NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
28 reportsClear category filterMileage unknown · Jan 15, 2004
Electrical SystemEngine And Engine CoolingEquipment
THUS IS A 2001 VEHICLE WITH 45K MILES - WORST CAR I HAVE EVER OWNED FOR THE FIRST 18 MONTHS WE HAD THE CAR WE COMPLAINED AT EVERY VISIT ABOUT A GROANING NOISE FROM THE REAR WHEN IN STOP AND GO TRAFFIC - FINALLY FIXED AFTER A YEAR AND A HALF 9/01 PAINT PEELED OFF LEFT PASSENGER DOOR - FIXED BY DEALER 11/01 RADIO STOPPED WORKIN…
Read full complaint
THUS IS A 2001 VEHICLE WITH 45K MILES - WORST CAR I HAVE EVER OWNED FOR THE FIRST 18 MONTHS WE HAD THE CAR WE COMPLAINED AT EVERY VISIT ABOUT A GROANING NOISE FROM THE REAR WHEN IN STOP AND GO TRAFFIC - FINALLY FIXED AFTER A YEAR AND A HALF 9/01 PAINT PEELED OFF LEFT PASSENGER DOOR - FIXED BY DEALER 11/01 RADIO STOPPED WORKING - REPLACED UNDER WARRANTY 10/02 - SLIDING DOOR HARD TO OPEN - CLAIMED TO REPAIR - STILL HARD TO OPEN 10/02 - CLUNKING NOISE OVER BUMPS IN FRONT END - REPLACED LEFT SIDE STABILIZER BAR LINK 4/02 - NOISE IN REAR WHEN TURNING - REPLACED REAR BACKING PLATE ANCHORS 6/02 AIR CONDITIONER COMPRESSOR REPLACED - UNDER WARRANTY -THEY TOOK TWO WEEKS TO FIX THIS 6/02 ENGINE LOSING POWER WHEN DRIVING - REPLACED TPS 1/03 REAR WIPER MOTOR REPLACED - $150 (CAR HAS 38K MILES) 6/03 REAR STABILIZER BAR - $250 7/03 REAR WIPER MOTOR AGAIN - OUT OF WARRANTY - $150 9/03 DRIVER WINDOW MOTOR - $250 THE WORST OF ALL - 11/03 - TRANSMISSION NEEDS TO BE TOTALLY REPLACED - $2700 - NO WARRANTY - CAR HAS 45K MILES - CALLED CHRYSLER AND WAS TOLD BASICALLY TOUGH LUCK THAT I DID NOT BUY AN EXTENDED WARRANTY - THE CAR JUST STOPPED MOVING - LUCKILY WE DID NOT HAVE AN ACCIDENT WE HAVE MAINTAINED THIS VEHICLE ACCORDING TO CHRYSLER GUIDELINES AT THE DEALER SINCE WE BOUGHT IT
NHTSA ODI #10071220
18,949 miles · Jan 15, 2004
Service Brakes, HydraulicSuspensionVisibility
9/8/01 10,232 MILES. PULSATION WHEN BRAKING. FOUND FRONT BRAKE ROTORS WARPED. REPLACED ROTORS. ALSO ORDERED WEATHERSTRIIPS AND DOOR CLADDING BECAUSE WEATHERSTRIP AROUND R/SLIDING DOOR ON BODY IS DEFORMED. 10/1/01 12,408 MILES. RATTLING NOISE IN FRONT SUSPENSION. REPLACED FRONT SWAY BAR LINKS. 12/26/01 15,592 MILES.…
Read full complaint
9/8/01 10,232 MILES. PULSATION WHEN BRAKING. FOUND FRONT BRAKE ROTORS WARPED. REPLACED ROTORS. ALSO ORDERED WEATHERSTRIIPS AND DOOR CLADDING BECAUSE WEATHERSTRIP AROUND R/SLIDING DOOR ON BODY IS DEFORMED. 10/1/01 12,408 MILES. RATTLING NOISE IN FRONT SUSPENSION. REPLACED FRONT SWAY BAR LINKS. 12/26/01 15,592 MILES. BOTH FRONT HEATED SEATS DO NOT OPERATE. 1/21/02 15,999 MILE. BOTH HEATED SEATS REPAIRED. 2/09/02 17,280 MILES. FRONT HEATED SEAT DOES NOT WORK AGAIN. REPAIRED FRONT SEAT. 4/19/02 L9,901 MILES. REPAIRED L/SLIDING DOOR DEFECTIVE WEATHERSTRIP. LEFT FRONT WINDOW WON'T GO UP OR DOWN. FOUND L/F WINDOW REGULATOR MOTOR DEFECTIVE. REPLACED L/F WINDOW REGULATOR MOTOR. 3/23/02 L8,949 MILES. PULSATION WHEN BRAKING. FOUND AND REPLACED FRONT BRAKE ROTORS. 8/8/02 23,559 MILES. PULSATION WHEN BRAKING. FOUND PULSATION IS FROM REAR ROTORS. TURN REAR ROTORS AND REMOVE HIGH SPOTS. BRAKES HAVE BEEN REPLACED 2 OR 3 TIMES SINCE PURCHASE OF VAN IN MAY OF 2001.
NHTSA ODI #10069846
10,000 miles · Jan 12, 2004
Service Brakes, HydraulicSteering
NOISY POWER STEERING PUMP AND POOR BRAKING. *LA
NHTSA ODI #10053007
Mileage unknown · Dec 30, 2003
Service Brakes, Hydraulic
WHILE DRIVING THE DRIVER APPLIED THE BRAKES AND THE PEDAL WENT TO THE FLOOR. THE DRIVER CONTINUED TO HOLD THE BRAKE PEDAL TO THE FLOOR UNTIL VEHICLE CAME TO A STOP. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DETERMINED THAT THE HYDRAULIC BRAKE LINE WAS DEFECTIVE. *NM
NHTSA ODI #10052152
Mileage unknown · Nov 19, 2003
Service Brakes, Hydraulic
VEHICLE BRAKE ROTORS WERE RUSTED INSIDE AND OUT.*MR THE VEHICLE MADE NOISE WHEN THE BRAKES WERE APPLIED. THE VEHICLE WAS TAKEN TOT HE DEALER WHERE THE TECHNICIAN DETERMINED THAT THE ROTORS WERE RUSTED FROM THE INSIDE OUT AND COULD NOT BE CUT. THE TECHNICIAN STATED THAT THE STEEL USED ON THESE ROTORS WAS INFERIOR BECAUSE IT WA…
Read full complaint
VEHICLE BRAKE ROTORS WERE RUSTED INSIDE AND OUT.*MR THE VEHICLE MADE NOISE WHEN THE BRAKES WERE APPLIED. THE VEHICLE WAS TAKEN TOT HE DEALER WHERE THE TECHNICIAN DETERMINED THAT THE ROTORS WERE RUSTED FROM THE INSIDE OUT AND COULD NOT BE CUT. THE TECHNICIAN STATED THAT THE STEEL USED ON THESE ROTORS WAS INFERIOR BECAUSE IT WAS POROUS. THE CONSUMER REQUESTED REIMBURSEMENT FOR THE ROTORS. *NLM
NHTSA ODI #10048485
15,000 miles · Nov 13, 2003
Service Brakes, Hydraulic
BRAKE ROTORS HAVE BEEN RESURFACED TWICE DURING 30,000 MILES OF DRIVING. *LA
NHTSA ODI #10046881
Mileage unknown · Sep 22, 2003
Service Brakes, Hydraulic
DEALER REPLACED BOTH REAR CALIPERS WHICH WERE CRACKED AND LEAKED BRAKE FLUID. *AK
NHTSA ODI #10040276
6,715 miles · Jun 10, 2003
Service Brakes, Hydraulic
HAVE HAD FRONT END / ROTOR PROBLEMS REPORTED @ 6715MILES, 10,806 MILES, 21,060 MILES AND 24,179 MILES. IT IS UNREASONABLEFOR ROTORS TO NEED TO BE RESURFACED OR REPLACED 4 TIMES IN LESS THAN 25,000 MILES. OBVIOUSLY SOMETHING IS DEFECTIVE CAUSING THEM TO FAIL. THIS IS A MAJOR SAFETY CONCERN FOR ME AND MY CHILDREN.*AK
NHTSA ODI #10021355
27,000 miles · Jun 9, 2003
Service Brakes, Hydraulic
SUDDEN WARPAGE OF THE FRONT DISK BRAKE ROTOR CAUSED VIBRATION OF THE FRONT END AND LOSS OF STEERING CONTROL. WAS NOT BEING DRIVEN UNDER ANY LOAD, ONLY 1 PASSENGER IN THE CAR. VEHICLE IS NOT USED TO TOW TRAILER. *JB
NHTSA ODI #10021306
6,380 miles · Jun 2, 2003
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
THE VEHICLE MADE A KNOCKING NOISE IN THE FRONT END. THE DEALER REPLACED THE FRONT SUSPENSION STRUT, STRUT MOUNT, FRONT SWAY BAR AND SWAY BAR LINK. THE REAR END OF THE VEHICLE ALSO MADE NOISE. THE DEALER REPLACED THE TRANSFER GEAR SET. THE VEHICLE ALSO EXPERIENCED A WHINING NOISE IN THE STEERING WHEEL. THE DEALER REPLACED TH…
Read full complaint
THE VEHICLE MADE A KNOCKING NOISE IN THE FRONT END. THE DEALER REPLACED THE FRONT SUSPENSION STRUT, STRUT MOUNT, FRONT SWAY BAR AND SWAY BAR LINK. THE REAR END OF THE VEHICLE ALSO MADE NOISE. THE DEALER REPLACED THE TRANSFER GEAR SET. THE VEHICLE ALSO EXPERIENCED A WHINING NOISE IN THE STEERING WHEEL. THE DEALER REPLACED THE SPRING CLOCK ALONG WITH THE SHROUD STABILIZER. POWER STEERING FLUID DUE IT BEING CLOG AND CAUSED THE STEERING TO WHINE WHEN TURNED. THE REAR LIFT GATE WOULD NOT OPEN WITH THE REMOTE. FAULTY FRONT ROTORS SQUEAKED WHEN APPLIED. THE DRIVERS SIDE WINDOW WOULD NOT GO UP DUE TO A FAULTY REGULATOR. THE CRUISE CONTROL WOULD NOT DISABLE WHEN THE BRAKES WERE APPLIED AND THE BRAKES WOULD NOT WORK WHEN THE CRUISE CONTROL WAS ENGAGED. THE REAR WINDSHIELD WIPERS WERE INOPERATIVE. THE ENGINE MADE NOISE WHEN STARTED. THE TIMING CHAIN FAILED AND CAUSED THE CHECK ENGINE LIGHT TO ILLUMINATE. THE O-RINGS FAILED AND CAUSED FUEL ODOR INSIDE THE VEHICLE. *SCC *NLM
NHTSA ODI #10021582
NHTSA investigations
3EA05009 · Headlight Malfunction
Opened Jun 1, 2005 · Closed May 2, 2006
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
PE05004 · Headlight Malfunction
Opened Feb 2, 2005 · Closed Jun 1, 2005
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
EA04031 · Power Liftgate Latch
Opened Nov 22, 2004 · Closed Apr 7, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Additional source detail variants (2)
Latches/locks/linkages
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Illustration