NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
17 reportsClear category filterMileage unknown · Jun 5, 2024
StructureSuspension
Strut mounts are very rusty, the Chrysler recommended repair could not be done, due to extensive rust around the strut tower. This is confirmed by many other owners of this year and generation of vehicle. The vehicle is is good shape except for this and the problem was caused by a manufacturing defect which allowed rusting in th…
Read full complaint
Strut mounts are very rusty, the Chrysler recommended repair could not be done, due to extensive rust around the strut tower. This is confirmed by many other owners of this year and generation of vehicle. The vehicle is is good shape except for this and the problem was caused by a manufacturing defect which allowed rusting in the strut towers. This problem started happening approximately when it was just 10 years old or less and got worse and worse over the years. I have not driven it for many years because it seems very unsafe.
NHTSA ODI #11592632
111,795 miles · Jul 30, 2012
Electrical SystemEngineService Brakes
IT HAD BEEN RAINING BUT HAD STOPPED. I WAS MAKING A RIGHT HAND TURN WHEN MY RIGHT TIRE WENT THROUGH APPROXIMATELY 2-4" OF WATER IN THE GUTTER. I IMMEDIATELY LOST CONTROL OF THE STEERING AND VEERED INTO THE OPPOSITE LANE. FORTUNATELY THERE WERE NO CARS IN THAT LANE. I HAD DIFFICULTY STEERING AND THE ENGINE BEGAN TO OVERHEAT.…
Read full complaint
IT HAD BEEN RAINING BUT HAD STOPPED. I WAS MAKING A RIGHT HAND TURN WHEN MY RIGHT TIRE WENT THROUGH APPROXIMATELY 2-4" OF WATER IN THE GUTTER. I IMMEDIATELY LOST CONTROL OF THE STEERING AND VEERED INTO THE OPPOSITE LANE. FORTUNATELY THERE WERE NO CARS IN THAT LANE. I HAD DIFFICULTY STEERING AND THE ENGINE BEGAN TO OVERHEAT. I WAS FORTUNATE THE GARAGE WAS AROUND THE CORNER. THE BELT HAD SLIPPED OFF THE PULLEYS. THE BELT HAD NOT BROKEN, ONLY SLIPPED OFF. THEY SAID I WAS THE 3RD TOWN AND COUNTRY THAT DAY THAT HAD TO HAVE THE BELT PUT BACK ON DUE TO THE WET WEATHER, AND THAT IT WAS A PROBLEM WITH MODEL FOR MANY YEARS. THIS IS THE 3RD TIME TO SEND THIS REPORT. WHEN I HIT "VERIFY" EVERYTHING GOES BLANK. *TR
NHTSA ODI #10468365
130,000 miles · May 27, 2010
Structure
DRIVERS SIDE STRUT TOWER IS VERY RUSTY, VERY CLOSE TO ALLOWING THE STRUT TO PUSH THROUGH THE HOUSING. CHRYSLER HAS A REPAIR KIT AVAILABLE, I HAVE SEEN THE PROBLEM ON COUNTLESS CHRYSLER AND DODGE VANS 1998-2001. *TR
NHTSA ODI #10332489
120,000 miles · Jan 5, 2009
Electrical SystemStructure
1999 CHRYSLER TOWN AND COUNTRY THE DASH LOSE FUNCTION, DRIVING WITHOUT SPEED AND THE REST OF THE FUNCTION. *TR
NHTSA ODI #10253857
100,000 miles · Nov 26, 2008
StructureSuspension
1. POOR QUALITY 2. FRONT STRUT TOWER IS RUSTED THROUGH. STRUTS ARE WOBBLING INSIDE THE STAMPED BODY HOUSING (PART OF THE UNIBODY). THE RUST IS SO BAD I'M AFRAID THE STRUT IS GOING TO PUNCH THROUGH AT ANY TIME LEAVING THE VEHICLE LIKELY TO CRASH DISASTROUSLY. 3. NOTHING SO FAR. *TR
NHTSA ODI #10249941
Mileage unknown · Nov 4, 2008
StructureSuspension
THE DRIVER SIDE SHOCK ABSORBER TOWER ON A 1999 CHRYSLER TOWN AND COUNTRY HAS RUSTED THROUGH LOSING SUPPORT FOR THE SHOCK ABSORBER. HAVE CHECKED OTHER 1999 AND 2000 CHRYSLER TOWN AND COUNTRY VANS AND THEY ALL HAVE THE SAME PROBLEM. WHAT IS BEING DONE TO CORRECT THIS PROBLEM? THANKS, GPS *TR
NHTSA ODI #10247656
90,000 miles · Oct 14, 2008
Structure
1999 CHRYSLER TOWN AND COUNTRY RUSTING STRUT TOWER HAS PROGRESSIVELY WORSENED SINCE BY DEALER, IN 2005, TOLD ME THAT IT IS ONLY A "COSMETIC DEFECT" AND IS A POTENTIAL DANGER OF RUSTING THROUGH. THIS IS A CRITICAL SAFETY ISSUE AND HAS BEEN MISCLASSIFIED BY CHRYSLER. I NOW READ ON THE WEB SITE THAT MORE OWNERS ARE SIMILARLY AFF…
Read full complaint
1999 CHRYSLER TOWN AND COUNTRY RUSTING STRUT TOWER HAS PROGRESSIVELY WORSENED SINCE BY DEALER, IN 2005, TOLD ME THAT IT IS ONLY A "COSMETIC DEFECT" AND IS A POTENTIAL DANGER OF RUSTING THROUGH. THIS IS A CRITICAL SAFETY ISSUE AND HAS BEEN MISCLASSIFIED BY CHRYSLER. I NOW READ ON THE WEB SITE THAT MORE OWNERS ARE SIMILARLY AFFECTED. *TR
NHTSA ODI #10245350
Mileage unknown · Oct 1, 2008
StructureSuspension
TOOK VAN IN FOR SLIGHT ENGINE NOISE AND MECHANIC NOTICED THAT STRUT TOWER WAS NEARLY RUSTED THROUGH. TOOK TO THE DEALER WHO STATED THAT THE CAR WAS UNSAFE TO DRIVE UNDER ANY CIRCUMSTANCES SINCE ONE ROUGH PIECE OF ROAD AND THE CAR BODY COULD FALL TO THE GROUND AND THE STRUT ASSEMBLY COME THROUGH THE DASH INTO THE PASSENGER COMPA…
Read full complaint
TOOK VAN IN FOR SLIGHT ENGINE NOISE AND MECHANIC NOTICED THAT STRUT TOWER WAS NEARLY RUSTED THROUGH. TOOK TO THE DEALER WHO STATED THAT THE CAR WAS UNSAFE TO DRIVE UNDER ANY CIRCUMSTANCES SINCE ONE ROUGH PIECE OF ROAD AND THE CAR BODY COULD FALL TO THE GROUND AND THE STRUT ASSEMBLY COME THROUGH THE DASH INTO THE PASSENGER COMPARTMENT. THIS WILL NOW COST OVER 1500.00 TO REPAIR. CHRYSLER ISSUED A SERVICE BULLETIN ON THIS IN 2002, SINCE THEY WERE AWARE THAT VANS FROM 1998 TO 2002 WERE SUBJECT TO THIS. THEY CALLED IT A "COSMETIC PROBLEM". ANY PROBLEM THAT WILL CAUSE A METAL OBJECT SEVERAL FEET LONG TO VIOLENTLY AND SUDDENLY EXPLODE THROUGH THE DASH INTO THE PASSENGER COMPARTMENT AT THE DRIVER IS HARDLY A "COSMETIC PROBLEM". "COSMETIC PROBLEMS" DO NOT RENDER A VEHICLE UNSAFE TO DRIVE. CHRYSLER HAS ACKNOWLEDGED THE PROBLEM AND REDESIGNED THE STRUT TOWER TO ELIMINATE THIS IN LATER MODELS. NOW THEY NEED TO RECALL THE VEHICLES THAT ARE RUSTING OUT BEFORE PEOPLE DIE! *TR
NHTSA ODI #10244159
87,688 miles · Apr 2, 2008
Structure
WHILE DRIVING, THE LEFT REAR PASSENGER DOOR WILL OPEN ON ITS OWN. ALL DOORS ARE LOCKED BEFORE I START THE CAR. THIS FIRST BEGAN LAST JUNE, WHILE DRIVING ON THE HIGHWAY AT APPROXIMATELY 55 MPH. IT HAPPENED ABOUT ONCE EVERY 2-3 MONTHS. NOW IT IS HAPPENING AT LEAST 2 TIMES A WEEK. I AM SCARED BECAUSE I HAVE NO INDICATION PRIOR…
Read full complaint
WHILE DRIVING, THE LEFT REAR PASSENGER DOOR WILL OPEN ON ITS OWN. ALL DOORS ARE LOCKED BEFORE I START THE CAR. THIS FIRST BEGAN LAST JUNE, WHILE DRIVING ON THE HIGHWAY AT APPROXIMATELY 55 MPH. IT HAPPENED ABOUT ONCE EVERY 2-3 MONTHS. NOW IT IS HAPPENING AT LEAST 2 TIMES A WEEK. I AM SCARED BECAUSE I HAVE NO INDICATION PRIOR TO ITS HAPPENING. A LOT OF THE TIME THERE IS NO PLACE FOR ME TO PULL OVER TO CLOSE THE DOOR. THEN I AM AFRAID THE VAN WILL CUT OFF BECAUSE THE OPEN DOOR LIGHT STAYS ON WHILE I AM DRIVING. THIS CAR HAS A LITTLE OVER 88,000 MILES. I BOUGHT THIS CAR USED 2-3 YEARS AGO. *TR
NHTSA ODI #10223142
90,000 miles · Feb 18, 2008
Air BagsElectrical SystemStructure
NO CRASH INVOLVED...NOTICED AFTER A RAINSTORM HERE ON THE COAST, THAT THERE WAS THE SOUND OF WATER ROLLING BACK AND FORTH IN THE DASH AREA WHEN I WAS DRIVING..NOT ONLY THAT, BUT THERE WAS A SIGNIFICANT(HUGE FLOOD) OF WATER COMING INTO THE PASSENGER COMPARTMENT FROM THE DASH AREA IMMEDIATELY IN FRONT OF THE PASSENGER SEAT...ENOUG…
Read full complaint
NO CRASH INVOLVED...NOTICED AFTER A RAINSTORM HERE ON THE COAST, THAT THERE WAS THE SOUND OF WATER ROLLING BACK AND FORTH IN THE DASH AREA WHEN I WAS DRIVING..NOT ONLY THAT, BUT THERE WAS A SIGNIFICANT(HUGE FLOOD) OF WATER COMING INTO THE PASSENGER COMPARTMENT FROM THE DASH AREA IMMEDIATELY IN FRONT OF THE PASSENGER SEAT...ENOUGH WATER THAT MY CARPETING WAS COMPLETELY SOAKED, AND RUINED. AFTER THIS HAPPENED MANY TIMES..I FINALLY FIGURED OUT WHAT IT WAS..THERE IS SOME SORT OF DRAIN HOSE TO A WATER COLLECTION RESERVOIR UNDER THE WINDSHIELD...WHICH CAN BE DISCONNECTED TO DRAIN, BUT IN THE EVENT OF DEBRIS WASHING INTO IT...WOULD CLOG UP AND OVERFLOW..RESULTING IN THE DESCRIBED CONDITION..THIS IS VERY POOR DESIGN IN MY OPINION..SOME OF FOLKS I HAVE HAD THIS TO..DID NOT HAVE A CLUE WHAT WAS GOING ON...I HAVE NOT SAID ANYTHING TO CHRYSLER ABOUT THIS...BUT THINK IT IS NOT JUST ME WHO HAS THE ISSUE..AND IT ALSO COULD BE A CONTRIBUTOR TO SOME OF THE OTHER ISSUES I HAVE READ ABOUT..PARTICULARLY THE CONDENSATION ISSUE AND THE AIRBAG ISSUE..I AM CONCERNED THAT THE ELECTRONICS WILL FAIL...PLEASE ADVISE...I AM PICKING A RANDOM DATE WHEN IT FIRST HAPPENED...ALSO..HAS OCCURRED MANY TIMES SINCE UNLESS I CLEAN THE DRAIN HOSES...NEVER HAD THIS HAPPEN ON ANY OTHER VEHICLE...? *TR
NHTSA ODI #10218438
Official recalls
4Oct 6, 2004
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Mar 8, 2002
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Apr 11, 2001
VEHICLE DESCRIPTION: CERTAIN VAN, WAGON, PICKUP TRUCKS, PASSENGER AND SPORT UTILITY VEHICLES, FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE FRONT SEAT BELT RETRACTOR MAY NOT COMPLY WITH THE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: IF THE RETRACTOR DOES NOT WORK PROPERLY, IT WILL NOT ADEQUATELY PROTECT OCCUPANTS IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SEAT BELT RETRACTOR. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
PE04017 · Overheating Of Seat Heaters
Opened Feb 18, 2004 · Closed Jun 21, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
ODI OPENED THIS INVESTIGATION BASED ON 24 COMPLAINTS ALLEGING THAT THE ELECTRICALLY HEATED DRIVER OR PASSENGER SEAT SPARKS/OVERHEATS.DAIMLERCHRYSLER BELIEVES THE FAILURE IS DUE TO ONE OF TWO FACTORS:THE STITCHING OPERATION ON THE SEAT COVER MAY CAUSE THE SEWING NEEDLE TO SEVER SOME STRANDS OF THE WIRE HEATING GRID IN THE SEAT, OR A POOR SOLDER JOINT/WIRE CONNECTOR FAILS DUE TO IMPROPER PROCESSING OR LONG TERM OVERSTRESSING.THE IGNITION SWITCH AND THE SEAT HEATER SWITCH MUST BOTH BE TURNED ON TO POWER THE SEAT HEATER.COMPLAINANTS REPORT THAT WHEN OVERHEATING OCCURS, SWITCHING THE HEATER OFF ALSO STOPS THE OVERHEATING.THE FAILURE CANNOT OCCUR IN AN UNATTENDED VEHICLE WITH THE IGNITION SWITCH OFF.ODI FINDS THAT THE 33 FIRE ALLEGATIONS ARE REPORTING VERY LOCALIZED OVERHEATING(PHOTOS OF DAMAGED SEATS SHOW HOLES THE SIZE OF A PENCIL OR LESS).THERE ARE NO REPORTS OF SUSTAINED COMBUSTION AND NO REPORTS OF OTHER FIRE DAMAGE TO THE VEHICLE.THE INJURY ALLEGATIONS ARE REPORTING MINOR INJURY.NO CONSUMERS REQUIRED MEDICAL TREATMENT (PHYSICIAN CARE).THERE ARE NO ALLEGATIONS OF LOSS OF VEHICLE CONTROL DUE TO FAILURE OF A HEATED SEAT.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
RQ04001 · Driver Air Bag Clockspring Failure
Opened Jan 28, 2004 · Closed Jun 4, 2004
Status: closed (inferred from source dates) · Air Bags:frontal
COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE00034 · Overheating Of Front Seat Heaters
Opened Aug 31, 2000 · Closed Jan 5, 2001
Status: closed (inferred from source dates) · Electrical System
ALLEGE THAT THE FRONT SEATS OVER HEAT AND SMOKE OR CATCH FIRE
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
Illustration