NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
697 reportsMileage unknown · Jan 18, 2024
Electrical SystemFuel/propulsion SystemPower Train
While driving in 60 degree weather, the vehicle’s check engine light lit on the dash and the vehicle abruptly stopped. I was able to push the vehicle safely in heavy traffic. I contacted Onstar who gave me the vehicle diagnosis. Onstar advised the following codes appeared POACA (Hybrid/ electric vehicle powertrain control module…
Read full complaint
While driving in 60 degree weather, the vehicle’s check engine light lit on the dash and the vehicle abruptly stopped. I was able to push the vehicle safely in heavy traffic. I contacted Onstar who gave me the vehicle diagnosis. Onstar advised the following codes appeared POACA (Hybrid/ electric vehicle powertrain control module requested malfunction indicator lamp illumination), P1AEE ( the electric propulsion system is not performing as expected. Please service immediately), and P1AEF (the electric propulsion system is not performing as expected).
NHTSA ODI #11566183
Mileage unknown · Jan 17, 2024
Electrical SystemFuel/propulsion SystemPower Train
Car stopped operation while out doing errands. Car had to be parked and restarted and made it back home. Car would not start again. Had to have it towed to dealership, BECM needs replaced for $2000. Warranty should cover, but part is backordered. Not sure when it will be fixed and with the recent freezing temperatures could have…
Read full complaint
Car stopped operation while out doing errands. Car had to be parked and restarted and made it back home. Car would not start again. Had to have it towed to dealership, BECM needs replaced for $2000. Warranty should cover, but part is backordered. Not sure when it will be fixed and with the recent freezing temperatures could have been dangerous.
NHTSA ODI #11565952
Mileage unknown · Jan 13, 2024
Electrical SystemFuel/propulsion SystemPower Train
Vehicle stopped running, will not restart. ODB codes show failure of the BECM. Check engine light illuminated, READY indication turned off. Vehicle does not display battery or fuel status. We were left stranded by this failure.
NHTSA ODI #11565346
Mileage unknown · Jan 10, 2024
Electrical SystemFuel/propulsion System
First, the electrical system did fail suddenly in August 2023. Luckily, I was parked and so was not injured. I did report the electrical failure to the Hendrick Chevrolet dealership in Durham. But this Chevrolet Volt also does not fill up with gas. At the pump, gas just spills out of the tank. I've seen online that many people …
Read full complaint
First, the electrical system did fail suddenly in August 2023. Luckily, I was parked and so was not injured. I did report the electrical failure to the Hendrick Chevrolet dealership in Durham. But this Chevrolet Volt also does not fill up with gas. At the pump, gas just spills out of the tank. I've seen online that many people have this same problem. At the suggestion of Hendrick Chevrolet dealership in Durham (and after paying $210 for a diagnostic), I replaced the vent valve solenoid. The car filled up with gas twice. But once again, gas starts spilling out of the tank if you try and fill it up. The car only has about 25,000 miles on it and hasn't been driven extensively so it doesn't make sense that it is malfunctioning.
NHTSA ODI #11564702
Mileage unknown · Jan 10, 2024
Electrical SystemFuel/propulsion SystemPower Train
While driving the car in electric mode, a chime came on and flashed 'propulsion power is reduced', then it went into engine mode and the car decelerated quickly from posted 70mph speed to less than 40mph even though I pushed the accelerator pedal and reved the engine high. While in this low power driving mode, a warning came on…
Read full complaint
While driving the car in electric mode, a chime came on and flashed 'propulsion power is reduced', then it went into engine mode and the car decelerated quickly from posted 70mph speed to less than 40mph even though I pushed the accelerator pedal and reved the engine high. While in this low power driving mode, a warning came on saying the collision detection system was disabled. The concern is the person behind me had no warning since my brake lights did not come on. He sped around me with a bit of road rage. The problem temporarily goes away when you turn the ignition off and back on. I took it to the dealer and the said it needed a new EGR Cooler 4 hours labor $1500. Chevy Dealer pulled two codes P0401 Exhaust Gas Recirculation "A" Flow Insufficient Detected P1E00 Hybrid/EV Powertrain Control Module 2 I paid them the $165 diagnosis fee and got my car back and just plan to restart when it occurs. In another instance, I was pulling out from a parking lot into a busy road in electric mode and the car lost ALL power leaving me exposed in the line of traffic. Error messages on the dash said to 'service BECM' and 'shift to park'. The car was not drivable and had to be towed. Call me if you need any more information. Thank you, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11564574
Mileage unknown · Jan 9, 2024
Electrical SystemFuel/propulsion System
We were driving on the highway (my wife and younger son were passengers, and my 17 year old son was driver). He was in electric mode and then the engine propulsion reduced message came on and the check engine light came on. Car was still running, albeit slower. We stopped and filled up the gas, and got an engine unavailable mes…
Read full complaint
We were driving on the highway (my wife and younger son were passengers, and my 17 year old son was driver). He was in electric mode and then the engine propulsion reduced message came on and the check engine light came on. Car was still running, albeit slower. We stopped and filled up the gas, and got an engine unavailable message. Vehicle switched back to battery mode on its own and because there was no charge, the vehicle stopped ON THE HIGHWAY. The car lost all control and power abilities and it was very dangerous. They were able to pull over into the break down lane and they called a tow. Took the car to Mike Reichenbach Chevrolet in SC and they removed and replaced the EGR valve. However, within the last couple of weeks, my son has received the loss of propulsion message again and the car is violently shaking. This is a safety issue!
NHTSA ODI #11564471
Mileage unknown · Jan 8, 2024
Electrical SystemEngineFuel/propulsion System
The Volts BECM has failed. There are warning lights constantly warning about Engine and low Propulsion. There are multiple symptoms. Most serious is that car has stalled while driving 3 times. If I pull over, put in park, then turn off; I can restart the engine using battery mode. It does not drive well in gas mode where gas…
Read full complaint
The Volts BECM has failed. There are warning lights constantly warning about Engine and low Propulsion. There are multiple symptoms. Most serious is that car has stalled while driving 3 times. If I pull over, put in park, then turn off; I can restart the engine using battery mode. It does not drive well in gas mode where gas fuels generator to charge battery for propulsion. It is now very loud and often won't allow you to drive faster than 30 MPH. The mileage diagnostics (MPG) are just over 50% of what they were before problem started. It often randomly switches from battery mode to gas. This is undesired. My problem is that the only certified tech is on other side of Island Volcano. I have no confidence that I can drive it to dealer, given the distance and power required to climb mountain. So, I am stuck with no way to fix. There are widespread reported issues, similar to mine, caused by defective BECM (Battery Energy Control Module). Problem started September 2023 and have issues every day I dare drive it.
NHTSA ODI #11564306
Mileage unknown · Jan 8, 2024
Electrical SystemEngine
Upon starting vehicle and shifting to drive, vehicle gives message to "shift to park" and will do nothing else. Also, while battery is fully charged, vehicle will display "unable to charge" and show no mileage left on EV mode - then at times (but not always) upon starting vehicle, mileage increases to what it expected.
NHTSA ODI #11564243
Mileage unknown · Jan 6, 2024
Fuel/propulsion System
Battery Energy Control Module (BECM) on 2017 Chevrolet Volt failed. Resulting in reduced propulsion power, no charging. Check engine light comes on. Dealer has confirmed this is a BECM issue.
NHTSA ODI #11563946
Mileage unknown · Jan 5, 2024
Electrical SystemPower Train
Vehicle suddenly would not function. All systems became inoperable. When serviced it was determined to be a sudden failure of the BECM module which required total replacement. Part was on national back order leaving vehicle unusable for weeks.
NHTSA ODI #11563790
NHTSA investigations
2PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
Illustration