IllustrationTHE ENGINE IN MY 1999 CHEVY VENTURE VAN JUST WENT OUT. THE VAN HAS LESS THAN 90,000 MILES ON IT. MY PARENTS 1999 VENTURE DID THE SAME THING AT APPROXIMATELY THE SAME MILEAGE 2 YEARS AGO. IS THERE A PROBLEM WITH THE ENGINES IN THE 1999 VENTURE VANS? *JB
1999 Chevrolet Venture
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1999 Chevrolet Venture do not stand out strongly from the model-year median of 220.
About this comparison →How this year compares
Owner complaints by model year
Compare all Venture years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
80–25K
3225–50K
5250–75K
3275–100K
17100–150K
2150K+
143 reports with mileage · 206 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 114 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
22 crash reports5 fire reports27 injury reports
What owners actually said
349 reportsI HAVE HAD SO MANY PROBLEMS 1. THE INNER BRAKE PADS WORE DOWN TO THE STEEL RUINING THE INSIDE OF BOTH ROTORS ABOUT 3,000 MILES. UNDER WARRANTY. BUT THE BRAKE PADS. 2. BATTERY ACID IS CORRODING ABOUT 4,000 MILES THE DEALERSHIP PAY ALL STILL UNDER WARRANTY 3. BATTERY AGAIN BUT IT TURN OUT TO BE THE ALTERNATOR ABOUT 6,500 TH…
Read full complaint
I HAVE HAD SO MANY PROBLEMS 1. THE INNER BRAKE PADS WORE DOWN TO THE STEEL RUINING THE INSIDE OF BOTH ROTORS ABOUT 3,000 MILES. UNDER WARRANTY. BUT THE BRAKE PADS. 2. BATTERY ACID IS CORRODING ABOUT 4,000 MILES THE DEALERSHIP PAY ALL STILL UNDER WARRANTY 3. BATTERY AGAIN BUT IT TURN OUT TO BE THE ALTERNATOR ABOUT 6,500 THE DEALERSHIP PAY UNDER WARRANTY. 4. THE TREAD COMPLETELY SEPARATED FROM THE SIDEWALL. P215/70R15, FIRE STONE ON ALL FOUR TIRES. DEALERSHIP DID NOT COVER TIRE HAVE NO WARRANTY ON NEW VEHICLE 7,000 MILES 5. WATER LEAK, AND CARPET IS WET EVERY TIME IT RAINS I FEEL IT IS COMING FROM THE WINDSHIELD. WARRANTY DOES NOT COVER. 8,000 STILL DOES IT AT 50,256. 6. LIGHTER KEEP SHORTING OUT AND AC KEEP MESS UP UNDER THE WARRANTY 7. WHILE DRIVING THE CHECK OIL LIGHT AND THE BATTERY LINE CAME ON. THE VEHICLE SHUT OFF, LOOSING ALL POWER THE INTAKE MANIFOLD UNDER WARRANTY 38,000 MILES. 8. INTAKE MANIFOLD FIX CAME HOME MY LIGHTS WAS MESS UP WHEN PUT ON MY BRAKES THE FOUR WAY FLASHER CAME ON WHEN I PUT MY LEFT TURN SIGNALS THE RIGHT ONE WOULD CAME ON PUT THE RIGHT TURN SIGNALS THE LEFT ONE WOULD COME ON TOOK IT BACK THEY HAD TO REPAIRED ENTIRE WIRING SYSTEM BECAUSE OF OVER HEARTED BURN IT UP UNDER WARRANT 9. BATTERY ACID IS CORRODING THE BATTERY PAN AND SURROUNDING COMPONENTS, POSITIVE CABLE CONNECTED TO BATTERY HAS FALLEN OFF,38,500 NOT COVER 6 YEAR WAS UP. 10. POWER STEERING FLUID SPRAYING FLUID ONTO THE ENGINE AND SERPENTINE BELT THE DEALERSHIP DID NOT PUT CAP BACK ON POWER STEERING. 11. POWER LOCKS WILL NOT OPERATE FROM DOOR SWITCHES ONLY FROM THE REMOTE POWER WINDOW. BACK AC DOES NOT WORK. 12. CONNECTOR LEFT AND RIGHT MELT TAIL LIGHTS, STOP LIGHTS, TURN SIGNALS ABOUT 42,000. 13. THERE IS A THUMP NOISE WHEN STOPPING AND TAKING OFF. 14. STRONG SMELL OF FUEL WHEN PARKED. 15. CLOUDING OF LENS 16. SERPENTINE BELT REPLACE AT 50,256 17. LEAKING FROM LOWER INTAKE MANIFOLD GASKET. AT 50,000. *NM
I OWN A 1999 CHEVY VENTURE. IN THE PAST TWO MONTHS THE HEATER CORE HAS GONE OUT THREE TIMES, THE FIRST TIME BEING THE ORIGINAL THAT LASTED SIX YEARS. WHEN IT GOES OUT, IT FOGS THE WINDOW UP SO BAD THAT DRIVING IS NEARLY IMPOSSIBLE. CHEVY HAS SENT OUT SERVICE BULLETINS THAT NOTE A PROBLEM WITH ELECTROLYSIS THAT RAPIDLY DETERIORAT…
Read full complaint
I OWN A 1999 CHEVY VENTURE. IN THE PAST TWO MONTHS THE HEATER CORE HAS GONE OUT THREE TIMES, THE FIRST TIME BEING THE ORIGINAL THAT LASTED SIX YEARS. WHEN IT GOES OUT, IT FOGS THE WINDOW UP SO BAD THAT DRIVING IS NEARLY IMPOSSIBLE. CHEVY HAS SENT OUT SERVICE BULLETINS THAT NOTE A PROBLEM WITH ELECTROLYSIS THAT RAPIDLY DETERIORATES THE HEATER CORE. THE HEATER CORES ARE CHEVY PARTS. THERE SEEMS TO BE NO PERMANENT FIX AVAILABLE. THE LAST REPAIR MADE TODAY INCLUDED THE ADDITION OF A GROUNDING CABLE. *NM
I HAVE HAD 3 MAIN PROBLEMS TRANSMISSION, HEADLIGHT MOISTURE AND AIRBAG LIGHT ILLUMINATION MY 99 VENTURE HAS 79K MILES ON IT AND THAT TRANSMISSION IS SHIFTING HARD (DEALER SUGGEST A DRAIN AND FLUSH) AT 60K I HAD A VALVE IN THE TRANSMISSION REPLACED FOR 800 DOLLARS. I AM AFRAID WE WILL BE REPLACING A TRANSMISSION AT 85000 MILES.…
Read full complaint
I HAVE HAD 3 MAIN PROBLEMS TRANSMISSION, HEADLIGHT MOISTURE AND AIRBAG LIGHT ILLUMINATION MY 99 VENTURE HAS 79K MILES ON IT AND THAT TRANSMISSION IS SHIFTING HARD (DEALER SUGGEST A DRAIN AND FLUSH) AT 60K I HAD A VALVE IN THE TRANSMISSION REPLACED FOR 800 DOLLARS. I AM AFRAID WE WILL BE REPLACING A TRANSMISSION AT 85000 MILES. I CAN NOT BELIEVE IT. THE AIR BAG LIGHT HAS BEEN COMING ON SINCE WE BOUGHT THE VEHICLE. WE HAVE HAD IT IN 7-9 TIMES FIXES RANGED FROM CLEARING THE CODE TO TIGHTENING UP A PLUG. THE HEAD LIGHT UNITS HAVE BEEN TAKING ON WATER AND BURNING OUT LIGHTS FOR THE LAST 20K MILES. SOUNDS LIKE A MANUFACTURER DEFECT. FROM WHAT I HAVE READ ON THE INTERNET A LOT OF PEOPLE ARE HAVING THE SAME EXACT PROBLEMS AND I CANNOT BELIEVE GM WOULD PRODUCE A VEHICLE LIKE THIS AND NOT STAND BUY THERE PRODUCT. *JB
WE HAVE A 1999 CHEVY VENTURE MINIVAN WITH 50,000 MILES ON IT. WE STARTED HAVING PROBLEMS ABOUT A YEAR AND A HALF AGO WITH IT. AFTER MANY TRIPS TO THE MECHANIC, WE FINALLY FOUND THE MAIN ISSUE CAUSING THE NUMEROUS PROBLEMS. A LEAK IN THE INTAKE MANIFOLD LEAKING COOLANT INTO THE ENGINE OIL. THE GM PART IS PLASTIC. IT IS A SMA…
Read full complaint
WE HAVE A 1999 CHEVY VENTURE MINIVAN WITH 50,000 MILES ON IT. WE STARTED HAVING PROBLEMS ABOUT A YEAR AND A HALF AGO WITH IT. AFTER MANY TRIPS TO THE MECHANIC, WE FINALLY FOUND THE MAIN ISSUE CAUSING THE NUMEROUS PROBLEMS. A LEAK IN THE INTAKE MANIFOLD LEAKING COOLANT INTO THE ENGINE OIL. THE GM PART IS PLASTIC. IT IS A SMALL PART, BUT TAKES 7.5 HOURS TO FIX, SO THE AVERAGE COST TO FIX IT IS $800!!. THERE ARE LITERALLY THOUSANDS OF COMPLAINTS ABOUT THIS PART USED BY GM. THERE IS A PETITION WITH OVER 9,000 SIGNATURES!! ITS TIME FOR GM TO RECALL THE PART AND MAKE THINGS RIGHT FOR THEIR CUSTOMERS ESPECIALLY WHEN IT IS USUALLY FAMILIES WITH SMALL CHILDREN RIDING IN THESE GM MINIVANS. *NM
MY 1999 CHEV VENTURE HAD THE BOTTOM SUSPENSION FRAME MEMBER THAT HOLDS THE WHEEL AND STEERING ASSEMBLIES,ON THE PASSENGER SIDE FAIL WHILE DIRIVING. THIS FAILURE RESULTED IN LOSS OF VEHICLE CONTROL. SOME ONE COULD BE KILLED IF IT HAPPENS AGAIN. NO FRAME SHOULD EVER BRAKE UNDER NORMAL DRIVING. THIS VEHICLE HAS ALWAYS BEEN DRIVE…
Read full complaint
MY 1999 CHEV VENTURE HAD THE BOTTOM SUSPENSION FRAME MEMBER THAT HOLDS THE WHEEL AND STEERING ASSEMBLIES,ON THE PASSENGER SIDE FAIL WHILE DIRIVING. THIS FAILURE RESULTED IN LOSS OF VEHICLE CONTROL. SOME ONE COULD BE KILLED IF IT HAPPENS AGAIN. NO FRAME SHOULD EVER BRAKE UNDER NORMAL DRIVING. THIS VEHICLE HAS ALWAYS BEEN DRIVEN WITHIN NORMAL OPERATION ON THE HIGHWAYS. IT HAS NEVER HAD MORE THAN 6 PASSENGERS IN THE VEHILCE. THEIR HAD TO BE A FLAW IN THE PART WHEN IT WAS MANUFACTURED OR IT IS A VERY POOR DESIGN. *NM
DT: THE CONTACT STATED AIRBAG LIGHT ILLUMINATED INTERMITTENTLY, AND THE POWER DOOR LOCK ON THE DRIVER'S SIDE STOPPED WORKING. HE TOOK THE VEHICLE TO AN INDEPENDENT REPAIR SHOP WHO PERFORMED A DIAGNOSTIC TEST. NO CODES WERE FOUND BY THE DIAGNOSTIC TEST. UPON FURTHER INSPECTION, CONDENSED WATER FROM THE AIR CONDITIONING HAD LEA…
Read full complaint
DT: THE CONTACT STATED AIRBAG LIGHT ILLUMINATED INTERMITTENTLY, AND THE POWER DOOR LOCK ON THE DRIVER'S SIDE STOPPED WORKING. HE TOOK THE VEHICLE TO AN INDEPENDENT REPAIR SHOP WHO PERFORMED A DIAGNOSTIC TEST. NO CODES WERE FOUND BY THE DIAGNOSTIC TEST. UPON FURTHER INSPECTION, CONDENSED WATER FROM THE AIR CONDITIONING HAD LEAKED AROUND THE WIRING AND UNDER THE CARPET ON THE FRONT FLOOR. THE MECHANIC DETERMINED THE WATER HAD SHORTED OUT THE POWER DOOR LOCK AND AFFECTED THE AIRBAG WIRING AS WELL. THE MECHANIC REPLACED THE WIRE FOR THE DOOR LOCK ASSEMBLY, HOWEVER NO REPAIRS WERE MADE TO THE AIRBAG WIRING AT THAT TIME. *AK UPDATED 12/27/05. *JB
DT: THE CONTACT STATED THERE WAS WATER IN THE HEADLIGHTS. THE HEADLIGHTS WORKED BUT NOT AS BRIGHTLY AS INTENDED. THE VEHICLE HAS BEEN TO THE DEALERSHIP, AND THEY STATED IT WAS A DEFECT IN THE DRIP SYSTEM. THE VEHICLE HAS NOT BEEN REPAIRED DUE TO THE EXCESSIVE EXPENSE. *AK UPDATED 12/20/05. *JB
DT: CONTACT STATES VEHICLE GETTING WATER IN HEADLIGHTS. REPLACED THE BULB TWICE. DEALER OFFERED NO HELP AT THEIR EXPENSE. MANUFACTURER HAS NOT BEEN CONTACTED YET. *AK
AIR-BAG WARNING LIGHT I JUST BOUGHT ANOTHER 1999 CHEVY VENTURE BECAUSE I REALLY LIKED MY OTHER ONE, BUT IT HAD TOO MANY PROBLEMS. MY OLD ONE WAS A LS AND THIS ONE IS A LT. NOW THE AIR BAG LIGHT IS ON WITH THIS ONE TOO! I DO NOT UNDERSTAND WHY SUCH AN IMPORTANT COMPONENT IS SUCH A PROBLEM. *JB
Official recalls
404V597000 · Latches/locks/linkages:doors:latch
Dec 22, 2004
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
01V264000 · Latches/locks/linkages:doors:latch
Aug 21, 2001
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
01V067000 · Latches/locks/linkages:doors:latch
Mar 8, 2001
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence & remedy
Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
99V071000 · Steering:gear Box:shaft Sector
Apr 12, 1999
VEHICLE DESCRIPTION: PASSENGER MINI VANS. THE LEFT AND/OR RIGHT FRONT LOWER INSULATOR TO CRADLE CENTER METAL SLEEVE IS COLLAPSED, WHICH CAN RESULT IN LOSS OF CLAMP LOAD IN THE JOINT. IF THE CLAMP LOAD IS REDUCED OR LOST, THE BOLT CAN BE LOST OR BROKEN AND THE JOINT CAN SEPARATE.
Consequence & remedy
Consequence: IF NOT REPAIRED, SEPARATION OF THE OPPOSITE SIDE JOINT COULD OCCUR RESULTING IN STEERING SHAFT SEPARATION.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT LOWER CRADLE-TO-SUSPENSION INSULATORS AND THE ATTACHING BOLTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6PE04064 · POWER-SLIDING Door
Opened Sep 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Structure:body:door
SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.
EA03005 · Rear Axle Trailing Arm Failure
Opened Apr 23, 2003 · Closed Jan 12, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02086 · Rear Axle Trailing Arm Failure
Opened Nov 18, 2002 · Closed Apr 9, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:rear
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
Additional source detail variants (2)
Suspension
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
Suspension:rear
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
PE02017 · Shoulder Harness Clip
Opened Feb 11, 2002 · Closed Aug 2, 2002
Status: closed (inferred from source dates) · Seat Belts
No summary supplied.
PE00045 · Air Bag Tear During Deployment
Opened Nov 3, 2000 · Closed Jan 11, 2001
Status: closed (inferred from source dates) · Air Bags
No summary supplied.
SQ00014 · Unexpected Opening Of Sliding Door
Opened Jul 25, 2000 · Closed Oct 22, 2001
Status: closed (inferred from source dates) · Structure
There is no summary currently available