AIR BAG SENSOR LIGHT BLINKS ON AND OFF. A RECALL WAS ISSUED ON THE CLOCK SPRING, HOWEVER THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK THE VEHICLE HAD NUMEROUS PROBLEMS SUCH AS STEERING PROBLEMS, SLIDING PROBLEMS, BRAKE AND ACCELERATION PROBLEMS, A STRONG ODOR OF GAS AND THEFRONT SWAY BARS AND REAR SHOCKS WERE …
Read full complaint
AIR BAG SENSOR LIGHT BLINKS ON AND OFF. A RECALL WAS ISSUED ON THE CLOCK SPRING, HOWEVER THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK THE VEHICLE HAD NUMEROUS PROBLEMS SUCH AS STEERING PROBLEMS, SLIDING PROBLEMS, BRAKE AND ACCELERATION PROBLEMS, A STRONG ODOR OF GAS AND THEFRONT SWAY BARS AND REAR SHOCKS WERE REPLACED *JB
NHTSA ODI #10099961
68,000 miles · Jul 5, 2004
StructureFire
WE HAD BEEN HAVING PROBLEMS WITH OUR 2001 CHRYSLER TOWN AND COUNTRY. THE SLIDING DOOR KEPT OPENING WHILE WE WERE DRIVING DOWN THE ROAD AND THE DOOR WOULD OPEN. THEN WHILE WE WERE ON VACATION I WAS DRIVING DOWN THE HIGHWAY AND THE DOOR CAUGHT ON FIRE. WITHIN 2 MINUTES THE WHOLE CAR WAS IN FLAMES IF MY THREE CHILDREN HAD BEEN IN …
Read full complaint
WE HAD BEEN HAVING PROBLEMS WITH OUR 2001 CHRYSLER TOWN AND COUNTRY. THE SLIDING DOOR KEPT OPENING WHILE WE WERE DRIVING DOWN THE ROAD AND THE DOOR WOULD OPEN. THEN WHILE WE WERE ON VACATION I WAS DRIVING DOWN THE HIGHWAY AND THE DOOR CAUGHT ON FIRE. WITHIN 2 MINUTES THE WHOLE CAR WAS IN FLAMES IF MY THREE CHILDREN HAD BEEN IN THE CAR I AM NOT SURE IF I WOULD OF BEEN ABLE TO GET THEM ALL OUT. THE FIRE DEPARTMENT GOT THERE IN GOOD TIME BUT IT WAS TO LATE. THE WHOLE VAN AND EVERYTHING IN IT WAS TOTALLY DESTROYED.*AK
NHTSA ODI #10080381
Mileage unknown · May 23, 2003
StructureSuspension
WE PURCHASED A 2002 DODGE ROLLX CONVERTED MINIVAN AND A 2001 CHRYSLER ROLLX CONVERTED MINIVAN WITH AN ELK ROOF ADDITION CONVERSION FROM THE ROLLX CO. IN SAVAGE MINN. ABOUT A YEAR AGO. WHEN WE RECENTLY BEGAN CARRYING MORE THAN ONE PASSENGER WE NOTICED AND FELT A BOTTOMING OUT WITH LITTLE BOUNCE. I GOT A LOOK AT THE REAR SUSPENSIO…
Read full complaint
WE PURCHASED A 2002 DODGE ROLLX CONVERTED MINIVAN AND A 2001 CHRYSLER ROLLX CONVERTED MINIVAN WITH AN ELK ROOF ADDITION CONVERSION FROM THE ROLLX CO. IN SAVAGE MINN. ABOUT A YEAR AGO. WHEN WE RECENTLY BEGAN CARRYING MORE THAN ONE PASSENGER WE NOTICED AND FELT A BOTTOMING OUT WITH LITTLE BOUNCE. I GOT A LOOK AT THE REAR SUSPENSION AND WAS SUPPRISED TO FIND THAT THEY DROPPED THE FLOOR JUST ABOVE THE E-BRAKE LINE AND LEAF SPRINGS. THE DISTANCE BETWEEN THE BOTTOM OF THE FLOOR AND THE LEAF IS ONE AND ONE HALF INCHES. THE DISTANCE BETWEEN THE RUBBER BUMPER AND THE AXLE IS OVER THREE INCHES. THE LEAF SPRING AND BRAKE CABLE CANNOT TAKE THE DAMAGE FOR ANY LENGTH OF TIME. WE HAVE TO REMOVE THE SPARE AND REAR SEATS TO DRIVE SOMEWHAT SAFER. CONTACT WITH THE COMPANY WAS FUTILE.
NHTSA ODI #10019207
Mileage unknown · Apr 8, 2003
Structure
ELECTRIC SLIDING SIDE DOOR BECAME IMPOSSIBLE TO OPEN MANUALLY. IT WOULD STILL OPERATE WITH ELECTRIC MOTOR BUT MADE A GRINDING NOISE. IN CASE OF AN ACCIDENT, PASSENGERS IN REAR SEATS WOULD HAVE A HARD TIME OPENING DOOR ANS EXITING VEHICLE. *AK
NHTSA ODI #10014540
13,500 miles · Mar 7, 2003
Structure
THE DRIVER SIDE SLIDING DOOR FROZE, AND DID NOT UNLOCK. *JB THE DOOR CANNOT BE OPENED MANUALLY, WITH REMOTE, OR WITH THE AUTO BUTTON. THIS PROBLEM OCCURS AT LEAST ONE TO TWO TIMES PER WEEK. THE DEALER WAS UNABLE TO DUPLICATE. SCC
NHTSA ODI #10011126
Mileage unknown · Oct 29, 2002
Structure
CONSUMER STATED THAT WHILE DRIVING AT 55MPH THE LIFT GATE WINDOW SHATTER WITHOUT WARNING FOR THE SECOND TIME WITH THIN 2-3MONTH. DEALER NOTIFIED TS
NHTSA ODI #8021826
Mileage unknown · Jul 22, 2002
Structure
RIGHT DOOR OPENS AND CLOSES AUTOMATICALLY.*AK
NHTSA ODI #8014461
Mileage unknown · Jan 15, 2002
StructureInjury
CHILD GOT FINGERS CAUGHT IN RIGHT SIDE POWER SLIDING DOOR, AND MECHANISM DID NOT RELEASE. HAD TO MANUALLY OPEN DOOR.*AK
NHTSA ODI #8002217
Mileage unknown · Jan 4, 2002
Structure
PASSENGER'S SIDE ELECTRIC SLIDING DOOR CAME AJAR. CONSUMER HEARD AN ALARM, AND WITHIN SECONDS DOOR OPENED ABOUT 2 TO 3 INCHES WHILE DRIVING. CONSUMER AUTOMATIC SENSOR TRIGGERED IT TO CLOSE BACK. CONSUMER FELT THIS WAS VERY UNSAFE BECAUSE CHILDREN WERE IN VEHICLE. CONSUMER HAS CONTACTED MANUFACTURER. PLEASE PROVIDE ANY FURT…
Read full complaint
PASSENGER'S SIDE ELECTRIC SLIDING DOOR CAME AJAR. CONSUMER HEARD AN ALARM, AND WITHIN SECONDS DOOR OPENED ABOUT 2 TO 3 INCHES WHILE DRIVING. CONSUMER AUTOMATIC SENSOR TRIGGERED IT TO CLOSE BACK. CONSUMER FELT THIS WAS VERY UNSAFE BECAUSE CHILDREN WERE IN VEHICLE. CONSUMER HAS CONTACTED MANUFACTURER. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK
NHTSA ODI #8001526
Mileage unknown · Mar 30, 2001
StructureInjury
CONSUMER'S CHILD HAD GOTTEN FINGER CAUGHT IN GEARS OF POWER DOOR. . HAS CONTACTED MANUFACTURER. *AK
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINIVANS. THE LOWER CONTROL ARM PIVOT BOLT COULD FRACTURE.
Consequence & remedy
Consequence: IF THE BOLT FRACTURES, THE LOWER CONTROL ARM COULD SEPARATE FROM THE CROSSMEMBER, CAUSING A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT LOWER CONTROL ARM BOLTS AND NUTS. OWNER NOTIFICATION BEGAN APRIL 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
EA04031 · Power Liftgate Latch
Opened Nov 22, 2004 · Closed Apr 7, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Additional source detail variants (2)
Latches/locks/linkages
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
2001 Chrysler Town And Country Problems, Complaints & Recalls | Skip That Year
Illustration