Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 41 of 283 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes, Hydraulic. Review the 73 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Visibility. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
27 crash reports5 fire reports18 injury reports
What owners actually said
283 reports
240,000 miles · Oct 22, 2020
TiresCrash
TL* THE CONTACT OWNS A 1996 CHEVROLET TAHOE EQUIP WITH DEXTEERO DHT2 TIRES, SIZED: P265/75R/16, DOT 01BTHBAC00420, AND LINE: NOT AVAILABLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH AND MAKING A LEFT TURN THE FRONT DRIVERS SIDE TIRE SUDDENLY EXPERIENCED A BLOW OUT CAUSING THE DRIVER TO LOOSE CONTROL OF THE STEER…
Read full complaint
TL* THE CONTACT OWNS A 1996 CHEVROLET TAHOE EQUIP WITH DEXTEERO DHT2 TIRES, SIZED: P265/75R/16, DOT 01BTHBAC00420, AND LINE: NOT AVAILABLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH AND MAKING A LEFT TURN THE FRONT DRIVERS SIDE TIRE SUDDENLY EXPERIENCED A BLOW OUT CAUSING THE DRIVER TO LOOSE CONTROL OF THE STEERING AND CRASHED INTO A GUARD RAIL. NO INJURIES WERE REPORTED. NO POLICE REPORT WAS TAKEN AND THE VEHICLE WAS TOWED AWAY. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER WALMART LOCATED AT 10404 6TH ST RANCH CUCAMONGA CA. NOTIFIED. THE MANUFACTURER WAS NOT NOTIFIED. THE SAME FAILURE MILEAGE WAS APPROXIMATELY 100 FOR THE TIRE. *LN* *BF *TR
NHTSA ODI #11365713
144,906 miles · May 8, 2020
Air Bags
I HAVE A 1996 CHEVY TAHOE WHICH I HAVE BEEN THE ORIGINAL OWNER SINCE NEW. I RECENTLY HAD MAINTENANCE PERFORMED ON THE VEHICLE AND HAD THE SHOP CHECK THE DRIVERS SIDE AIR BAG BECAUSE THE CHECK AIR BAG INDICATOR LIGHT WAS COMING ON DURING THE OPERATION OF THE VEHICLE. THE REPAIR SHOP INDICATED TO ME THAT THE SENSOR NEEDED TO B…
Read full complaint
I HAVE A 1996 CHEVY TAHOE WHICH I HAVE BEEN THE ORIGINAL OWNER SINCE NEW. I RECENTLY HAD MAINTENANCE PERFORMED ON THE VEHICLE AND HAD THE SHOP CHECK THE DRIVERS SIDE AIR BAG BECAUSE THE CHECK AIR BAG INDICATOR LIGHT WAS COMING ON DURING THE OPERATION OF THE VEHICLE. THE REPAIR SHOP INDICATED TO ME THAT THE SENSOR NEEDED TO BE REPLACED BUT THE SENSOR WAS NO LONGER AVAILABLE EVEN AFTER A STATES WIDE SEARCH WAS PERFORMED. I CONTACTED GENERAL MOTORS ONLY TO FIND OUT THE PART HAS BEEN DISCONTINUED AND NO REPLACEMENT PART IS AVAILABLE. THE PART NUMBER FROM GM IS #16162465 AND THERE IS NO AFTER MARKET PARTS. IS GENERAL MOTORS STILL RESPONSIBLE FOR A REPLACEMENT PART FOR THIS REQUIRED SAFETY ITEM OR WHAT DO YOU SUGGEST I DO TO CORRECT THIS PROBLEM? *TR
NHTSA ODI #11323878
170,000 miles · May 3, 2016
Service BrakesCrash
TL* THE CONTACT OWNS A 1996 CHEVROLET TAHOE. WHILE DRIVING APPROXIMATELY 5 MPH AND PUSHING ANOTHER VEHICLE, THE BRAKES FAILED WHEN THE BRAKE PEDAL WAS DEPRESSED. AS A RESULT, BOTH VEHICLES CRASHED INTO A WALL. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS NOT DIAGNOSED NOR…
Read full complaint
TL* THE CONTACT OWNS A 1996 CHEVROLET TAHOE. WHILE DRIVING APPROXIMATELY 5 MPH AND PUSHING ANOTHER VEHICLE, THE BRAKES FAILED WHEN THE BRAKE PEDAL WAS DEPRESSED. AS A RESULT, BOTH VEHICLES CRASHED INTO A WALL. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.
NHTSA ODI #10862771
80 miles · Jul 20, 2014
Electrical SystemVisibility/wiper
MY HUSBAND WAS DRIVING OUR 1996 TAHOE WHEN IT JUST STOPPED! WE FOUND THAT THE KEY HAD SHUT OFF WHILE DRIVING. WE WERE IN THE MIDDLE OF A THRUWAY WHEN EVERYONE WAS DRIVING 60 MPH. A VERY DANGEROUS SITUATION INDEED. THIS HAS HAPPENED 3 TIMES IN THE YEAR I'VE OWNED THE VEHICLE. WE ARE ALSO HAVING A PROBLEM WITH THE WIPERS WOR…
Read full complaint
MY HUSBAND WAS DRIVING OUR 1996 TAHOE WHEN IT JUST STOPPED! WE FOUND THAT THE KEY HAD SHUT OFF WHILE DRIVING. WE WERE IN THE MIDDLE OF A THRUWAY WHEN EVERYONE WAS DRIVING 60 MPH. A VERY DANGEROUS SITUATION INDEED. THIS HAS HAPPENED 3 TIMES IN THE YEAR I'VE OWNED THE VEHICLE. WE ARE ALSO HAVING A PROBLEM WITH THE WIPERS WORKING INTERMITTENTLY AND SOMETIMES GET STUCK IN THE MIDDLE OF THE WINDSHIELD OR JUMPING ACROSS THE WINDSHIELD POP, POP, POP.ETC. *TR
NHTSA ODI #10614814
125,000 miles · Nov 18, 2013
Vehicle Speed Control
VEHICLE STOP SHUT DOWN COMPLETE WITH JERKING BEFORE SHUTTING DOWN STOP PULLING AND LOST ALL POWER NOW SERVICE ENGINE LIGHT IS ON AND ANTI-LOCK BRAKE LIGHT IS ON AND WANT SHIFT INTO SECOND GEAR AS IF SOMETHING IS WRONG WITH TRANSMISSION. *TR
NHTSA ODI #10552736
110,000 miles · Aug 21, 2013
Structure
PAINT STARTED CHIPPING/PEELING OFF FROM DRIVERS FRONT FINDER AND HOOD IN APPROX. 2009 TO TODAYS DATE (08/21/2013). PS WE ARE THE ORIGINAL OWNERS AND OUR TAHOE HAS BEEN KEPT UP IN TOP CONDITION. *TR
NHTSA ODI #10536532
130,000 miles · Oct 7, 2011
Service Brakes, Hydraulic
UNWANTED ANTILOCK BRAKE ACTIVATION AT LOW SPEED STARTED INTERMITTENT NOW CONSISTENT IN UNWANTED ACTIVATION RESULTING IN INCREASED STOPPING DISTANCE. THERE IS A CURRENT CAMPAIGN FOR 1999-2002 THAT SHOULD BE EXPANDED TO INCLUDE 1996 VEHICLES. CAMPAIGN NO. 05V379000. *TR
NHTSA ODI #10429051
50,000 miles · Jun 12, 2011
Seats
DRIVER POWER SEAT WILL NOT OPERATE . I HAVE READ SIMILAR COMPLAINTS ON THE WEB ABOUT THE FAILURE OF SEAT WORKING PROPERLY AND HAS THERE BEEN A RECALL? I HAVE OWNED THE VEHICLE NEW AND THE ONLY DRIVER. I ONLY WEIGHT 90LBS. *TR
NHTSA ODI #10406037
53,000 miles · Dec 16, 2010
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 1996 CHEVROLET TAHOE. WHILE DRIVING APPROXIMATELY 25 MPH THE BRAKES WERE APPLIED AND THE PEDAL EXTENDED TO THE FLOOR. THE VEHICLE WAS TAKEN TO HIS RESIDENCE AND THE CONTACT COULD SEE BRAKE FLUID LEAKING FROM THE BRAKE LINES. THE FAILURE WAS NOT DIAGNOSED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CU…
Read full complaint
TL*THE CONTACT OWNS A 1996 CHEVROLET TAHOE. WHILE DRIVING APPROXIMATELY 25 MPH THE BRAKES WERE APPLIED AND THE PEDAL EXTENDED TO THE FLOOR. THE VEHICLE WAS TAKEN TO HIS RESIDENCE AND THE CONTACT COULD SEE BRAKE FLUID LEAKING FROM THE BRAKE LINES. THE FAILURE WAS NOT DIAGNOSED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 53,000.
NHTSA ODI #10370953
140,000 miles · Nov 12, 2010
Air Bags
TL*THE CONTACT OWNS A 1996 CHEVROLET TAHOE. WHILE THE VEHICLE WAS PARKED, THE CONTACT STATED THAT THE FRONT RIGHT AND LEFT FRAME RAILS FOR THE AIR BAG SENSOR WERE SEPARATING AND ROTTING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE PARTS FOR REPAIR WERE NO LONGER MANUFACTURED. THE VEHICLE HAD NOT BEEN REPAIR…
Read full complaint
TL*THE CONTACT OWNS A 1996 CHEVROLET TAHOE. WHILE THE VEHICLE WAS PARKED, THE CONTACT STATED THAT THE FRONT RIGHT AND LEFT FRAME RAILS FOR THE AIR BAG SENSOR WERE SEPARATING AND ROTTING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE PARTS FOR REPAIR WERE NO LONGER MANUFACTURED. THE VEHICLE HAD NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 140,000.
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7
EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
PE01023 · Seat Belt Anchorage Separation
Opened Jul 17, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Seat Belts:front:anchorage
ODI HAS RECEIVED ONE (1) COMPLAINT ALLEGING THAT THE 2ND ROW PASSENGER-SIDE SEAT BELT RELEASE BUCKLE ANCHOR DETACHED FROM SEAT FRAME DURING A SIDE IMPACT CRASH.DURING THE CRASH, THE OCCUPANT WAS THROWN FROM HIS SEAT, PARTIALLY EJECTED THROUGH THE REAR QUARTER WINDOW OF THE VEHICLE.OCCUPANT SUSTAINED INJURY.GM HAS SUBSEQUENTLY CHANGED SEAT BELT ANCHORING DESIGN IN MY 2000. ODI HAS COMPLETED A PRELIMINARY INVESTIGATION AND HAS DETERMINED THAT FURTHER INFORMATION IS NEEDED TO DETERMINE WHETHER A SAFETY DEFECT EXISTS.
EA00024 · Headlight
Opened Sep 26, 2000 · Closed Dec 21, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
EA00013 · Battery Leaks Acid
Opened May 2, 2000 · Closed Jun 28, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE00017 · Headlight
Opened Apr 11, 2000 · Closed Sep 26, 2000
Status: closed (inferred from source dates) · Exterior Lighting
BASED ON THE REPORTS RECEIVED BY ODI FROM CONSUMERS, FAILURE OF THE HEADLIGHT ELECTRICAL CIRCUIT MAY OCCUR IN THE SUBJECT VEHICLES, AND MAY RESULT FROM REPEATED ADJUSTMENT OFTHE TILT STEERING WHEEL IN THE SUBJECT VEHICLES.REPEATED ADJUSTMENT OF THE STEERING WHEEL POSITION MAY STRAIN THE WIRING IN THE HEADLIGHT CIRCUIT TO THE POINT OF FAILURE WHERE THEY ARE ATTACHED TO THE MULTI-FUNCTION SWITCH, RESULTING IN THE UNANTICIPATED LOSS OF HEADLIGHTS WHILE THE VEHICLE IS IN MOTION.ODI HAS CONCERNS REGARDING THE HIGH RATE OF WARRANTY REPAIRS FOR PROBLEMS POTENTIALLY ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES, WITH THE RECOGNITION THE EACH INCIDENT OF HEADLIGHT FAILURE REPRESENTS A CONDITION OF VEHICLE DISABLEMENT.IN ADDITION, THE MANUFACTURER'S EVALUATION OF THE ALLEGED DEFECT HAS NOT BEEN RECEIVED, AND THIS OFFICE HAS INTEREST IN THE DETAILS OF THE METHODOLOGIES AND RESULTS OF THAT ASSESSMENT.
PE99073 · Battery Leaks Acid
Opened Dec 3, 1999 · Closed May 2, 2000
Status: closed (inferred from source dates) · Electrical System
ODI HAS RECEIVED 21 COMPLAINTS WHERE OWNERS ALLEGE THAT THE STANDARD GM FACTORY SUPPLIED AC DELCO BATTERY CASE FAILED, RESULTING IN THE LEAKAGE OF SULFURIC ACID.OF THE 21 COMPLAINT VEHICLES, SIX SUBURBAN, THREE TAHOES, AND ONE YUKON OWNER(S) COMPLAINED ABOUT A LOSS OF BRAKE FLUID FROM DETERIORATION OF THE RIGHT FRONTBRAKE LINE AS A RESULT OF SULFURIC ACID CONTAMINATION.THE REMAINING 11 COMPLAINTS PERTAIN PRIMARILY TO SULFURIC ACID LEAKAGE FROM THE BATTERY CASE.AT LEAST ONE COMPLAINANT STATED THAT THE REPLACEMENT BATTERY ALSO FAILED.SEVERAL OF THE COMPLAINANTS NOTE THAT THE LEAKING ACID HAD COME IN CONTACT WITH A WIRE HARNESS AT THE FRAME IN THE VICINITY OF THE STEEL BRAKE LINE.A FIELD INSPECTION BY ODI INDICATES THAT THE DESCRIBED HARNESS IS THE ABS CONNECTION TO THE RIGHT FRONT WHEEL SPEED SENSOR.PRIOR TO THE BATTERY CASE FAILURE, THERE IS USUALLY NO WARNING (SHORT OF AN UNDERHOOD INSPECTION), AND THE ENSURING DAMAGE (SULFURIC ACID CONTAMINATION) IS PROGRESSIVE.OF THE KNOWN BATTERY FAILURES, THERE MAY BE A TEMPERATURE CORRELATION, AS 60% OF THE OWNER COMPLAINTS CAME FROM FOUR STATES; CALIFORNIA, FLORIDA, GEORGIA AND TEXAS.THERE IS ALSO A PRODUCT IMPROVEMENT PROGRAM AND ENGINEERING CHANGE NOTICE TO ADD 1% SILVER TO THE BATTERY'S POSITIVE SIDE TERMINALL, WITH THE EARLIEST IMPLEMENTATION DATE FOR THIS BEING FEB 2, 1998.THE EFFECT OF THIS DESIGN CHANGE IS AS YET UNKNOWN; FURTHER REVIEW IS WARRANTED.AN EA IS BEING OPENED TO GATHER FURTHER APPROPRIATE INFORMATION, CLARIFY ANY DEFECT TRENDS, AND TO ASSESS THE SAFETY IMPLICATIONS AND RISKS CONCERNING THESE FAILURES.
RQ99015 · Front Seat Recliner Bolt Failure
Opened Jul 14, 1999 · Closed Dec 28, 2001
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
No summary supplied.
1996 Chevrolet Tahoe Problems, Complaints & Recalls | Skip That Year
Illustration