
ODI HAS REVIEWED COMPLAINTS FROM CONSUMERS STATING THAT THEY DO NOT HAVE HEADLIGHT FUNCTION WHILE OPERATING THEIR VEHICLE.THE REPORTS INDICATE THAT A LOSS OF BOTH HIGH AND LOW BEAM HEADLIGHTS IS THE RESULT OF PROBLEMS WITH THE VEHICLES MULTIFUNCTION SWITCH AND CONNECTING WIRING HARNESS.CONSUMERSNOTICED THAT THE STEERING COLUMN AREA (WHERE THESE PARTS ARE LOCATED) IS HEATING UP.IN SOME CASES, SMOKE WOULD COME OUT OF THE STEERING COLUMN AREA AND THE PLASTIC TRIM WOULD BEGIN TO MELT.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-019) TO FURTHER STUDY THIS ISSUE.
Additional source detail variants (4)
Exterior Lighting:fog Lights
ODI HAS REVIEWED COMPLAINTS FROM CONSUMERS STATING THAT THEY DO NOT HAVE HEADLIGHT FUNCTION WHILE OPERATING THEIR VEHICLE.THE REPORTS INDICATE THAT A LOSS OF BOTH HIGH AND LOW BEAM HEADLIGHTS IS THE RESULT OF PROBLEMS WITH THE VEHICLES MULTIFUNCTION SWITCH AND CONNECTING WIRING HARNESS.CONSUMERSNOTICED THAT THE STEERING COLUMN AREA (WHERE THESE PARTS ARE LOCATED) IS HEATING UP.IN SOME CASES, SMOKE WOULD COME OUT OF THE STEERING COLUMN AREA AND THE PLASTIC TRIM WOULD BEGIN TO MELT.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-019) TO FURTHER STUDY THIS ISSUE.
Exterior Lighting:fog Lights:switch
ODI HAS REVIEWED COMPLAINTS FROM CONSUMERS STATING THAT THEY DO NOT HAVE HEADLIGHT FUNCTION WHILE OPERATING THEIR VEHICLE.THE REPORTS INDICATE THAT A LOSS OF BOTH HIGH AND LOW BEAM HEADLIGHTS IS THE RESULT OF PROBLEMS WITH THE VEHICLES MULTIFUNCTION SWITCH AND CONNECTING WIRING HARNESS.CONSUMERSNOTICED THAT THE STEERING COLUMN AREA (WHERE THESE PARTS ARE LOCATED) IS HEATING UP.IN SOME CASES, SMOKE WOULD COME OUT OF THE STEERING COLUMN AREA AND THE PLASTIC TRIM WOULD BEGIN TO MELT.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-019) TO FURTHER STUDY THIS ISSUE.
Exterior Lighting:headlights
ODI HAS REVIEWED COMPLAINTS FROM CONSUMERS STATING THAT THEY DO NOT HAVE HEADLIGHT FUNCTION WHILE OPERATING THEIR VEHICLE.THE REPORTS INDICATE THAT A LOSS OF BOTH HIGH AND LOW BEAM HEADLIGHTS IS THE RESULT OF PROBLEMS WITH THE VEHICLES MULTIFUNCTION SWITCH AND CONNECTING WIRING HARNESS.CONSUMERSNOTICED THAT THE STEERING COLUMN AREA (WHERE THESE PARTS ARE LOCATED) IS HEATING UP.IN SOME CASES, SMOKE WOULD COME OUT OF THE STEERING COLUMN AREA AND THE PLASTIC TRIM WOULD BEGIN TO MELT.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-019) TO FURTHER STUDY THIS ISSUE.
Exterior Lighting:headlights:switch
ODI HAS REVIEWED COMPLAINTS FROM CONSUMERS STATING THAT THEY DO NOT HAVE HEADLIGHT FUNCTION WHILE OPERATING THEIR VEHICLE.THE REPORTS INDICATE THAT A LOSS OF BOTH HIGH AND LOW BEAM HEADLIGHTS IS THE RESULT OF PROBLEMS WITH THE VEHICLES MULTIFUNCTION SWITCH AND CONNECTING WIRING HARNESS.CONSUMERSNOTICED THAT THE STEERING COLUMN AREA (WHERE THESE PARTS ARE LOCATED) IS HEATING UP.IN SOME CASES, SMOKE WOULD COME OUT OF THE STEERING COLUMN AREA AND THE PLASTIC TRIM WOULD BEGIN TO MELT.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-019) TO FURTHER STUDY THIS ISSUE.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
Illustration