NHTSA owner reports · September 18, 2026 snapshot.
Air Bags complaints
40 reportsClear category filter97,500 miles · Jul 24, 2017
Air Bags
TL* THE CONTACT OWNS A 1999 CHEVROLET VENTURE. THE CONTACT STATED THAT WHEN STARTING THE VEHICLE, THE AIR BAG WARNING LIGHT WOULD FLASH 7 TIMES THEN REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND A DIAGNOSTIC WAS PERFORMED, WHICH LOCATED A FAILURE CODE FOR THE AIR BAGS. THE VEHICLE WAS NOT TAKEN TO A …
Read full complaint
TL* THE CONTACT OWNS A 1999 CHEVROLET VENTURE. THE CONTACT STATED THAT WHEN STARTING THE VEHICLE, THE AIR BAG WARNING LIGHT WOULD FLASH 7 TIMES THEN REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND A DIAGNOSTIC WAS PERFORMED, WHICH LOCATED A FAILURE CODE FOR THE AIR BAGS. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 97,500.
NHTSA ODI #11010181
85,000 miles · Oct 19, 2006
Air BagsCrashInjury
DT*: THE CONTACT STATED WHILE STOPPED AT A STOP LIGHT DURING WET ROAD CONDITIONS, THE VEHICLE WAS IMPACTED ON THE FRONT DRIVER SIDE BY ANOTHER VEHICLE TRAVELING 45 MPH. THE CONTACT'S VEHICLE WAS PUSHED INTO ONCOMING TRAFFIC AND COLLIDED WITH 3 OTHER VEHICLES CAUSING DAMAGE TO THE WHOLE FRONT END AND FRONT PASSENGER DOOR. NONE …
Read full complaint
DT*: THE CONTACT STATED WHILE STOPPED AT A STOP LIGHT DURING WET ROAD CONDITIONS, THE VEHICLE WAS IMPACTED ON THE FRONT DRIVER SIDE BY ANOTHER VEHICLE TRAVELING 45 MPH. THE CONTACT'S VEHICLE WAS PUSHED INTO ONCOMING TRAFFIC AND COLLIDED WITH 3 OTHER VEHICLES CAUSING DAMAGE TO THE WHOLE FRONT END AND FRONT PASSENGER DOOR. NONE OF THE AIR BAGS DEPLOYED, AND THE CONTACT SUSTAINED INJURIES TO THE LEG, SHOULDER, AND CHEST. THE SEAT BELT WAS WORN, AND THE AIRBAG WARNING LIGHT WAS NOT ILLUMINATED PRIOR TO THE INCIDENT. A POLICE REPORT WAS TAKEN AND PICTURES WERE AVAILABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP, AND WAS DEEMED TOTALED. UPDATED 1/26/2007 - *NM
NHTSA ODI #10171335
20,000 miles · Jul 31, 2006
Air BagsElectrical SystemEngine And Engine Cooling
THIS WILL BE A LIST OF MOST OF THE PROBLEMS. I HAVE COMPLAINED OF SMELLING ANTI-FREEZE SINCE I PURCHASED THE VAN NEW. IT CURRENTLY HAS 94K ON IT AND I HAVE DONE ALL SCHEDULED MAINTENANCE ON IT. I THINK THE CLOCK WORK OIL CHANGES IS THE ONLY REASON IT STILL RUNS. MANIFOLD GASKETS, INTAKE, HEAD...HAVE BEEN REPLACED TWICE AND NEED…
Read full complaint
THIS WILL BE A LIST OF MOST OF THE PROBLEMS. I HAVE COMPLAINED OF SMELLING ANTI-FREEZE SINCE I PURCHASED THE VAN NEW. IT CURRENTLY HAS 94K ON IT AND I HAVE DONE ALL SCHEDULED MAINTENANCE ON IT. I THINK THE CLOCK WORK OIL CHANGES IS THE ONLY REASON IT STILL RUNS. MANIFOLD GASKETS, INTAKE, HEAD...HAVE BEEN REPLACED TWICE AND NEED IT AGAIN, REALLY BAD. BUT I JUST DO NOT HAVE 5-800 BUCKS LAYING AROUND TO DO A GASKET JOB AGAIN SINCE I JUST DID IT A YEAR AGO. THE ANTI-FREEZE DILUTING THE OIL HAS MESSED UP A COUPLE PISTONS. THEY SLAP VERY BAD OK HERE IS MY LIST (I HAVE DEALER INVOICES FOR EVERYTHING FIXED THE FIRST TIME AND RECEIPTS FOR PARTS AND LABOR THE SECOND TIME, OR MY HUSBAND GOT SICK OF PAYING FOR THE SAME CRAP SO HE WOULD FIX THINGS) (HE IS IN THE AUTOMOTIVE TESTING AND DESIGN FIELD) *JB
NHTSA ODI #10163941
79,000 miles · Mar 2, 2006
Air BagsExterior LightingPower Train
I HAVE HAD 3 MAIN PROBLEMS TRANSMISSION, HEADLIGHT MOISTURE AND AIRBAG LIGHT ILLUMINATION MY 99 VENTURE HAS 79K MILES ON IT AND THAT TRANSMISSION IS SHIFTING HARD (DEALER SUGGEST A DRAIN AND FLUSH) AT 60K I HAD A VALVE IN THE TRANSMISSION REPLACED FOR 800 DOLLARS. I AM AFRAID WE WILL BE REPLACING A TRANSMISSION AT 85000 MILES.…
Read full complaint
I HAVE HAD 3 MAIN PROBLEMS TRANSMISSION, HEADLIGHT MOISTURE AND AIRBAG LIGHT ILLUMINATION MY 99 VENTURE HAS 79K MILES ON IT AND THAT TRANSMISSION IS SHIFTING HARD (DEALER SUGGEST A DRAIN AND FLUSH) AT 60K I HAD A VALVE IN THE TRANSMISSION REPLACED FOR 800 DOLLARS. I AM AFRAID WE WILL BE REPLACING A TRANSMISSION AT 85000 MILES. I CAN NOT BELIEVE IT. THE AIR BAG LIGHT HAS BEEN COMING ON SINCE WE BOUGHT THE VEHICLE. WE HAVE HAD IT IN 7-9 TIMES FIXES RANGED FROM CLEARING THE CODE TO TIGHTENING UP A PLUG. THE HEAD LIGHT UNITS HAVE BEEN TAKING ON WATER AND BURNING OUT LIGHTS FOR THE LAST 20K MILES. SOUNDS LIKE A MANUFACTURER DEFECT. FROM WHAT I HAVE READ ON THE INTERNET A LOT OF PEOPLE ARE HAVING THE SAME EXACT PROBLEMS AND I CANNOT BELIEVE GM WOULD PRODUCE A VEHICLE LIKE THIS AND NOT STAND BUY THERE PRODUCT. *JB
NHTSA ODI #10151632
70,500 miles · Oct 4, 2005
Air Bags
AIR-BAG WARNING LIGHT I JUST BOUGHT ANOTHER 1999 CHEVY VENTURE BECAUSE I REALLY LIKED MY OTHER ONE, BUT IT HAD TOO MANY PROBLEMS. MY OLD ONE WAS A LS AND THIS ONE IS A LT. NOW THE AIR BAG LIGHT IS ON WITH THIS ONE TOO! I DO NOT UNDERSTAND WHY SUCH AN IMPORTANT COMPONENT IS SUCH A PROBLEM. *JB
NHTSA ODI #10138466
Mileage unknown · Aug 4, 2004
Air BagsExterior LightingService Brakes, Hydraulic
WHILE DRIVING TURN SIGNAL LIGHTS/ABS, AND SRS LIGHTS FLASHED ON AND OFF THE DASHBOARD. CONSUMER WAS ABLE TO DRIVE THE VEHICLE TO DEALER FOR INSPECTION, AND THE MECHANIC COULD NOT BE DUPLICATE THE PROBLEM. *AK
NHTSA ODI #10087239
Mileage unknown · Feb 24, 2004
Air Bags
AIR BAG LIGHT WILL FLASH OR NOT GO OFF ON A DAILY BASIS. HAS BEEN A PROBLEM FOR 3 YEARS. IN THE PAST, I HAD BEEN TOLD IT WAS JUST DIRTY CONTACTS.THE DEALER'S SERVICE DEPT. JUST HAD MY VAN FOR ALMOST A WEEK DID NOT EVEN MENTION THE LIGHT AS A CONCERN. WHILE LOOKING UP OTHER INFO. I HAVE DISCOVERED THIS COULD BE A MAJOR PROBLEM…
Read full complaint
AIR BAG LIGHT WILL FLASH OR NOT GO OFF ON A DAILY BASIS. HAS BEEN A PROBLEM FOR 3 YEARS. IN THE PAST, I HAD BEEN TOLD IT WAS JUST DIRTY CONTACTS.THE DEALER'S SERVICE DEPT. JUST HAD MY VAN FOR ALMOST A WEEK DID NOT EVEN MENTION THE LIGHT AS A CONCERN. WHILE LOOKING UP OTHER INFO. I HAVE DISCOVERED THIS COULD BE A MAJOR PROBLEM, ESPECIALLY SINCE THIS VAN HAS A "POOR" FRONTAL CRASH RATING EVEN WITH AIR BAGS!*AK
NHTSA ODI #10058821
57,000 miles · Jan 15, 2004
Air BagsEngine And Engine CoolingVisibility
I NOTICED A SMELL OF HOT ANTIFREEZE. ALSO IT WOULD MAKE A LOT OF NOISE WHEN STARTING UP. THE THERMOSTAT NEVER SHOWED ANYTHING OVERHEATING. OIL DIDN'T SHOW ANYTHING ON THE DIPSTICK. WE CHANGE THE OIL EVERY 3000 MILES. THE DEALERSHIP THAT TORE INTO IT HAD SAID WE DID NOT CHANGE THE OIL EVER BY THE LOOKS OF THE INTERNALS. WE…
Read full complaint
I NOTICED A SMELL OF HOT ANTIFREEZE. ALSO IT WOULD MAKE A LOT OF NOISE WHEN STARTING UP. THE THERMOSTAT NEVER SHOWED ANYTHING OVERHEATING. OIL DIDN'T SHOW ANYTHING ON THE DIPSTICK. WE CHANGE THE OIL EVERY 3000 MILES. THE DEALERSHIP THAT TORE INTO IT HAD SAID WE DID NOT CHANGE THE OIL EVER BY THE LOOKS OF THE INTERNALS. WE BOUGHT THIS USED 1999 CHEVY VENTURE LT , AUGUST 2000 HAVING 34,000 MILES ON IT ALREADY. THE PREVIOUS OWNER BOUGHT THIS VAN IN OCTOBER 1998 BRAND NEW. HOW COULD A VEHICLE HAVE TO HAVE A MOTOR DROPPED IN WITH ONLY 57,000 ON IT AND HAVE HAD DONE EVERYTHING POSSIBLE TO KEEP EVERYTHING IN WORKING ORDER. THIS IS NOT OUR FIRST CHEVY, OUR WHOLE FAMILY BUYS CHEVYS. JUST TO BRAG WE HAVE 13, AND ALL OF THEM MAINTAINED WELL. ONE EVEN HAVING OVER 200,000 MILES ON IT,1995 CHEVY ASTRO. ANYWAY, I WATCH THE GAUGES VERY CLOSELY AND NEVER DID I SEE ANYTHING WRONG.
NHTSA ODI #10069888
40,000 miles · Jan 15, 2004
Air BagsEngine And Engine CoolingUnknown Or Other
PASSENGER SLIDING DOOR WINDOW SHATTERED WHILE DRIVING FOR NO REASON AT ALL. NOTHING HIT THE WINDOW AND IT JUST POPPED LOUDLY AND SHATTERED.
NHTSA ODI #10068966
48,000 miles · Dec 4, 2003
Air BagsPower TrainService Brakes, Hydraulic
MY 1999 CHEVROLET VENTURE MINIVAN HAS HAD NUMEROUS PROBLEMS. THE ONE I AM MOST CONCERNED WITH IS THE AUTOMATIC TRANSMISSION. THE TRANSMISSION MAKES THE CAR JERK WHEN I EITHER SLOW DOWN OR STOP IN HEAVY TRAFFIC. THIS HAPPENS WHEN I PRESS ON THE ACCELERATOR TO GAIN SPEED AGAIN. IT DOESN'T HAPPEN EVERY TIME BUT MORE OFTEN THAN …
Read full complaint
MY 1999 CHEVROLET VENTURE MINIVAN HAS HAD NUMEROUS PROBLEMS. THE ONE I AM MOST CONCERNED WITH IS THE AUTOMATIC TRANSMISSION. THE TRANSMISSION MAKES THE CAR JERK WHEN I EITHER SLOW DOWN OR STOP IN HEAVY TRAFFIC. THIS HAPPENS WHEN I PRESS ON THE ACCELERATOR TO GAIN SPEED AGAIN. IT DOESN'T HAPPEN EVERY TIME BUT MORE OFTEN THAN NOT. THERE ARE ALSO TIMES WHEN DRIVING DOWN THE ROAD IT WHINES. ALSO HAVE A PROBLEM WITH WHAT I FIGURE IS ELECTRICAL. SOMETIMES THE ABS LIGHT STAYS ON AND THEN EVENTUALLY GOES OFF. ALSO, THE AIR BAG LIGHT COMES ON INTERMITTENTLY. *NLM
NHTSA ODI #10049196
Official recalls
4Dec 22, 2004
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
Aug 21, 2001
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Mar 8, 2001
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence & remedy
Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Apr 12, 1999
VEHICLE DESCRIPTION: PASSENGER MINI VANS. THE LEFT AND/OR RIGHT FRONT LOWER INSULATOR TO CRADLE CENTER METAL SLEEVE IS COLLAPSED, WHICH CAN RESULT IN LOSS OF CLAMP LOAD IN THE JOINT. IF THE CLAMP LOAD IS REDUCED OR LOST, THE BOLT CAN BE LOST OR BROKEN AND THE JOINT CAN SEPARATE.
Consequence & remedy
Consequence: IF NOT REPAIRED, SEPARATION OF THE OPPOSITE SIDE JOINT COULD OCCUR RESULTING IN STEERING SHAFT SEPARATION.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT LOWER CRADLE-TO-SUSPENSION INSULATORS AND THE ATTACHING BOLTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6PE04064 · POWER-SLIDING Door
Opened Sep 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Structure:body:door
SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.
EA03005 · Rear Axle Trailing Arm Failure
Opened Apr 23, 2003 · Closed Jan 12, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02086 · Rear Axle Trailing Arm Failure
Opened Nov 18, 2002 · Closed Apr 9, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:rear
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
Additional source detail variants (2)
Suspension
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
Suspension:rear
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
PE02017 · Shoulder Harness Clip
Opened Feb 11, 2002 · Closed Aug 2, 2002
Status: closed (inferred from source dates) · Seat Belts
No summary supplied.
PE00045 · Air Bag Tear During Deployment
Opened Nov 3, 2000 · Closed Jan 11, 2001
Status: closed (inferred from source dates) · Air Bags
No summary supplied.
SQ00014 · Unexpected Opening Of Sliding Door
Opened Jul 25, 2000 · Closed Oct 22, 2001
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Illustration