NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
45 reportsClear category filter32,000 miles · Apr 1, 2008
Steering
LEAKING STEERING RACK AND SOLENOID PACK. POSSIBLE LEAK IN STEERING PUMP ALSO. SAFETY OF TIE ROD ENDS, BUSHINGS, SWAY BARS, CONTROL ARMS NOTED IN INSPECTION OF FRONT END BOTH BY A CHRYSLER DEALER AND BY AN AUTO-REPAIR CHAIN. BOTH RECOMMENDED REPLACEMENT OF PARTS (IN SHOP RIGHT NOW) TO ELIMINATE A SAFETY RISK. IN SPEAKING TO ANOT…
Read full complaint
LEAKING STEERING RACK AND SOLENOID PACK. POSSIBLE LEAK IN STEERING PUMP ALSO. SAFETY OF TIE ROD ENDS, BUSHINGS, SWAY BARS, CONTROL ARMS NOTED IN INSPECTION OF FRONT END BOTH BY A CHRYSLER DEALER AND BY AN AUTO-REPAIR CHAIN. BOTH RECOMMENDED REPLACEMENT OF PARTS (IN SHOP RIGHT NOW) TO ELIMINATE A SAFETY RISK. IN SPEAKING TO ANOTHER OWNER OF THIS SAME YEAR AND MODEL OF CAR WITH LOW MILEAGE, I LEARNED THAT HE HAS EXPERIENCED THE SAME PROBLEMS. *TR
NHTSA ODI #10223003
69,350 miles · May 28, 2007
Steering
1) HEARD OCCASIONAL "CLICKING" NOISE IN STEERING. DID NOT EXPERIENCE STEERING PROBLEMS. 2) ON SATURDAY, MAY 26TH, THE TIE ROD BROKE WHILE TURNING A CORNER, STOPPING THE VEHICLE INSTANTLY. FORTUNATELY, THE CATASTROPHIC FAILURE OCCURRED AT LOW SPEED. 3) THE CAR WAS TOWED BY AAA TO A NEARBY CAR MAINTENANCE CENTER. *TR
NHTSA ODI #10191847
20,000 miles · Mar 5, 2007
SteeringFire
TL*- THE CONTACT STATED THAT WHILE DRIVING THE 2002 CHRYSLER PT CRUISER AT45 MPH SHE SMELLED SMOKE. AFTER DRIVING TWO MILES MORE THERE WERE FLAMES AND ASHES COMING FROM UNDER THE HOOD. THE CONTACT STATED SHE PULLED OFF THE ROAD, EXITED THE VEHICLE, AND REMOVED HER PERSONAL BELONGINGS. ATC APPROXIMATELY 15 SECONDS LATER THE VEH…
Read full complaint
TL*- THE CONTACT STATED THAT WHILE DRIVING THE 2002 CHRYSLER PT CRUISER AT45 MPH SHE SMELLED SMOKE. AFTER DRIVING TWO MILES MORE THERE WERE FLAMES AND ASHES COMING FROM UNDER THE HOOD. THE CONTACT STATED SHE PULLED OFF THE ROAD, EXITED THE VEHICLE, AND REMOVED HER PERSONAL BELONGINGS. ATC APPROXIMATELY 15 SECONDS LATER THE VEHICLE WAS COMPLETED ENGULFED IN FLAMES. THE ROADS WERE CLEAR. THE CONTACT STATED THERE WAS A FIRE DEPARTMENT REPORT AVAILABLE. THE FIRE MARSHALL WAS UNABLE TO INSPECT THE VEHICLE TO DETERMINE TO THE CAUSE OF THE FIRE. THE VEHICLE WAS DECLARED A TOTAL LOSS BY THE INSURANCE COMPANY. SHE RECEIVED A RECALL NOTICE FOR THE FUEL PUMP MODULE SECONDARY SEAL ON AUGUST 30 2004 AND HAD IT REPLACED AT 8900 MILES. TALSO, HE CONTACT STATED SHE RECEIVED A RECALL FOR POWER STEERING PRESSURE HOSE ON AUGUST 11TH 2005 AT 14000 MILES. THE CONTACT WAS UNSURE IF THE POWER STEERING PRESSURE HOSE WAS REPLACED, ADJUSTED OR INSPECTED. THE VEHICLE HAD 20000 MILES AT THE TIME OF THE FIRE. *AK
NHTSA ODI #10184202
32,754 miles · Apr 7, 2006
Steering
DT*: THE CONTACT STATED A LEAK WAS DETECTED IN THE POWER STEERING HOSE. A NHTSA RECALL, 04V268000 WAS PERFORMED ON THE VEHICLE CONCERNING, THE POWER STEERING HOSE, HOWEVER THE RECALL DID NOT REMEDY THE PROBLEM. THE DEALERSHIP WOULD NOT OFFER A SECOND REPAIR WITHOUT CHARGE UNDER THE RECALL.
NHTSA ODI #10154798
3,000 miles · Nov 15, 2005
Steering
DT: THE CONTACT STATES THERE IS A NHTSA CAMPAIGN ID NUMBER 04V268000 CONCERNING THE STEERING POWER ASSIST HOSE PIPING AND CONNECTIONS. THE CONSUMER IS EXPERIENCING THE SAME SYMPTOMS AS INDICATED IN THE RECALL BUT THE VEHICLE IDENTIFICATION NUMBER WAS NOT INCLUDED IN THE RECALL. NO REPAIRS HAVE BEEN MADE AT THIS TIME DUE TO TH…
Read full complaint
DT: THE CONTACT STATES THERE IS A NHTSA CAMPAIGN ID NUMBER 04V268000 CONCERNING THE STEERING POWER ASSIST HOSE PIPING AND CONNECTIONS. THE CONSUMER IS EXPERIENCING THE SAME SYMPTOMS AS INDICATED IN THE RECALL BUT THE VEHICLE IDENTIFICATION NUMBER WAS NOT INCLUDED IN THE RECALL. NO REPAIRS HAVE BEEN MADE AT THIS TIME DUE TO THE EXPENSE. *JB
NHTSA ODI #10142712
Mileage unknown · Oct 25, 2005
Steering
CONSUMER LETTER REGARDING RECALL ON POWER STEERING HOSE. *TS THE CONSUMER HAD DIFFICULTY GETTING HER VEHICLE INSPECTED, SHE WAS ALWAYS GETTING THE RUN AROUND FROM THE DEALER. RECALL #04V268000. *JB
NHTSA ODI #10141067
16,383 miles · Aug 22, 2005
Steering
BOTH FRONT LOWER CONTROL ARM BUSHINGS WERE WORN AND PUSHED OUT OF CONTROL ARM. REPLACEMENT REQUIRED TO PASS NY STATE INSPECTION, THEREFORE THIS IS A SAFETY ITEM. VEHICLE HAS ONLY 16383 MILES.
NHTSA ODI #10133769
43,128 miles · Aug 19, 2005
Steering
DT: THE CONSUMER TOOK THE VEHICLE TO A SERVICE DEALER FOR RECALL CAMPAIGN 04V268000 REPAIR WORK FOR THE POWER STEERING HOSE ON 6/7/05. SHE RECEIVED ANOTHER RECALL LETTER YESTERDAY WITH THE SAME INFORMATION, AND WHEN SHE CALLED THE DEALER SHE DISCOVERED THAT THE RECALL WORK WAS NOT COMPLETED. THE DEALER PICKED THE VEHICLE UP AT…
Read full complaint
DT: THE CONSUMER TOOK THE VEHICLE TO A SERVICE DEALER FOR RECALL CAMPAIGN 04V268000 REPAIR WORK FOR THE POWER STEERING HOSE ON 6/7/05. SHE RECEIVED ANOTHER RECALL LETTER YESTERDAY WITH THE SAME INFORMATION, AND WHEN SHE CALLED THE DEALER SHE DISCOVERED THAT THE RECALL WORK WAS NOT COMPLETED. THE DEALER PICKED THE VEHICLE UP AT THE OWNER'S BUSINESS FOR SERVICE BECAUSE THE DEALER WAS LOCATED MORE THE 47 MILES FROM THE VEHICLE OWNER. THE OWNER'S CONCERN WAS THAT THE RECALL WORK WAS NOT COMPLETED IN THE FIRST PLACE. THE ONLY THING THE OWNER NOTICED WAS THAT THERE WAS A NOISE IN THE FRONT OF THE VEHICLE BEFORE THE RECALL NOTICE WAS RECEIVED. WHEN THE OWNER HAD THE VEHICLE INSPECTED BY HER MECHANIC, SHE WAS TOLD THAT THE BEARINGS WERE OUT. THIS IS WHAT LED THE OWNER TO TAKE THE VEHICLE TO A SERVICE DEALER FOR THE RECALL WORK IN THE FIRST PLACE. THIS LED TO THE CHAIN OF EVENTS LISTED ABOVE WITH THE INCOMPLETE RECALL WORK. *AK *SC
NHTSA ODI #10127692
Mileage unknown · Mar 4, 2005
Steering
RECALL CAMPAIGN 04V268000 CONCERNING POWER STEERING HOSE ASSEMBLY. AFTER THE VEHICLE BEEN AT THE DEALER FOR DAYS HE TOLD CONSUMER TO PICK UP THE VEHICLE, AND THAT THE RECALL REPAIRS WERE NOT DONE BECAUSE IT WAS NOT MENTONED ON THE WORK ORDER.*AK
NHTSA ODI #10113474
49,000 miles · Feb 9, 2005
SteeringCrash
WHILE DRIVING AT 35 MPH DRIVER SWERVED TO THE LEFT TO AVOID HITTING ANOTHER VEHICLE. THE REAR RIGHT WHEEL CAME OFF AT THE SPINDLE WHEN THE STEERING WHEEL WAS TURNED BACK TO THE RIGHT. THIS RESULTED IN THE DRIVER LOSING CONTROL OF THE VEHICLE AND DRIVING INTO A DITCH. SEVERAL MECHANICS INSPECTED THE VEHICLE, AND INDICATED THAT…
Read full complaint
WHILE DRIVING AT 35 MPH DRIVER SWERVED TO THE LEFT TO AVOID HITTING ANOTHER VEHICLE. THE REAR RIGHT WHEEL CAME OFF AT THE SPINDLE WHEN THE STEERING WHEEL WAS TURNED BACK TO THE RIGHT. THIS RESULTED IN THE DRIVER LOSING CONTROL OF THE VEHICLE AND DRIVING INTO A DITCH. SEVERAL MECHANICS INSPECTED THE VEHICLE, AND INDICATED THAT THE 4 SPINDLE BOLTS WERE STRIPPED WHICH CAUSED THE WHEEL TO SEPARATE. *AK
NHTSA ODI #10111240
Official recalls
3Jun 3, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 8, 2002
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP MODULE MOUNTING FLANGE COULD LEAK FUEL IF THE VEHICLE IS INVOLVED IN A ROLLOVER CRASH.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SECONDARY SEAL OVER THE FUEL PUMP MODULE. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Sep 10, 2001
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES ARE BEING RECALLED FOR A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER MICROPROCESSOR. UNDER CERTAIN CONDITIONS, THE CLUSTER, WITH THE MAJORITY OF ITS GAUGES, ILLUMINATION, AND WARNING LAMPS, COULD BECOME INOPERATIVE.
Consequence & remedy
Consequence: DRIVING THE VEHICLE WITH AN INOPERATIVE CLUSTER COULD CAUSE A DISTRACTION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL RE-FLASH THE CLUSTER SOFTWARE TO CORRECT THE CONDITION. OWNER NOTIFICATION BEGAN OCTOBER 8, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
Illustration