TL*THE CONTACT OWNS A 1998 CHEVROLET VENTURE. THE CONTACT SHIFTED THE GEAR INTO PARK AND SHUT OFF THE VEHICLE. THE VEHICLE ROLLED AWAY WHILE SHE WAS ASSISTING A CHILD WITH EXITING THE VEHICLE. THE CONTACT RAN TO JUMP INTO THE VEHICLE AND NOTICED THAT THE GEAR SHIFTER WAS VERY UNSTABLE AND HAD A LOT OF "PLAY" OR WIGGLE. SHE D…
Read full complaint
TL*THE CONTACT OWNS A 1998 CHEVROLET VENTURE. THE CONTACT SHIFTED THE GEAR INTO PARK AND SHUT OFF THE VEHICLE. THE VEHICLE ROLLED AWAY WHILE SHE WAS ASSISTING A CHILD WITH EXITING THE VEHICLE. THE CONTACT RAN TO JUMP INTO THE VEHICLE AND NOTICED THAT THE GEAR SHIFTER WAS VERY UNSTABLE AND HAD A LOT OF "PLAY" OR WIGGLE. SHE DEPRESSED THE BRAKE PEDAL AND THE VEHICLE CAME TO A STOP. PRIOR TO THIS FAILURE, THE TAIL LIGHTS FAILED IN FEBRUARY OF 2007. AT THAT TIME, SHE WAS INFORMED THAT SHE NEEDED NEW CIRCUIT BOARDS. WITHIN A YEAR, THE FAILURES RECURRED. THE CIRCUIT BOARDS BURNED OUT AND THE DEALER STATED THAT THE PLUG FOR THE BOARDS WAS BURNED OUT AS WELL, WHICH WOULD CAUSE THE FAILURES TO CONTINUE. THE FAILURE MILEAGE WAS 130,000 AND CURRENT MILEAGE WAS 168,000.
NHTSA ODI #10262259
Mileage unknown · Aug 15, 2007
Exterior Lighting
DRIVERS SIDE BRAKE LIGHT. IT KEEPS BURNING OUT THE BULBS. IT MELTS THE PLASTIC AROUND THE METAL LINE, THE PART THAT IT PLUGS INTO. I HAVE TALKED TO OTHER PEOPLE THAT HAS THE SAME PROBLEM. *JB
NHTSA ODI #10199739
Mileage unknown · Aug 14, 2007
Exterior Lighting
1998 CHEVROLET VENTURE HEADLIGHT ASSEMBLY. CONSTANT CONDENSATION/MOISTURE INSIDE DRIVE AND PASSENGER SIDE UNITS CAUSING A FOGGY OR BURNED EFFECT AND RENDERING HEADLIGHTS VIRTUALLY USELESS. AFTER MANY YEARS, I'VE NOTICED MANY DIFFERENT MODEL YEARS OF THE VENTURE AND ITS OLDSMOBILE COUSIN HAVE THE SAME PROBLEM. THE HEADLIGHT ASSE…
Read full complaint
1998 CHEVROLET VENTURE HEADLIGHT ASSEMBLY. CONSTANT CONDENSATION/MOISTURE INSIDE DRIVE AND PASSENGER SIDE UNITS CAUSING A FOGGY OR BURNED EFFECT AND RENDERING HEADLIGHTS VIRTUALLY USELESS. AFTER MANY YEARS, I'VE NOTICED MANY DIFFERENT MODEL YEARS OF THE VENTURE AND ITS OLDSMOBILE COUSIN HAVE THE SAME PROBLEM. THE HEADLIGHT ASSEMBLY SHOULD BE REPLACED, AT NO CHARGE, FORM THE AUTO MAKER. *JB
NHTSA ODI #10199585
Mileage unknown · Nov 30, 2006
Exterior Lighting
MY HEADLIGHT LENSES HAVE FALLEN OFF ON THREE SEPARATE OCCASIONS. THIS IS CLEARLY A FAULTY DESIGN AS THE LENSES ARE MERELY GLUED ON THE FRONT OF THE HEADLIGHT ASSEMBLY. BECAUSE OF THE GLUE WEARING AWAY ON THE HEADLIGHT COVER, WATER GETS INTO THE ASSEMBLY AND CAUSES THE HALOGEN LIGHTS TO SHORT OUT. THIS TO ME IS A VERY SERIOUS …
Read full complaint
MY HEADLIGHT LENSES HAVE FALLEN OFF ON THREE SEPARATE OCCASIONS. THIS IS CLEARLY A FAULTY DESIGN AS THE LENSES ARE MERELY GLUED ON THE FRONT OF THE HEADLIGHT ASSEMBLY. BECAUSE OF THE GLUE WEARING AWAY ON THE HEADLIGHT COVER, WATER GETS INTO THE ASSEMBLY AND CAUSES THE HALOGEN LIGHTS TO SHORT OUT. THIS TO ME IS A VERY SERIOUS PROBLEM. I THINK THAT THE MANUFACTURER SHOULD ADMIT TO THIS AND RECALL THE VANS AND REPLACE WITH A NEW DESIGN. WHY DOES IT ALWAYS TAKE SOMEONE'S DEATH AND A LAWSUIT TO GET SOMETHING TAKEN CARE OF. I HAVE HAD TO REPLACE THE LIGHTS THREE TIMES. THE LAST TIME I PUT DUCT TAPE AROUND THE OUTSIDE OF THE LENSES TO KEEP THEM ON. WHY SHOULD I HAVE TO DO THAT??? *JB
NHTSA ODI #10174757
93,000 miles · Dec 20, 2005
Exterior Lighting
I OWN A 1998 CHEVY VENTURE MINIVAN AND ON THE DATE SPECIFIED I WAS OUT WITH MY FAMILY ( A SNOWY EVENING) WHEN I WENT TO APPLY THE BRAKES AND MY TURN SIGNALS ON MY DASH WENT TO A SOLID GREEN. AS I APPROACHED THE RED LIGHT A PERSON IN THE CAR NEXT TO ME ADVISED ME THAT I HAD NO TAILLIGHTS. AFTER GETTING HOME I DID SOME RESEARCH …
Read full complaint
I OWN A 1998 CHEVY VENTURE MINIVAN AND ON THE DATE SPECIFIED I WAS OUT WITH MY FAMILY ( A SNOWY EVENING) WHEN I WENT TO APPLY THE BRAKES AND MY TURN SIGNALS ON MY DASH WENT TO A SOLID GREEN. AS I APPROACHED THE RED LIGHT A PERSON IN THE CAR NEXT TO ME ADVISED ME THAT I HAD NO TAILLIGHTS. AFTER GETTING HOME I DID SOME RESEARCH ON THE INTERNET AND FOUND THAT THIS IS A WIDESPREAD PROBLEM WHERE IF MOISTURE GETS INTO THE CONNECTOR ON THE BRAKE LIGHT ASSEMBLY, IT WILL CAUSE THE GROUND CONNECTOR TO SHORT OUT AND CAUSE THE BRAKE LIGHTS TO DO SOME CRAZY THINGS AS WELL AS THE CRUISE CONTROL TO DISENGAGE AT CERTAIN TIMES. *NM
NHTSA ODI #10145715
130,000 miles · Nov 14, 2005
Exterior Lighting
DT: THE CONTACT STATED THAT THE RIGHT FRONT HEADLIGHT LENS CAME OFF THREE TIMES AND THE LEFT ONCE. THEY REPLACED THE ENTIRE HEAD LAMP TWICE ON THE RIGHT SIDE. THE PROBLEM OCCURRED AGAIN. *AK
NHTSA ODI #10142629
62,000 miles · Nov 10, 2005
Exterior Lighting
DT: THE CONTACT STATES WHEN APPLYING THE BRAKES BOTH HEADLIGHTS SEPARATED FROM THE VEHICLE. HE REPLACED THE HEADLIGHTS IN THE VEHICLE. THE VEHICLE HAS NOT BEEN INSPECTED TO DETERMINE WHY THIS HAPPENED. HE HAS NOT CONTACTED THE MANUFACTURER. *AK UPDATED 11/30/05. *JB
NHTSA ODI #10142391
52,000 miles · Mar 25, 2005
Engine And Engine CoolingExterior Lighting
THE 1997-2000 VENUTURES HAVE PROBLEMS WITH THE ENGINES, THE INTAKE GASKET BREAKS DOWN CAUSING ANTI FREEZE TO MIX WITH THE ENGINES OIL CAUSING THE CAM SHAFT TO CRACK, IN OUR CASE THERE WAS NO LEAKS UNDER THE VAN AND THERE WAS NO WARNING EITHER THE VAN WAS RUNNING WELL THAT MORNING AND WHEN MY WIFE WAS DRIVING DOWN THE STREET THER…
Read full complaint
THE 1997-2000 VENUTURES HAVE PROBLEMS WITH THE ENGINES, THE INTAKE GASKET BREAKS DOWN CAUSING ANTI FREEZE TO MIX WITH THE ENGINES OIL CAUSING THE CAM SHAFT TO CRACK, IN OUR CASE THERE WAS NO LEAKS UNDER THE VAN AND THERE WAS NO WARNING EITHER THE VAN WAS RUNNING WELL THAT MORNING AND WHEN MY WIFE WAS DRIVING DOWN THE STREET THERE WAS 2 SHORT BUKLES FROM THE VAN AND EVERYTHING SHUT DOWN INCLUDING STEERING WHICH WAS DIFFICULT TO DO, IS IT GOING TO TAKE SOMEONES FAMILY TO DIE ON THE SIDE OF THE ROAD BEFORE GM WILL DO ANYTHING ABOUT THIS IF MY WIFE HAD BEEN ON THE HIGHWAY THEN THERE WOULD BE NO WAY THAT SHE WOULD HAVE MADE IT WITHOUT BEING HIT, EVEN THEN SHE HAD 3 YOUNG CHILDREN IN THE VAN AGES 3-8 AND WAS ALMOST HIT FROM BEHIND, BECAUSE IT WAS AN INDUSTRIAL HIGHWAY SPEED LIMIT OF 50MPH AND NOT MUCH ROOM ON THE SHOULDER TO PARK. THERE ARE MANY COMPLAINTS ABOUT THESE VANS AND YET NO ONE SEEMS TO BE DOING ANYTHING. THIS WEBSITE HAS COMPLAINT AFTER COMPLAINT, WWW. COMPLAINTS.COM AND WWW.GM-V6LEMONS.COM HAS HUNDREDS OF COMPLAINTS ALONG WITH OTHER WEBSITES OF PEOPLE EXPERANCING THE SAME PROBLEM. HOW MANY PEOPLE HAVE TO DIE BEFORE ANYTHING IS DONE? GM DOESN'T SEEM TO CARE EVEN THOUGH THEIR DEALERSHIPS HAVE STATED THEIR IS A PROBLEM WITH THE ENGINES. ENGINE SHUT OFF AND FAILURE ARE SERIOUS PROBLEMS . *AK
NHTSA ODI #10114737
Mileage unknown · Jan 22, 2005
Engine And Engine CoolingExterior Lighting
WATER BUILD UP INTO THE FRONT HEAD LIGHTS AND WATER BUILD UP IN THE ENGINE. HAD TO REPLACE LIGHTS AND ENGINE AFTER LIGHTS WERE REPLACED WE HAD TO DRILL A HOLD BELOW THE LIGHT COVERS SO THAT WATER BUILD UP CAN DRAIN FROM HOLE. HAD TO REPLACE THE ENGINE.
NHTSA ODI #10107725
75,000 miles · Aug 29, 2004
Exterior Lighting
IN FEB./MARCH 2004, RIGHT HEADLIGHT ASSEMBLY LENS FELL OFF, EXPOSING LAMP TO WEATHER. IN JULY 2004, LEFT HEADLIGHT LENS FELL OFF. WE HAD TO REPLACE THE ENTIRE ASSEMBLY IN BOTH CASES. COST ABOUT $160 EACH TIME. DEALER INSTALLED NEW ASSEMBLIES AND TOLD US THE FAILURE IS DUE TO ADHESIVE BREAKDOWN BUT NOT COVERED BY CHEVROLET. …
Read full complaint
IN FEB./MARCH 2004, RIGHT HEADLIGHT ASSEMBLY LENS FELL OFF, EXPOSING LAMP TO WEATHER. IN JULY 2004, LEFT HEADLIGHT LENS FELL OFF. WE HAD TO REPLACE THE ENTIRE ASSEMBLY IN BOTH CASES. COST ABOUT $160 EACH TIME. DEALER INSTALLED NEW ASSEMBLIES AND TOLD US THE FAILURE IS DUE TO ADHESIVE BREAKDOWN BUT NOT COVERED BY CHEVROLET. THE VEHICLE IS A 1998 CHEVY VENTURE LS WITH 75000 MILE IN FEB AND 80000 MILES IN JULY. *JB
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence & remedy
Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: PASSENGER MINI VANS EQUIPPED WITH BUCKET SEATS OR A SPLIT BENCH SEAT IN THE SECOND (MIDDLE) OR THIRD (BACK) ROW. THE SEAT LATCH MECHANISMS ON BUCKET SEATS AND ON THE 40% PORTION OF THE SPLIT BENCH SEAT IN THE SECOND AND THIRD ROWS DO NOT HAVE PROTECTIVE COVERS.
Consequence & remedy
Consequence: WHEN ACTIVATING THE RELEASE MECHANISM TO ROLL A BUCKET SEAT FORWARD, A CUSTOMER'S FINGER(S) COULD BE SEVERELY INJURED OR SEVERED IN THEY ARE NOT KEPT CLEAR OF THE MECHANISM.
Remedy: DEALERS WILL INSTALL PROTECTIVE COVERS ON THE OUTBOARD LATCH MECHANISMS ON ALL LEFT AND RIGHT HAND REAR BUCKET SEATS IN THE SECOND AND THIRD ROW, AND TO BOTH INBOARD AND OUTBOARD LATCH MECHANISMS ON THE CENTER REAR BUCKET SEAT AND THE 40% PORTION OF THE SPLIT BENCH SEAT.
VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES MAY HAVE (1) A BROKEN SHIFT CABLE FITTING OR (2) LOOSE SHIFT LINKAGE. CONSEQUENTLY, MOVING THE SHIFT LEVER TO A 'PARK' POSITION MAY NOT SHIFT THE TRANSMISSION TO 'PARK'.
Consequence & remedy
Consequence: THE VEHICLE COULD ROLL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT, AND REPLACE IF NECESSARY, THE AUTOMATIC TRANSAXLE RANGE SELECTOR CABLE.
VEHICLE DESCRIPTION: PASSENGER MINI VANS EQUIPPED WITH TRACTION CONTROL SYSTEMS. THE WINDSHIELD WIPER LINKAGE ARM CAN CONTACT A BRAKE LINE WHICH IS CONNECTED TO THE TRACTION CONTROL SYSTEM MODULATOR VALVE. THIS CONTACT CAN CHAFE THE BRAKE LINE RESULTING IN A BRAKE FLUID LEAK.
Consequence & remedy
Consequence: BRAKE FLUID LEAKAGE CAN CAUSE REDUCED BRAKE EFFECTIVENESS AND INCREASED STOPPING DISTANCES.
Remedy: DEALERS WILL INSTALL A BRAKE LINE CLIP TO ENSURE PROPER CLEARANCE. ALSO THE BRAKE LINES WILL BE INSPECTED TO ANY DAMAGE CAUSED BY THIS CONDITION AND WILL REPLACE ANY DAMAGED LINES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7
PE04064 · POWER-SLIDING Door
Opened Sep 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Structure:body:door
SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.
EA03005 · Rear Axle Trailing Arm Failure
Opened Apr 23, 2003 · Closed Jan 12, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
EA02032 · Safety Belt Assembly Failure
Opened Nov 18, 2002 · Closed Nov 21, 2003
Status: closed (inferred from source dates) · Seat Belts
ODI IDENTIFIED 59 REPORTS WITH THE ALLEGED DEFECT.ODI WAS ABLE TO CONTACT 44 OF THE 59 CONSUMERS IN ORDER TO DETERMINE THE SPECIFIC CAUSE OF THE LATCH PROBLEMS.OF THE 44 OWNERS CONTACTED, ODI DETERMINED THAT FOUR FAILURES WERE DUE TO AN OUT-OF-TOLERANCE LATCH PLATE, AND THAT 23 FAILURES WERE DUE TO A DISPLACED BUCKLE HOUSING COVER.THE REMAINING 17 FAILURES HAD INDETERMINABLE CAUSES.OF THE 59 REPORTS, THERE WERE THREE ALLEGED MINOR INJURIES.NO LEGAL CLAIMS OR LAWSUITS HAVE BEEN FILED WITH REGARD TO THIS ALLEGED DEFECT.BASED ON THE LIMITED NUMBER OF REPORTS, AND A DECLINING REPORT TREND, THIS INVESTIGATION IS CLOSED.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEARED TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ADDITIONAL SUMMARY REPORT.
PE02086 · Rear Axle Trailing Arm Failure
Opened Nov 18, 2002 · Closed Apr 9, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:rear
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
Additional source detail variants (2)
Suspension
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
Suspension:rear
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
PE02017 · Shoulder Harness Clip
Opened Feb 11, 2002 · Closed Aug 2, 2002
Status: closed (inferred from source dates) · Seat Belts
No summary supplied.
PE00045 · Air Bag Tear During Deployment
Opened Nov 3, 2000 · Closed Jan 11, 2001
Status: closed (inferred from source dates) · Air Bags
No summary supplied.
SQ00014 · Unexpected Opening Of Sliding Door
Opened Jul 25, 2000 · Closed Oct 22, 2001
Status: closed (inferred from source dates) · Structure
There is no summary currently available
1998 Chevrolet Venture Problems, Complaints & Recalls | Skip That Year
Illustration