NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
552 reportsMileage unknown · Apr 17, 2001
Engine And Engine Cooling
ENGINE JUST STOPS RUNNING WITHOUT WARNING OR SYMPTOMS AS IF THE KEY WERE TURNED OFF. STARTS AGAIN WITHOUT PROBLEM.. NO WARNING LIGHTS ON DASH EXCEPT BATTERY SYMBOL AT TIME OF STALL. COULD BE FATAL IF PASSING ON 2 LANE.. EXTREMELY DANGEROUS ON FREEWAY. COUNTLESS HOURS TRYING TO LOCATE PROBLEM TO NO AVAIL... I TRADED THE CAR. UNSA…
Read full complaint
ENGINE JUST STOPS RUNNING WITHOUT WARNING OR SYMPTOMS AS IF THE KEY WERE TURNED OFF. STARTS AGAIN WITHOUT PROBLEM.. NO WARNING LIGHTS ON DASH EXCEPT BATTERY SYMBOL AT TIME OF STALL. COULD BE FATAL IF PASSING ON 2 LANE.. EXTREMELY DANGEROUS ON FREEWAY. COUNTLESS HOURS TRYING TO LOCATE PROBLEM TO NO AVAIL... I TRADED THE CAR. UNSAFE TO DRIVE.. WORRIED IT WILL BE SOLD WITHOUT BEING FIXED. *AK
NHTSA ODI #744190
Mileage unknown · Apr 16, 2001
Exterior Lighting
TAIL LIGHTS AND TURN SIGNAL LIGHTS KEEP BLOWING OUT. REPLACED BULBS AND WIRING HARNESS ON THREE OCCASIONS WITHIN NINE MONTHS. DEALER NOTIFIED, AND REPLACE THEM. BUT, PROBLEM STILLOCCURRING. FEEL FREE TO PROVIDE ANY FURTHER DETAILS ON THIS MATTER.
NHTSA ODI #886042
Mileage unknown · Apr 10, 2001
Steering
CONSUMER WAS TRAVELING 65MPH ON HIGHWAY AND STEERING WAS LEAKING. STEERING PUMP WENT OUT 70,000 MILES, AND HAD TO BE REPLACED.*AK
NHTSA ODI #885558
Mileage unknown · Apr 9, 2001
Power TrainService Brakes, Air
THE FLOATING DRIVESHAFT WAS INADEQUATELY LUBED CAUSING A POPPING NOISE AT THE DRIVESHAFT YOKE, THE CONSUMER BELIEVES THIS PROBLEM CAUSED DAMAGE TO THE TRANSMISSION. NLM
NHTSA ODI #560722
Mileage unknown · Apr 5, 2001
Steering
FAILURE CAUSED STEERING AT SPEED TO BE DANGEROUSLY SENSITIVE AND STEERING WOULD TORQUE TO THE RIGHT OR LEFT WHEN DECELERATING ON AN OFF-RAMP WHEN SENSOR TRIED TO SWITCH LEVEL OF STEERING ASSIST, AS IF RUNNING OFF ROAD ONTO SHOULDER. DEALER STATES THIS IS A PROBLEM THEY HAVE SEEN AND REPLACED SENSOR OUT OF WARRANTY. WAS NOT OBV…
Read full complaint
FAILURE CAUSED STEERING AT SPEED TO BE DANGEROUSLY SENSITIVE AND STEERING WOULD TORQUE TO THE RIGHT OR LEFT WHEN DECELERATING ON AN OFF-RAMP WHEN SENSOR TRIED TO SWITCH LEVEL OF STEERING ASSIST, AS IF RUNNING OFF ROAD ONTO SHOULDER. DEALER STATES THIS IS A PROBLEM THEY HAVE SEEN AND REPLACED SENSOR OUT OF WARRANTY. WAS NOT OBVIOUS WHAT THE PROBLEM WAS UNTIL I REALIZED THE VEHICLE HAD SPEED SENSITIVE STEERING. MOST DRIVERS WOULD NEVER REALIZE FAILURE HAD OCCURED. SIGNIFICANT PROBABILITY OF CONTRIBUTING TO A LOSS OF CONTROL ACCIDENT.
NHTSA ODI #743591
Mileage unknown · Apr 2, 2001
Service Brakes, Hydraulic
EXCESSIVE WEARING OF BRAKE PADS, BRAKE SHOES DUE TO THE INTERMITTENT ENGAGEMENT OF THE POWER BOOSTER WHILE DRIVING. TOOK VEHICLE WHEN IT FIRST HAD THIS PROBLEM TO TWO DIFFERENT CHEVROLET DEALERSHIPS AND WAS TOLD THAT BECAUSE I COULD NOT PROVE THE BOOSTER'S PREMATURE TRIGGERING THAT IT WOULD NOT BE COVERED UNDER WARRANTY, IN OT…
Read full complaint
EXCESSIVE WEARING OF BRAKE PADS, BRAKE SHOES DUE TO THE INTERMITTENT ENGAGEMENT OF THE POWER BOOSTER WHILE DRIVING. TOOK VEHICLE WHEN IT FIRST HAD THIS PROBLEM TO TWO DIFFERENT CHEVROLET DEALERSHIPS AND WAS TOLD THAT BECAUSE I COULD NOT PROVE THE BOOSTER'S PREMATURE TRIGGERING THAT IT WOULD NOT BE COVERED UNDER WARRANTY, IN OTHER WORDS THEY TOLD ME IF WE DON'T SEE IT AS BEING BROKEN WE AREN'T FIXING IT.. THEY DID NOT ACKNOWLEDGE THE EXISTANCE OF A SAFETY BULLETING SAYING IN FACT THAT THE POWER BOOSTER WAS PRONE TO FAILURE. SINCE THEN I HAVE HAD TO CHANGE OUT THE BRAKE PADS TWICE AT MY OWN EXPENSE. I REPLACED ALL PARTS WITH GMAC FACTORY PARTS AND REPLACED THE POWER BOOSTER WITH A GM REBUILT POWER BOOSTER. *AK
NHTSA ODI #743413
Mileage unknown · Mar 23, 2001
Power Train
THE TRANSMISSION FAILED WHILE DRIVING. NLM
NHTSA ODI #560506
Mileage unknown · Mar 22, 2001
Service Brakes, Hydraulic
WHILE DEPRESSING BBRAKE PEDAL VEHICLE CONTINUED TO TRAVEL WITHOUT ANY INDICATION THAT PEDAL WAS AT FLOORBOARD. PLEASE PROVIDE FURTHER INFORMATION*AK
NHTSA ODI #883815
Mileage unknown · Mar 9, 2001
Tires
I WAS 20 MILES FROM HOME GOING 64 MPH, ON A SLIGHT CURVE. I HEARD AND FELT THE BACK TIRE BLOW THE TIRE WALL FROM THE POINT OF TIRE WEAR TO THE CENTER. I WAS SHOCKED AT THE DAMAGE.. THE TAHOE LEANED SEVERELY TO THE RIGHT, BUT REMAINED UPRIGHT. I HELD THE STEERING WHEEL TIGHT AND STRAIGHT. AND EASED THE TAHOE TO THE SIDE OF THE…
Read full complaint
I WAS 20 MILES FROM HOME GOING 64 MPH, ON A SLIGHT CURVE. I HEARD AND FELT THE BACK TIRE BLOW THE TIRE WALL FROM THE POINT OF TIRE WEAR TO THE CENTER. I WAS SHOCKED AT THE DAMAGE.. THE TAHOE LEANED SEVERELY TO THE RIGHT, BUT REMAINED UPRIGHT. I HELD THE STEERING WHEEL TIGHT AND STRAIGHT. AND EASED THE TAHOE TO THE SIDE OF THE ROAD. THE TAHOE WAS HARD TO CONTROL, BUT WAS ABLE TO GET IT TO THE SIDE OF THE HIGHWAY. WHEN THE TIRE BLEW THE TAHOE LEANED SEVERELY TO THE RIGHT. WHEN I GOT OUT OF THE TAHOE, I DISCOVERED THE TIRE HAD SUFFERED CATASTROPHIC FAILURE. THE TIRE COMPLELEY COLLASPED. THE SIDE WALL COMPLETELY BLOW AWAY. THIS TIRE WAS A FULL SIZE SPARE WITH ONLY 4000 MILES ON IT. SQUARE CHUNKS WHERE REMOVED FROM PART OF THE SIDEWALL. THERE WERE A NUMBER OF TEARS IN THE TIRE. FROM THE POINT OF THE TREAD TO THE CENTER.. I CALLED MY HUSBAND ON THE CELL PHONE; HE WAS IN THE MIDDLE OF A TRIAL (HE'S AN ATTORNEY). HE DROVE THE 20 MILES TO THE SITE AND HE WAS SHOCKED AT THE DAMAGE. WE CALLED A TOW TRUCK THE WHEEL ITSELF WAS DAMAGED. AT THIS TIME WE DO NOT KNOW IF THE REAR AXLE IS DAMAGED, IT WILL BE CHECKED OUT TOMORROW. IT'S AT THE DEALERSHIP NOW. NO ONE HAD SEEN ANYTHING LIKE IT. THIS WAS NOT A FLAT, IT WAS AN ENTIRE BLOWOUT. WE STILL HAVE POSSESSION OF THE DEFECTIVE TIRE AND PHOTOS WERE TAKEN AT THE SCENE AND AT THE DEALERSHIP.*AK (TIRESIZE: P2451/76R1)( DOT NUMBER: TIRE SIZE: P2451/76R1 )
NHTSA ODI #742154
Mileage unknown · Mar 7, 2001
Electrical SystemFuel System, Gasoline
THE BATTERY POSITIVE LEAKED ONTO THE BRAKE LINE WHICH IN TURN ATE THROUGH THE BRAKE LINE AND A LOSS OF BRAKE FLUID AND BRAKES WITHOUT WARNING HAPPENED. I WAS TRAVELING AT 40MPH WHEN WENT TO APPLY THE BRAKES AND THEY WENT SLOWLY TO THE FLOOR AS I WAS STOPPING AND THEN DROPPED TO FLOOR AND I WENT THRU THE MIDDLE OF A INTERSECTION…
Read full complaint
THE BATTERY POSITIVE LEAKED ONTO THE BRAKE LINE WHICH IN TURN ATE THROUGH THE BRAKE LINE AND A LOSS OF BRAKE FLUID AND BRAKES WITHOUT WARNING HAPPENED. I WAS TRAVELING AT 40MPH WHEN WENT TO APPLY THE BRAKES AND THEY WENT SLOWLY TO THE FLOOR AS I WAS STOPPING AND THEN DROPPED TO FLOOR AND I WENT THRU THE MIDDLE OF A INTERSECTION (I THANK GOD THAT TRAFFIC WAS LIGHT). I SEE THAT IN THIS DATA BASE THAT THIS IS COMMON PROBLEM AND I CAN'T BELIEVE THAT THIS IS NOT A RECALL. HOW MANY PEOPLE HAVE TO BE HURT OF KILLED BEFORE GMC DOES SOMETHING ABOUT THIS. I HAVE PURCHASED 8 NEW GM VEHICLES IN THE LAST 10 YEARS AND IF THIS IS THE WAY THEY ARE GOING TO TREAT CUSTOMERS, I WILL NOT BUY ANOTHER. NEEDLESS TO SAY THE VEHICLE WILL BE FOR SALE AS SOON AS IT IS FIXED AND ANOTHER BRAND WILL BE CONSIDERED. *AK
NHTSA ODI #742043
NHTSA investigations
5PE05020 · Unwanted LOW-SPEED Abs Activation
Opened Apr 28, 2005 · Closed Sep 13, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
Additional source detail variants (2)
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
IN A LETTER DATED AUGUST 29, 2005, GM NOTIFIED ODI THAT IT WAS RECALLING CERTAIN MODEL YEAR 1999 THROUGH 2002 C/K PICKUP TRUCKS AND SPORT UTILITY VEHICLES TO CORRECT A PROBLEM WITH ANTI-LOCK BRAKE SYSTEM (ABS) WHEEL SPEED SENSOR CORROSION THAT MAY RESULT IN UNWANTED ABS ACTIVATION AND EXTENDED STOPPING DISTANCES DURING LOW-SPEED BRAKING (RECALL 05V-379).GM'S RECALL COVERS APPROXIMATELY 804,000 VEHICLES CURRENTLY REGISTERED IN THE FOLLOWING 14 SALT-BELT STATES:CONNECTICUT, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WEST VIRGINIA.THE RECALL PROCEDURE WILL INVOLVE REMOVING THE SENSOR, CLEANING THE MOUNTING SURFACE, APPLYING A RUST INHIBITOR (ZINC-X) TO THE SURFACE, AND REINSTALLING THE SENSOR.IF NECESSARY, THE SENSOR WILL BE REPLACED. THE POPULATION AND FAILURE REPORT DATA GIVEN IN THIS RESUME ARE FOR THE FULL REGION THAT HAS BEEN CONSIDERED BY ODI AS THE SALT-BELT.THAT INCLUDES DELAWARE, IOWA, MARYLAND, MINNESOTA, MISSOURI, WISCONSIN AND THE DISTRICT OF COLUMBIA IN ADDITION TO THE 14 STATES INCLUDED IN 05V-379.THE STATES COVERED BY GM'S RECALL HAVE THE HIGHEST INCIDENT RATES FOR THE SUBJECT CONDITION, ACCOUNTING FOR 91% OF THE INCIDENTS, BUT ONLY 24% OF SUBJECT VEHICLE SALES IN THE UNITED STATES.ODI'S ANALYSIS DETERMINED THAT 840 OF THE COMPLAINTS, 244 OF THE CRASHES, AND 16 OF THE INJURIES IDENTIFIED IN THIS INVESTIGATION OCCURRED IN THOSE STATES.THE RESULTING INCIDENT AND CRASH RATES ARE 96.2 AND 28.0 PER 100,000 VEHICLES RESPECTIVELY (NOTE:RATES ARE BASED ON VEHICLE SALES, NOT REGISTERED VEHICLES). THE CORRESPONDING NUMBERS IN THE EXCLUDED PORTIONS OF THE SALT-BELT ARE 399,000 VEHICLES, 81 INCIDENTS (20.3 PER 100,000 VEHICLES), 3 CRASHES, AND NO INJURIES.THE STATISTICS IN THE REMAINING 30 STATES ARE 2,406,000 VEHICLES, 168 INCIDENTS (7.0 PER 100,000 VEHICLES), 31 CRASHES, AND ONE INJURY.GM AND ODI ARE CONTINUING TO MONITOR THE PROBLEM EXPERIENCE IN STATES THAT ARE NOT INCLUDED IN THE RECALL.GM WILL PROVIDE ODI WITH UPDATED COMPLAINT, FIELD REPORT, AND WARRANTY DATA IN NOVEMBER 2005.ODI AND GM WILL REVIEW THAT DATA AND ASSESS THE APPROPRIATENESS OF THE CURRENT SCOPE OF THE RECALL AT THAT TIME.
PE03026 · Steel Wheel Rim Fracture
Opened Jun 12, 2003 · Closed Nov 3, 2003
Status: closed (inferred from source dates) · Wheels; Wheels:multi Piece; Wheels:rim
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Wheels
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Wheels:multi Piece
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Wheels:rim
THERE HAVE BEEN LESS THAN 2 COMPLAINTS PER 100,000 SUBJECT VEHICLES RELATED TO THE ALLEGED DEFECT.THE OLDEST VEHICLES (MY 1999) HAVE ONLY 2 COMPLAINTS IN OVER 140 THOUSAND VEHICLES AFTER OVER 4 YEARS IN SERVICE.THE RATE OF WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT IS LESS THAN 0.1%.THERE ARE NO KNOWN INCIDENTS INVOLVING RAPID LOSS OF TIRE PRESSURE OR LOSS OF VEHICLE CONTROL. A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02015 · Throttle Sticking Closed
Opened Aug 1, 2002 · Closed Jan 12, 2004
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THIS INVESTIGATION INVOLVES THE GENERAL MOTORS CORPORATION (GM)THROTTLE BODY (TB) UTILIZED IN MODEL YEAR (MY) 1999-2002 SILVERADO, SIERRA, TAHOE, SUBURBAN, AVALANCHE AND YUKON (SUBJECT VEHICLE(S)) WITH 4.8L, 5.3L, AND 6.0L ENGINES. THE TB VALVE MAY INTERMITTENTLY STICK IN A CLOSED POSITION.IN SUCH A SITUATION, AN OPERATOR MAY APPLY ADDITIONAL ACCELERATOR PEDAL FORCE TO INCREASE ENGINE SPEED.THE APPLICATION OF ADDITIONAL ACCELERATOR PEDAL FORCE, TO OPEN A STUCK THROTTLE VALVE, MAY OPEN THE THROTTLE VALVE MORE THAN INTENDED AND, IN TURN, ACCELERATE THE ENGINE AND VEHICLE MORE THAN INTENDED AND REASONABLY EXPECTED BY THE DRIVER.ON AUGUST 1, 2002, THE OFFICE OF DEFECTS INVESTIGATION (ODI), OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA), OPENED THIS ENGINEERING ANALYSIS.THE INVESTIGATION REVEALED THAT TWO FACTORS MAY CAUSE THE DEFECT: 1) TB MANUFACTURING PROCESS PROBLEMS; AND 2) ACCUMULATION OF DEPOSITS (A PCV SYSTEM BY-PRODUCT) ON OR AROUND THE TB THROTTLE VALVE AND BORE.ODI CONCLUDES THAT THE TB PERFORMS IN A DEFECTIVE MANNER AFTER ANALYZING GM?S DATA SUBMISSIONS, AND TEST DATA COLLECTED BY THE VEHICLE RESEARCH AND TEST CENTER (VRTC).FIFTY-NINE CRASHES ARE ALLEGED TO HAVE OCCURRED AS A RESULT OF GM?S TB DEFECT.THE MAJORITY OF THE CRASHES INVOLVE A SINGLE VEHICLE, ENGAGING IN A CLOSE QUARTER VEHICLE MANEUVER (OR LOW SPEED), AND CAUSING ONLY MINOR PROPERTY DAMAGE.FOUR OUT OF THE FIFTY-NINE CRASHES INVOLVE INJURY, AND THOSE INJURIES WERE MINOR.ALTHOUGH GM?S TB IS DEFECTIVE, BASED ON THE EVIDENCE GATHERED, ODI HAS FOUND THAT THE ACCELERATOR PEDAL FORCE REQUIRED TO OPEN A STUCK THROTTLE VALVE IS NEGLIGIBLE, AND THE THROTTLE VALVE DOES NOT STICK IN THE OPEN POSITION.THEREFORE THIS ENGINEERING ANALYSIS (EA02-015) WILL BE CLOSED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.FOR A DETAILED DISCUSSION OF THE TB COMPONENT AND TESTING, PLEASE SEE THE ATTACHED REPORT.
PE01023 · Seat Belt Anchorage Separation
Opened Jul 17, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
ODI HAS RECEIVED ONE (1) COMPLAINT ALLEGING THAT THE 2ND ROW PASSENGER-SIDE SEAT BELT RELEASE BUCKLE ANCHOR DETACHED FROM SEAT FRAME DURING A SIDE IMPACT CRASH.DURING THE CRASH, THE OCCUPANT WAS THROWN FROM HIS SEAT, PARTIALLY EJECTED THROUGH THE REAR QUARTER WINDOW OF THE VEHICLE.OCCUPANT SUSTAINED INJURY.GM HAS SUBSEQUENTLY CHANGED SEAT BELT ANCHORING DESIGN IN MY 2000. ODI HAS COMPLETED A PRELIMINARY INVESTIGATION AND HAS DETERMINED THAT FURTHER INFORMATION IS NEEDED TO DETERMINE WHETHER A SAFETY DEFECT EXISTS.
EA99011 · Erratic Power Steering Assist While Driv
Opened May 12, 1999 · Closed Feb 27, 2001
Status: closed (inferred from source dates) · Steering
THE OFFICE OF DEFECT INVESTIGATION (ODI) HAS INVESTIGATED ALLEGATIONS OF POWER STEERING ASSIST FLUCTUATIONS IN THE SUBJECT VEHICLES.FOR DETAILS AND A BASIS FOR THE INVESTIGATION CONCLUSIONS, PLEASE SEE THE CLOSING REPORT IN THE EA99-011 PUBLIC FILE.ODI HAS NOT IDENTIFIED A SAFETY-RELATED DEFECT TREND IN THE SUBJECT VEHICLE POPULATION.FUTHER EXPENDITURE OF AGENCY RESOURCES ON THIS SUBJECT DOES NOT APPEAR TO BE WARRANTED AT THIS TIME.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ENGINEERING IS CLOSED.
Illustration