NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
697 reportsMileage unknown · Jan 31, 2024
EngineFuel/propulsion System
Driving on the road with a near full electric battery and then lost most of my power and got this message on the dash along with a check engine light. "Propulsion Power is Reduced" - I was in freeway traffic on a hill and had to put hazards on to move to the slow lane. Engine came on and seemed to be revving to full power to mai…
Read full complaint
Driving on the road with a near full electric battery and then lost most of my power and got this message on the dash along with a check engine light. "Propulsion Power is Reduced" - I was in freeway traffic on a hill and had to put hazards on to move to the slow lane. Engine came on and seemed to be revving to full power to maintain speed.
NHTSA ODI #11569137
Mileage unknown · Jan 31, 2024
EngineFuel/propulsion SystemPower Train
BECM failure on car confirmed at 128,000 miles. While driving the car's check engine light came on; immediately followed by a message of reduced propulsion and the EV range dropping to 0. Vehicle switched to gas and ran very rough for a short distance to an available stop. Have been informed by dealership that the vehicle is …
Read full complaint
BECM failure on car confirmed at 128,000 miles. While driving the car's check engine light came on; immediately followed by a message of reduced propulsion and the EV range dropping to 0. Vehicle switched to gas and ran very rough for a short distance to an available stop. Have been informed by dealership that the vehicle is now unsafe for driving due to a potential stall.
NHTSA ODI #11569029
Mileage unknown · Jan 27, 2024
Fuel/propulsion System
I was in a neighborhood driving ~30 mph and slowed down to take a right turn. Once I completed the turn my car stalled out completely and would no longer accelerate. I tried putting the car in park and back into drive with no luck. I quickly turned the car off and back on and was able to resume driving. As I was just through the…
Read full complaint
I was in a neighborhood driving ~30 mph and slowed down to take a right turn. Once I completed the turn my car stalled out completely and would no longer accelerate. I tried putting the car in park and back into drive with no luck. I quickly turned the car off and back on and was able to resume driving. As I was just through the intersection I could have easily been hit while motionless and had my newborn baby and wife with me in the car at the time. The issue has no happened again, but I am terrified it might. As there were no warning signs or any signals of problem in the dashboard I don't have any idea when it might happen again.
NHTSA ODI #11568259
Mileage unknown · Jan 25, 2024
Electrical SystemPower Train
My vehicle shut down in the middle of the road. GM diagnosed it as a faulty BECM.
NHTSA ODI #11567898
Mileage unknown · Jan 25, 2024
EngineFuel/propulsion SystemVehicle Speed Control
While we were driving on the freeway, we saw a check engine light and “propulsion power is reduced” message. The car began driving very roughly and we had to slow down. We had this happen once before where the car engine stopped working entirely while driving at city speeds after seeing this error earlier in the summer, so we pu…
Read full complaint
While we were driving on the freeway, we saw a check engine light and “propulsion power is reduced” message. The car began driving very roughly and we had to slow down. We had this happen once before where the car engine stopped working entirely while driving at city speeds after seeing this error earlier in the summer, so we pulled over as soon as we could. We were traveling in a remote area at the time, just before the holidays, and it was fairly cold out. The car dealer inspected the car and told us it was unsafe to drive, that we could not take it back until it was fixed, and that it was an EGR valve problem. We previously had this fixed under warranty as well for similar behavior, and the car is barely five years old with very few miles on it. It’s our only car and we have been waiting on the part for weeks now, with no response on when we’ll be able to have our car back, and no rental car that we can drive in the meantime to get to our jobs and get groceries. The part is covered under our warranty. Both times this has happened to us, we were actively driving. In the city, it was very unsafe for the engine to unexpectedly stop as we were driving because of the amount of traffic and pedestrians, and because it meant we didn’t have full control of the vehicle. On the freeway, it was very unsafe because of the speed we were going on the freeway. Knowing that our engine was at high risk of unexpectedly stopping working while driving on the freeway from the past experience in the city made it difficult to safely concentrate on pulling over and also maneuver in traffic.
NHTSA ODI #11567891
Mileage unknown · Jan 25, 2024
Electrical SystemEngineFuel/propulsion System
Vehicle lost power on highway and on local streets. “Propulsion power reduced” warning. Car brought to dealer 7/2023. EGR valve ordered at that time. The EGR valve has not been available since that time. No time frame for availability has been given.
NHTSA ODI #11567845
Mileage unknown · Jan 25, 2024
Electrical SystemPower Train
same issue as PE23022 and TSB 18-NA-261 Called 51 parts wharehouses and Chevy dealers to locate part. They all report the same: part is not available and no idea when it will be come available. vehicle is not mobile without working part. Vehicle has lost propulsion while driving. Twice I was lucky no one was behind or on the s…
Read full complaint
same issue as PE23022 and TSB 18-NA-261 Called 51 parts wharehouses and Chevy dealers to locate part. They all report the same: part is not available and no idea when it will be come available. vehicle is not mobile without working part. Vehicle has lost propulsion while driving. Twice I was lucky no one was behind or on the side of me that I could pull off to the side of the road or a parking lot.
NHTSA ODI #11567744
Mileage unknown · Jan 23, 2024
Electrical SystemFuel/propulsion SystemPower Train
1 month ago was driving on toll and Population power is reduced came on, vehicle was reaving high and felt like power was being reduced/speed, was going 70 and had to immediately decrease speed and get off toll and found closest Chevy shop. Looked at dash and vehicle should have had at least 10 energy miles but it had immediate…
Read full complaint
1 month ago was driving on toll and Population power is reduced came on, vehicle was reaving high and felt like power was being reduced/speed, was going 70 and had to immediately decrease speed and get off toll and found closest Chevy shop. Looked at dash and vehicle should have had at least 10 energy miles but it had immediately dropped down to 0. Before taking to Chevy, I had a quick inspection done by a Valvoline shop and they told me the battery had to be replaced. Carvana (Silverrock) warranty refused to do the repair under their coverages as “batteries were not covered under warranty” Had it towed from Valvoline to Chevy. Found out Chevy battery was under warranty so it was taken there. Vehicle was checked in and didn’t have an eta as hybrid battery was on back order with no ETA. 3 weeks later the part was received and it was a control module not a battery as the “battery was not failing at the time”. Service called and said vehicle was ready for pick up. Had vehicle for 1 week and was at work starting it up and after 9 hours sitting started it up and low population came back on and vehicle started idling higher than before then after a minute looked at back of car and a large cloud of while smoke started forming from back of vehicle. Immediately turned off car and called gmc roadside assistance to have vehicle towed to another dealership where is it sitting again for diagnosis with no eta.
NHTSA ODI #11567156
Mileage unknown · Jan 22, 2024
Fuel/propulsion System
Propulsion power reduced message appears on dash board. Yes available for inspection. Unsafe to drive losing power on highway. Yes there are warning error messages appearing on dashboard.
NHTSA ODI #11567123
Mileage unknown · Jan 19, 2024
Electrical SystemFuel/propulsion SystemPower Train
Car won't start show codes U2622, U2621, U2620, U2619, P0AFA.
NHTSA ODI #11566530
NHTSA investigations
2PE23022 · Loss Of Motive Power Due To The Battery Energy Control Module
Opened Nov 29, 2023 · Closed Mar 3, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System; Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Electrical System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
Illustration