TL* THE CONTACT OWNS A 2000 DODGE CARAVAN. THE CONTACT STATED THAT THE TRANSPARENCY OF THE FRONTAL HEADLIGHTS WAS FOGGING CAUSING IT TO BE VERY DIFFICULT TO VIEW THE ROAD AT NIGHT. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 30,000. UPDATED 07…
Read full complaint
TL* THE CONTACT OWNS A 2000 DODGE CARAVAN. THE CONTACT STATED THAT THE TRANSPARENCY OF THE FRONTAL HEADLIGHTS WAS FOGGING CAUSING IT TO BE VERY DIFFICULT TO VIEW THE ROAD AT NIGHT. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 30,000. UPDATED 07/13/16*LJ UPDATED 07/25/16.*JB
NHTSA ODI #10864592
Mileage unknown · Oct 17, 2015
Exterior Lighting
OVER THE PAST SEVERAL YEARS I HAVE NOTICED MY HEADLIGHT LENS WERE FOGGING UP TO THE POINT WHERE THEY WERE NOT FUNCTIONING SAFELY. I TOOK THE CAR TO THE SHOP WHERE THEY USED AN EMULSIFIER LIQUID TO PARTIALLY RESTORE THE LENSES. THEN I NOTICED THAT OTHER CARS HAD THE SAME PROBLEM. THIS WAS NOT A PROBLEM WHEN THE MANUFACTURER…
Read full complaint
OVER THE PAST SEVERAL YEARS I HAVE NOTICED MY HEADLIGHT LENS WERE FOGGING UP TO THE POINT WHERE THEY WERE NOT FUNCTIONING SAFELY. I TOOK THE CAR TO THE SHOP WHERE THEY USED AN EMULSIFIER LIQUID TO PARTIALLY RESTORE THE LENSES. THEN I NOTICED THAT OTHER CARS HAD THE SAME PROBLEM. THIS WAS NOT A PROBLEM WHEN THE MANUFACTURERS USED GLASS LENSES. NOW THEY USE PLASTIC. WHAT CAN BE DONE TO ENCOURAGE AUTO MANUFACTURERS TO PLACE SAFE NO-FOG LENSES IN THEIR NEW VEHICLES?
NHTSA ODI #10783106
90,000 miles · Aug 14, 2009
Exterior Lighting
BOTH ORIGINAL FRONT HEADLIGHT ASSEMBLY'S ON THE 2000 DODGE GRAND CARAVAN ARE CLOUDED TO THE POINT THAT THE HEADLIGHT ILLUMINATION MAY BE COMPROMISED. THIS SEEMS TO BE A RESULT OF THE PLASTIC NOT BEING ABLE TO HANDLE THE UV (SUN).THE REAR LIGHTING ASSEMBLIES ARE FINE. *TR
NHTSA ODI #10280461
Mileage unknown · Mar 9, 2009
Air BagsElectrical SystemExterior Lighting
TL*THE CONTACT OWNS A 2000 DODGE CARAVAN. WHILE PROCEEDING TO MAKE A LEFT TURN AT APPROXIMATELY 30 MPH ON NORMAL ROAD CONDITIONS, THE TURN SIGNAL INDICATOR FAILED TO ACTIVATE. IN ADDITION, THE AIR BAG WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL AND REMAINED LIT UNTIL THE ENGINE WAS TURNED OFF. THE RIGHT TURN SIGNAL …
Read full complaint
TL*THE CONTACT OWNS A 2000 DODGE CARAVAN. WHILE PROCEEDING TO MAKE A LEFT TURN AT APPROXIMATELY 30 MPH ON NORMAL ROAD CONDITIONS, THE TURN SIGNAL INDICATOR FAILED TO ACTIVATE. IN ADDITION, THE AIR BAG WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL AND REMAINED LIT UNTIL THE ENGINE WAS TURNED OFF. THE RIGHT TURN SIGNAL INDICATOR OPERATED INTERMITTENTLY AND THE HORN DID NOT WORK. THE FAILURES OCCURRED WITHOUT WARNING. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS UNAVAILABLE AND THE CURRENT MILEAGE WAS 83,600.
NHTSA ODI #10261138
115,000 miles · Sep 17, 2008
Exterior Lighting
TL*THE CONTACT OWNS A 2000 DODGE CARAVAN. THE PLASTIC HEADLIGHT LENS OXIDIZES, RESULTING IN POOR ILLUMINATION OF THE ROAD. THE CONTACT WAS INFORMED THAT HE COULD PURCHASE A NEW HEAD LENS COVER. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 115,000.
NHTSA ODI #10242555
Mileage unknown · Dec 15, 1999
Exterior Lighting
HEADLIGHTS ON THIS VEHICLE ARE SO POORLY DESIGNED AS TO BE A HAZARD. AS A 2000 MODEL DAIMLER -CHRYSLER SHOULD BE REQUIRED TO UPGRADE THE HEADLIGHTS ON THIS VEHICLE. THIS IS NOT THE FIRST CHRYSLER PRODUCT I HAVE OWNED WITH VERY POOR FORWARD LIGHTING. *AK
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
2000 Dodge Caravan Problems, Complaints & Recalls | Skip That Year
Illustration