TOOK VAN IN FOR SLIGHT ENGINE NOISE AND MECHANIC NOTICED THAT STRUT TOWER WAS NEARLY RUSTED THROUGH. TOOK TO THE DEALER WHO STATED THAT THE CAR WAS UNSAFE TO DRIVE UNDER ANY CIRCUMSTANCES SINCE ONE ROUGH PIECE OF ROAD AND THE CAR BODY COULD FALL TO THE GROUND AND THE STRUT ASSEMBLY COME THROUGH THE DASH INTO THE PASSENGER COMPA…
Read full complaint
TOOK VAN IN FOR SLIGHT ENGINE NOISE AND MECHANIC NOTICED THAT STRUT TOWER WAS NEARLY RUSTED THROUGH. TOOK TO THE DEALER WHO STATED THAT THE CAR WAS UNSAFE TO DRIVE UNDER ANY CIRCUMSTANCES SINCE ONE ROUGH PIECE OF ROAD AND THE CAR BODY COULD FALL TO THE GROUND AND THE STRUT ASSEMBLY COME THROUGH THE DASH INTO THE PASSENGER COMPARTMENT. THIS WILL NOW COST OVER 1500.00 TO REPAIR. CHRYSLER ISSUED A SERVICE BULLETIN ON THIS IN 2002, SINCE THEY WERE AWARE THAT VANS FROM 1998 TO 2002 WERE SUBJECT TO THIS. THEY CALLED IT A "COSMETIC PROBLEM". ANY PROBLEM THAT WILL CAUSE A METAL OBJECT SEVERAL FEET LONG TO VIOLENTLY AND SUDDENLY EXPLODE THROUGH THE DASH INTO THE PASSENGER COMPARTMENT AT THE DRIVER IS HARDLY A "COSMETIC PROBLEM". "COSMETIC PROBLEMS" DO NOT RENDER A VEHICLE UNSAFE TO DRIVE. CHRYSLER HAS ACKNOWLEDGED THE PROBLEM AND REDESIGNED THE STRUT TOWER TO ELIMINATE THIS IN LATER MODELS. NOW THEY NEED TO RECALL THE VEHICLES THAT ARE RUSTING OUT BEFORE PEOPLE DIE! *TR
NHTSA ODI #10244159
Mileage unknown · May 25, 2008
Suspension
NOTICED THAT THE DRIVER SIDE FRONT STRUT SUPPORT IS SEVERELY RUSTED, AS IS THE CASE WITH NUMEROUS OTHER OWNERS OF THIS VEHICLE. THIS MUST BE A FACTORY DEFECT SINCE IT SEEMS TO OCCUR PRIMARILY ON THE LEFT FRONT. THIS IS A DANGEROUS DEFECT. *TR
NHTSA ODI #10228878
90,000 miles · Oct 16, 2007
Suspension
EXCESSIVE RUST ON FRONT INTERIOR STRUT TOWER MOUNT; ADVISED BY MECHANIC THAT IS A SAFETY CONCERN. *JB
NHTSA ODI #10205863
60,000 miles · Feb 19, 2007
Suspension
STRUT TOWER INSIDE OF HOOD IS ALMOST RUSTED THROUGH. MECHANIC SAID THAT IT COULD CAUSE STRUT TO BREAK THROUGH AND COLLAPSE WHILE DRIVING. THE STRUT TOWER IS PROTECTED FROM THE WEATHER. WHY IS IT RUSTING OUT? *JB
NHTSA ODI #10182930
89,000 miles · Nov 27, 2006
StructureSuspension
DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, A NOISE WAS HEARD. THE VEHICLE WAS DRIVEN TO AN INDEPENDENT REPAIR SHOP, WHO DETERMINED THE FRONT DRIVER SIDE STRUT TOWER WAS RUSTED AND NEEDED TO BE REPLACED. UPDATD 01/19/07. *JB
NHTSA ODI #10174372
108,430 miles · Sep 21, 2006
Suspension
DT*: THE CONTACT STATED WHILE PERFORMING A NORMAL MAINTENANCE INSPECTION AT THE DEALER, IT WAS DETERMINED THE LEFT FRONT STRUT AND STRUT TOWER WAS CORRODED. THE VEHICLE WAS EXPOSED TO HARSH WINTER WEATHER AND ROAD SALTS. THE MANUFACTURER WAS NOTIFIED.
NHTSA ODI #10168884
125,000 miles · Sep 10, 2006
Suspension
WHILE DOING GENERAL CAR CARE (CLEANING THE BATTERY) I NOTICED SEVERE RUST ON THE LEFT STRUT TOWER AT THE SPRING SEAT. THE AREA IS SUPPORTING THE WEIGHT OF THE VEHICLE AND IF IT FAILS WILL CAUSE THE LEFT FRONT TIRE TO MOVE INTO CONTACT WITH THE CAR BODY AND PREVENT NORMAL STEERING TO AVOID COLLISIONS. SECONDARILY, SUSPENSION DA…
Read full complaint
WHILE DOING GENERAL CAR CARE (CLEANING THE BATTERY) I NOTICED SEVERE RUST ON THE LEFT STRUT TOWER AT THE SPRING SEAT. THE AREA IS SUPPORTING THE WEIGHT OF THE VEHICLE AND IF IT FAILS WILL CAUSE THE LEFT FRONT TIRE TO MOVE INTO CONTACT WITH THE CAR BODY AND PREVENT NORMAL STEERING TO AVOID COLLISIONS. SECONDARILY, SUSPENSION DAMPERS CANNOT BE REPLACED SINCE THE STRUT COULD NOT BE RE-ATTACHED. POOR DAMPER CONDITION OF COURSE AFFECTS THE DRIVERS ABILITY TO CONTROL THE VEHICLE ON IMPERFECT PAVEMENT. *JB
NHTSA ODI #10167780
Mileage unknown · Aug 23, 2006
StructureSuspension
STRUT TOWER HAS SEVERE RUSTING THAT MAY LEAD TO A COLLAPSE ON THE FRONT TIRE. *JB
NHTSA ODI #10166289
67,000 miles · May 16, 2006
Suspension
THE DRIVER SIDE SHOCK ABSORBER TOWER ON A 99 CHRYSLER TOWN AND COUNTRY HAS RUSTED THROUGH LOSING SUPPORT FOR THE SHOCK ABSORBER. HAVE CHECKED OTHER 99 CHRYSLER TOWN AND COUNTRY VANS AND THEY ALL HAVE THE SAME PROBLEM. *JB
NHTSA ODI #10157625
88,800 miles · Mar 2, 2006
Suspension
DT*: THE CONTACT STATED THE FRONT END MADE A NOISE AT ANY SPEED. THE DEALERSHIP DETERMINED THE DRIVER SIDE STRUT TOWER WAS SEVERLY RUSTED AND WAS ON THE VERGE OF COLLAPSING. THE DEALER SUGGESTED THAT THE VEHICLE BE TAKEN TO AN AUTO BODY SHOP. THEY SUGGESTED THE MANUFACTURER BE ALERTED. UPDATED 4/4/2006 - *NM
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: CERTAIN VAN, WAGON, PICKUP TRUCKS, PASSENGER AND SPORT UTILITY VEHICLES, FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE FRONT SEAT BELT RETRACTOR MAY NOT COMPLY WITH THE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: IF THE RETRACTOR DOES NOT WORK PROPERLY, IT WILL NOT ADEQUATELY PROTECT OCCUPANTS IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SEAT BELT RETRACTOR. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8
EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
PE04017 · Overheating Of Seat Heaters
Opened Feb 18, 2004 · Closed Jun 21, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
ODI OPENED THIS INVESTIGATION BASED ON 24 COMPLAINTS ALLEGING THAT THE ELECTRICALLY HEATED DRIVER OR PASSENGER SEAT SPARKS/OVERHEATS.DAIMLERCHRYSLER BELIEVES THE FAILURE IS DUE TO ONE OF TWO FACTORS:THE STITCHING OPERATION ON THE SEAT COVER MAY CAUSE THE SEWING NEEDLE TO SEVER SOME STRANDS OF THE WIRE HEATING GRID IN THE SEAT, OR A POOR SOLDER JOINT/WIRE CONNECTOR FAILS DUE TO IMPROPER PROCESSING OR LONG TERM OVERSTRESSING.THE IGNITION SWITCH AND THE SEAT HEATER SWITCH MUST BOTH BE TURNED ON TO POWER THE SEAT HEATER.COMPLAINANTS REPORT THAT WHEN OVERHEATING OCCURS, SWITCHING THE HEATER OFF ALSO STOPS THE OVERHEATING.THE FAILURE CANNOT OCCUR IN AN UNATTENDED VEHICLE WITH THE IGNITION SWITCH OFF.ODI FINDS THAT THE 33 FIRE ALLEGATIONS ARE REPORTING VERY LOCALIZED OVERHEATING(PHOTOS OF DAMAGED SEATS SHOW HOLES THE SIZE OF A PENCIL OR LESS).THERE ARE NO REPORTS OF SUSTAINED COMBUSTION AND NO REPORTS OF OTHER FIRE DAMAGE TO THE VEHICLE.THE INJURY ALLEGATIONS ARE REPORTING MINOR INJURY.NO CONSUMERS REQUIRED MEDICAL TREATMENT (PHYSICIAN CARE).THERE ARE NO ALLEGATIONS OF LOSS OF VEHICLE CONTROL DUE TO FAILURE OF A HEATED SEAT.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
RQ04001 · Driver Air Bag Clockspring Failure
Opened Jan 28, 2004 · Closed Jun 4, 2004
Status: closed (inferred from source dates) · Air Bags:frontal
COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE00034 · Overheating Of Front Seat Heaters
Opened Aug 31, 2000 · Closed Jan 5, 2001
Status: closed (inferred from source dates) · Electrical System
ALLEGE THAT THE FRONT SEATS OVER HEAT AND SMOKE OR CATCH FIRE
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
1999 Chrysler Town And Country Problems, Complaints & Recalls | Skip That Year
Illustration