NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
35 reportsClear category filter83,500 miles · Jun 5, 2016
Power Train
ENGINE STARTS AND RUNS, BUT AS SOON AS I PUT IT INTO ANY GEAR BUT PARK, THE CAR IMMEDIATELY DIES. IT WILL RESTART, BUT AGAIN DIES WHEN PLACED IN A GEAR. THE CHECK ENGINE LIGHT CAME ON SO I HAD MY MECHANIC LOOK AT IT. HE CHECKED FOR CODES AND THIS IS THE CODE THAT CAME UP (P0601). IT HAS 83500 MILES. HE SAYS IT NEED A NEW COMPUTE…
Read full complaint
ENGINE STARTS AND RUNS, BUT AS SOON AS I PUT IT INTO ANY GEAR BUT PARK, THE CAR IMMEDIATELY DIES. IT WILL RESTART, BUT AGAIN DIES WHEN PLACED IN A GEAR. THE CHECK ENGINE LIGHT CAME ON SO I HAD MY MECHANIC LOOK AT IT. HE CHECKED FOR CODES AND THIS IS THE CODE THAT CAME UP (P0601). IT HAS 83500 MILES. HE SAYS IT NEED A NEW COMPUTER. THIS INITIALLY STARTED BACKING INTO TRAFFIC, THE CAR JUST QUIT. I STARTED IT BACK UP AND WENT TO PUT IT IN DRIVE AND IT AGAIN QUIT. THIS HAPPENS OVER AND OVER, UNTIL SOMEONE PUSHED ME OUT OF THE STREET. CAR IS NOW PARKED UNTIL IT IS REPAIRED.
NHTSA ODI #10872620
Mileage unknown · Oct 5, 2011
Power Train
TL* THE CONTACT OWNS A 2002 CHRYSLER PT CRUISER. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE VEHICLE STOPPED ACCELERATING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP AND THE TRANSMISSION WAS REPLACED. THE FAILURE RECURRED APPROXIMATELY SEVEN YEARS LATER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP AND THE …
Read full complaint
TL* THE CONTACT OWNS A 2002 CHRYSLER PT CRUISER. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE VEHICLE STOPPED ACCELERATING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP AND THE TRANSMISSION WAS REPLACED. THE FAILURE RECURRED APPROXIMATELY SEVEN YEARS LATER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP AND THE CONTACT WAS ADVISED TO REPLACE THE TRANSMISSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10428791
141,145 miles · Mar 9, 2011
Power TrainInjury
CHRYSLER CUSTOMER ASSISTANCE CENTER (KMM7261775V12890L0KM)US CUSTOMER SERVICE - CHRYSLER BRAND SITE BRIEF DESCRIPTION: TRANSMISSION FAILED WITHOUT WARNING 2002PT COMMENTS: I AM VERY BLESSED TO BE ABLE TO SEND THIS EMAIL DUE TO THE FACT AS A PT 2002 OWNER AND A VERY HAPPY ONE JUST HAD THE SCARE OF MY LIFE.WHILE DRIVING AT 65…
Read full complaint
CHRYSLER CUSTOMER ASSISTANCE CENTER (KMM7261775V12890L0KM)US CUSTOMER SERVICE - CHRYSLER BRAND SITE BRIEF DESCRIPTION: TRANSMISSION FAILED WITHOUT WARNING 2002PT COMMENTS: I AM VERY BLESSED TO BE ABLE TO SEND THIS EMAIL DUE TO THE FACT AS A PT 2002 OWNER AND A VERY HAPPY ONE JUST HAD THE SCARE OF MY LIFE.WHILE DRIVING AT 65 MPH MY TRANSMISSION LOCKED UP CAUSING MY PT CRUISER TO LIFT THE BACK WHEELS OFF THE GROUND AND THREW ME INTO THE WINDSHIELD LUCKY FOR ME I HAD MY SAFETY BELT ON.NOW HERE I AM STUCK ON A MAJOR HIGHWAY WITH NO REVERSE AND NO GEARS.I WAS LUCKY ENOUGH TO HAVE IT TOWED TO A GOODYEAR DEALER WHO SAID THE TRANSMISSION IS SHOT. THIS PLACE DOES ALL MY WORK AND I HAVE RECORDS TO PROVE WITH THIS CAR HAS BEEN SERVICE AND WELL TAKING CARE OF. MY CONCERN IS NOW THE TRANSMISSION PLACE SAYS IT WILL COST 2800.00 DOLLARS TO FIX. I WOULD LIKE SOME KIND OF RESPONSE FROM CHRYSLER. THERE RESPONSE WAS WE DONT CARE AND WILL NOT HELP. *TR
NHTSA ODI #10386947
52,000 miles · Jun 30, 2010
Power Train
TL* THE CONTACT OWNS A 2002 CHRYSLER PT CRUISER. THE CONTACT STATED THAT WHILE BACKING OUT OF TRAFFIC, THE LINKAGE ARM HAD COME OFF OF THE TRANSMISSION WHICH WERE HELD ON BY BUSHINGS. THE CAR WOULD NOT MOVE. THE VEHICLE WAS TOWED TO HIS HOME. THE MANUFACTUER HAD NOT BEEN CONTACTED AND THE VEHICLE HAD NOT BEEN REPAIRED. THE …
Read full complaint
TL* THE CONTACT OWNS A 2002 CHRYSLER PT CRUISER. THE CONTACT STATED THAT WHILE BACKING OUT OF TRAFFIC, THE LINKAGE ARM HAD COME OFF OF THE TRANSMISSION WHICH WERE HELD ON BY BUSHINGS. THE CAR WOULD NOT MOVE. THE VEHICLE WAS TOWED TO HIS HOME. THE MANUFACTUER HAD NOT BEEN CONTACTED AND THE VEHICLE HAD NOT BEEN REPAIRED. THE CONTACT STATED HE WILL DO THE REPAIRS HIMSELF. THE FAILURE MILEAGE WAS APPROXIMATELY 52,000.
NHTSA ODI #10340823
124,000 miles · Jun 18, 2009
Power Train
TL*THE CONTACT OWNS A 2002 CHRYSLER PT CRUISER. SINCE MAY OF 2009, THE VEHICLE HAS BEEN STALLING WITHOUT WARNING. THE MOST RECENT FAILURE OCCURRED WHILE DRIVING 30 MPH. AFTER THE FIRST OCCURRENCE, THE CONTACT TOOK THE VEHICLE TO A REPAIR SHOP. THE MECHANIC REPLACED THE POWERTRAIN CONTROL MODULE WITH A USED ONE, BUT THE FAILU…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHRYSLER PT CRUISER. SINCE MAY OF 2009, THE VEHICLE HAS BEEN STALLING WITHOUT WARNING. THE MOST RECENT FAILURE OCCURRED WHILE DRIVING 30 MPH. AFTER THE FIRST OCCURRENCE, THE CONTACT TOOK THE VEHICLE TO A REPAIR SHOP. THE MECHANIC REPLACED THE POWERTRAIN CONTROL MODULE WITH A USED ONE, BUT THE FAILURE WAS NOT CORRECTED. THE POWERTRAIN CONTROL MODULE HAS BEEN REPLACED TWICE. THE DEALER WILL REPLACE THE POWERTRAIN CONTROL MODULE FOR THE THIRD TIME FOR FREE; HOWEVER, THE PART WILL NOT BE AVAILABLE UNTIL TWO WEEKS. THE CURRENT AND FAILURE MILEAGES WERE 124,000.
NHTSA ODI #10274220
Mileage unknown · Feb 15, 2009
Power Train
HAVE A 2002 PT CRUISER WITH EXCESSIVE OIL BURN. REPLACEMENT OF 1 QT. OIL EVERY 750 MILES. BOUGHT CAR NEW IN 02. HAVE HAD THIS PROBLEM SINCE INCEPTION. ADDRESSED PROBLEM TO DEALER IN SALEM, OR. THEY CONTENDED IT WAS NORMAL . I HAVE 58K ON ENGINE NOW AND PROBLEMS STILL CURRENT. *TR
NHTSA ODI #10258694
Mileage unknown · Nov 16, 2008
Power TrainSteeringTires
WAS DRIVING ALONG AND THE TRANSMISSION WENT OUT AT ABOUT 35,598.00 MILES . THE BRAKES MAKE A GOD AWFUL NOISE I HAVE HAD THEM CHECKED THEY SAY NOTHING IS WRONG BUT I DON'T BELIEVE THEM THE BRAIN BOX WENT OUT THE SAME TIME AS THE TRANMISSION. THE DASHBOARD ON TOP HAS CRACKED FOR NO REASON THE CAR IS GARAGE KEPT IT PULLS TO THE RIG…
Read full complaint
WAS DRIVING ALONG AND THE TRANSMISSION WENT OUT AT ABOUT 35,598.00 MILES . THE BRAKES MAKE A GOD AWFUL NOISE I HAVE HAD THEM CHECKED THEY SAY NOTHING IS WRONG BUT I DON'T BELIEVE THEM THE BRAIN BOX WENT OUT THE SAME TIME AS THE TRANMISSION. THE DASHBOARD ON TOP HAS CRACKED FOR NO REASON THE CAR IS GARAGE KEPT IT PULLS TO THE RIGHT FOR NO REASON THEY SAY AND IT HAS STARTED MAKING RATTLING NOISES FROM THE PASSENGER SIDE THE TRUNK LID SHOCKS ARE GIVEN OUT AND THE CAR JUST TURNED TO 40,000.00 MILES I THINK THEY MAKE THEM TO BREAK AT A CERTAIN TINE AND NO ONE WILL DO ANYTHING ABOUT THESES PROBLEMS I THINK MY NEXT CAR MIGHT BE A TOYOTA AT LEAST THEY DON'T FALL APART SO EASY BECAUSE I BABY THIS CAR LIKE ITS THE ONLY ONE I WILL EVER OWN IF CHRYSLER WANTED TO DO THE RIGHT THING THEY WOULD TAKE THIS LEMON BACK AND GIVE ME A NEW ONE FREE OF CHARGE AND I WOULD DO THE CHRYSLER ADVERSEMENT ALL OVER IT FOR THEM AS LONG AS IT LOOKS GOOD . BECAUSE I HAVE NO MONEY FOR ANOTHER NEW AUTOMOBILE HAVE A FAMILY TO TAKE CARE OF AND IM NOT ALLOWED TO WORK ANYMORE THIS WOULD BE A GREAT THIN TANKS FOR LISTENING. *TR
NHTSA ODI #10248916
80,267 miles · Mar 23, 2008
Power Train
THE TRANSMISSION FROM MY PT CRUISER EXPLODED ON I95 NEAR KINGSLAND GA WHILE COMING BACK FROM A TRIP ON 3/3/08. IT HAS A EXCELLENT MAINTAINANCE RECORD ON THIS CAR. ALL SERVICES WHERE DONE WHEN DUE BY A CHRYSLER DEALERSHIP IN HINESVILLE GA, WHERE I PURCHASED THIS CAR NEW IN 2002. I HAVE NEVER HAD ANY INDICATIONS THAT THERE WAS ANY…
Read full complaint
THE TRANSMISSION FROM MY PT CRUISER EXPLODED ON I95 NEAR KINGSLAND GA WHILE COMING BACK FROM A TRIP ON 3/3/08. IT HAS A EXCELLENT MAINTAINANCE RECORD ON THIS CAR. ALL SERVICES WHERE DONE WHEN DUE BY A CHRYSLER DEALERSHIP IN HINESVILLE GA, WHERE I PURCHASED THIS CAR NEW IN 2002. I HAVE NEVER HAD ANY INDICATIONS THAT THERE WAS ANYTHING WRONG WITH MY TRANSMISSION. IT NEVER MADE ANY STRANGE NOISE, LEAKED TRANSMISSION FLUID, SKIPPED GEARS..AND JUST LIKE THAT IT EXPLODED. IT HAD A COMPLETE TUNE UP PERFORMED ON PT CRUISER SEPT 2007. I HAD TO HAVE IT TOWED TO THE NEAREST CHRYSLER DEALERSHIP IN KINGSLAND GA. TRANSMISSION NEEDED TO BE REPLACED WITH A COST OF $3,484.66 A TRANSMISSION SHOULD NOT HAVE EXPLODED WITH 80267 MILES. I FEEL OVERALL THERE IS A PROBLEM WITH PT CRUISERS TRANSMISSIONS AND THIS SHOULD BE COVERED UNDER WARRANTY. *TR
NHTSA ODI #10222048
95,000 miles · Mar 11, 2008
Power Train
TL*THE CONTACT OWNS A 2002 CHRYSLER PT CRUISER. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE HESITATED AND NEVER SWITCHED FROM SECOND GEAR. THE ENGINE JUST KEPT REVVING. THE CONTACT DROVE TO A SAFE AREA AND SHUT OFF THE VEHICLE. THE VEHICLE MADE A SOUND AS IF IT FAILED COMPLETELY. THE VEHICLE WAS TOWED TO A DEALER AND TH…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHRYSLER PT CRUISER. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE HESITATED AND NEVER SWITCHED FROM SECOND GEAR. THE ENGINE JUST KEPT REVVING. THE CONTACT DROVE TO A SAFE AREA AND SHUT OFF THE VEHICLE. THE VEHICLE MADE A SOUND AS IF IT FAILED COMPLETELY. THE VEHICLE WAS TOWED TO A DEALER AND THEY STATED THAT THEY DID NOT HAVE ENOUGH TIME TO GET AN ACCURATE DIAGNOSIS. THE VEHICLE STILL HAS NOT BEEN REPAIRED. THE CURRENT MILEAGE WAS 97,000 AND FAILURE MILEAGE WAS 95,000.
NHTSA ODI #10220771
86,623 miles · Mar 3, 2008
Power Train
WHILE DRIVING, THE AUTOMATIC TRANSMISSION SLIPPED OUT OF GEAR, RENDERING THE VEHICLE USELESS AND ENDANGERING THE DRIVER. TOWED TO REPAIR SHOP. ESTIMATE TO REBUILD THE TRANSMISSION $2,134.20. THE VEHICLE HAS 86,632 MILES AND WAS PURCHASED USED AT 77,000 MILES. *TR
NHTSA ODI #10219915
Official recalls
3Jun 3, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 8, 2002
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP MODULE MOUNTING FLANGE COULD LEAK FUEL IF THE VEHICLE IS INVOLVED IN A ROLLOVER CRASH.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SECONDARY SEAL OVER THE FUEL PUMP MODULE. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Sep 10, 2001
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES ARE BEING RECALLED FOR A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER MICROPROCESSOR. UNDER CERTAIN CONDITIONS, THE CLUSTER, WITH THE MAJORITY OF ITS GAUGES, ILLUMINATION, AND WARNING LAMPS, COULD BECOME INOPERATIVE.
Consequence & remedy
Consequence: DRIVING THE VEHICLE WITH AN INOPERATIVE CLUSTER COULD CAUSE A DISTRACTION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL RE-FLASH THE CLUSTER SOFTWARE TO CORRECT THE CONDITION. OWNER NOTIFICATION BEGAN OCTOBER 8, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
Illustration